Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
920–25K
5125–50K
5550–75K
4475–100K
40100–150K
6150K+
288 reports with mileage · 440 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 287 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
16 crash reports7 fire reports13 injury reports
What owners actually said
728 reports
67,000 miles · Dec 11, 2024
Structure
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V0310000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at approxi…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V0310000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at approximately 65 MPH, the driver’s side A-pillar trim detached. The dealer was contacted. The manufacturer was not made aware of the issue. The failure mileage was 67,000. VIN tool confirms parts not available.
NHTSA ODI #11630118
Mileage unknown · Dec 10, 2024
Power TrainUnknown Or Other
Body control module has went out in the vehicle multiple times. Which causes the battery to die and the vehicle not to start. Part has been replaced multiple times.
NHTSA ODI #11629964
Mileage unknown · Dec 8, 2024
Electrical SystemLane DepartureUnknown Or Other
Radio and back up screen stop working 1 month after purchase.
NHTSA ODI #11629482
Mileage unknown · Dec 6, 2024
Unknown Or Other
The A-pillar appliques on my vehicle are detaching and my windshield vibrates while i drive, putting my family at risk, and others as well. The rubber seal around windshield is coming off on the outside of car. I have reached out to Ford on multiple occasions with no course of action. I have done my research and have let them k…
Read full complaint
The A-pillar appliques on my vehicle are detaching and my windshield vibrates while i drive, putting my family at risk, and others as well. The rubber seal around windshield is coming off on the outside of car. I have reached out to Ford on multiple occasions with no course of action. I have done my research and have let them know since they can not fix the problem, I have contacted a lawyer. Still nothing. When driving my car any speed the windshield vibrates, idling and the windshield vibrates. this is a safety concern for my family. Please help us
NHTSA ODI #11629267
Mileage unknown · Dec 3, 2024
Structure
Exterior A- Left pillar become detached on the interstate and was a hazard to the cars behind, almost caused a crash. Exterior A-Right pillar is loose. I have attempted to get the recall repair completed at a dealership, but have been unsuccessful.
NHTSA ODI #11628612
102,500 miles · Dec 3, 2024
Structure
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the sound of wind wa…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that the sound of wind was heard while driving at speeds 40 MPH or higher coming from the sides of the front windshield. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was 102,500. VIN tool confirms parts not available.
NHTSA ODI #11628477
Mileage unknown · Dec 2, 2024
Structure
The keyless entry panel on driver's side next to driver's window is poorly put on and is starting to come off and could tear off on freeway and cause a safety risk to others. We took the vehicle into a Ford dealership for repairs on some other trim that had a recall and when we received our vehicle back we heard a whistling nois…
Read full complaint
The keyless entry panel on driver's side next to driver's window is poorly put on and is starting to come off and could tear off on freeway and cause a safety risk to others. We took the vehicle into a Ford dealership for repairs on some other trim that had a recall and when we received our vehicle back we heard a whistling noise on drivers side and saw the keyless entry panel trim piece was coming off and when we called back to have them fix they stated they didn't damage it during the other trim work they performed and it isn't part of the recall
NHTSA ODI #11628430
84,000 miles · Dec 2, 2024
Power Train
The contact owns a 2018 Ford Explorer. The contact stated that while approaching a stop sign, the vehicle started shuddering while depressing the brake pedal. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle wa…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while approaching a stop sign, the vehicle started shuddering while depressing the brake pedal. No warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure. The failure mileage was approximately 84,000.
NHTSA ODI #11628231
Mileage unknown · Dec 1, 2024
Unknown Or Other
I first contacted the dealership on July 29, 2024 to set up an appointment and again on Oct. 8, 2024. I took my vehicle to the dealership on 11/22/24 to have the recalls on my vehicle corrected. On pickup I was informed that the pillars had not been fixed became there were no parts available. The following day while driving on …
Read full complaint
I first contacted the dealership on July 29, 2024 to set up an appointment and again on Oct. 8, 2024. I took my vehicle to the dealership on 11/22/24 to have the recalls on my vehicle corrected. On pickup I was informed that the pillars had not been fixed became there were no parts available. The following day while driving on the highway something hit the side of my vehicle. When I arrived at my destination I noticed on the passenger side windshield pillar was missing and the passenger doors were scratched. I’m concerned because the drivers side pillar may fall of and hurt someone. In addition I’m concerned about the windshield falling due to the cracking of the sealant. I need to use my vehicle to go to work.
NHTSA ODI #11628135
138,000 miles · Nov 25, 2024
Air BagsElectrical SystemStructure
The contact owns a 2018 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact noticed that water was leaking in on both sides of the windshield. The contact stated that due to the failure, rainwater was leaking onto instrument panel, causing the instrument panel to become inoperable. The contact st…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated while driving at an undisclosed speed, the contact noticed that water was leaking in on both sides of the windshield. The contact stated that due to the failure, rainwater was leaking onto instrument panel, causing the instrument panel to become inoperable. The contact stated that the air bag warning light was also illuminated. The vehicle was taken to the dealer and the dealer confirmed the failure. The contact was informed that the vehicle was not included in NHTSA Campaign Number: 24V031000 (Structure). The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The approximate failure mileage was 138,000.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration