2018 Ford Explorer

I was driving on a freeway when the engine stopped without warning. The timing chain apparently; slipped and the pistons collided with the alves leaving me stranded on the road. This si a dangerous situation that Ford knows of adn is ignoring. THe car had 101000 miles on it. The car was serviced at 98500 miles by Ford but the timing issue was ignored by the mechanics becasue the computer produced no error codes. The obvious ticking of the engine was the only indication that there was a problem that the mechanics ignored. This is a know premature failure and danger to drivers and the engine should be recalled for repair at Ford's expense. Please issue a safety recall on this engine. ( 3.5L V-Shaped 3.5L Ti-VCT) Consumers are at risk for unexpected breakdowns without warning, at speed, in traffic...

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated while driving 70 MPH, the passenger's side windshield A-pillar trim detached and flew off the vehicle. The vehicle was pulled over to the side of the road and was inspected. The contact observed that the passenger's side A-pillar trim was missing. The vehicle was taken to a dealer, where the contact was advised that there was a related recall associated with the VIN, but the parts were not currently available. The dealer used Gorilla duct tape on both windshield A-pillar trims. The manufacturer was notified of the failure. The failure mileage was 56,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was being serviced at a local car wash, the exterior roof rail rack detached. Upon further inspection, the front driver’s side A-pillar trim fractured, and water was leaking onto the interior, causing damage to the rear mirror power module. The contact stated that the front driver’s side mirror failed to adjust as intended when the control module was in use. The local dealer was contacted; however, parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 74,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was not available. The vehicle was taken to the dealer; however, the vehicle was inspected, and the contact was informed that the parts were not yet available for the repair. The manufacturer was not contacted. The contact had not experienced a failure.

In November 2023, our SUV started to over heat and engine shut off. We noticed the coolant reservoir was bone dry. We added coolant. It was bone dry again within a couple days. We had a mechanic friend diagnose and he told us it is the water pump. We took it to the Ford dealership and we were quoted $3000 to repair it. We could not afford this, so thankfully we met a mechanic that works at dealerships but also repairs on the side. He fixed it for $1000. Flash forward to November 2025 and we notice the heat in our car is not working. Couple weeks later, overheat warning and I'm forced to pull over with my 3 children in the car on a busy highway. Once car cooled down, we went straight home and forfeited our plans. Notice the reservoir is empty again. Refill it. It's empty within a few days. Come to find out, it's the water pump again and Ford dealership wants $4400 this time to fix it and our friend who fixed it last time wants $2000 to fix it. He had another Ford Explorer currently in his shop with the same problem. He said it will continue to fail. We are at a loss. Car overheats almost immediately and loses coolant almost immediately. Ford should HAVE A RECALL ON THE WATER PUMP. Why does the engine have to be pulled out to replace the water pump that is just going to fail every 2 years. I have bought Ford since 2008 and swore I always would buy Ford. I have had 3 Ford vehicles. This experience with this vehicle and the Ford dealerships has changed my opinion. I will never buy Ford again. We are only at 125,000 miles and bought vehicle BRAND NEW in 2018-- so 7 years... just 7 years!

Purchased 5 years ago aprox 100k miles.kept oil changed regularly. Of course parts kept coming off, monk safety clips etc. It's a dime store matcbox wannabe. Then the abs and engine light came on. The computer was acting up and it would do crazy things. Lock and unlock, go into that slow drive as i was pulling into a road. Etc. These would self correct, all but the abs in a matter of minutes. Oh i did have it checked. All that came up was right wheel speed sensor. I paid to have it fixed. Ford dealer told me his news, new sensor bad news still says it's bad. I was moving to another state. Stranger things kept happening. None could find out what was wrong. It started back firing so new plugs and coils. The shop told me after that it still had issues and while no code it was the transmission. It started to violently shake going 70mph. Scared me to death. I sold it and now car shopping. Never Ford again! I have always trusted them but they have compromised on quality, safety and customer loyalty.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that after arriving home and exiting the vehicle, the contact became aware that the A-pillar trim on the driver's side had detached. The dealer was contacted, and it was confirmed that the part to repair the vehicle was not available. Another dealer was contacted, AutoNation Ford Valencia (23920 Creekside Rd, Valencia, CA 91355), and confirmed that the part was not available. The manufacturer was not made aware of the failure. The failure mileage was 84,000.

The contact owns a 2018 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that while driving approximately 70 MPH, there was a loud sound coming from the roof or the side of the vehicle. The vehicle was taken to the residence, and the contact became aware that the passenger’s side A-pillar trim had detached from the windshield. The dealer was contacted and informed the contact that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 90,000.