I first contacted the dealership on July 29, 2024 to set up an appointment and again on Oct. 8, 2024. I took my vehicle to the dealership on 11/22/24 to have the recalls on my vehicle corrected. On pickup I was informed that the pillars had not been fixed became there were no parts available. The following day while driving on …
Read full complaint
I first contacted the dealership on July 29, 2024 to set up an appointment and again on Oct. 8, 2024. I took my vehicle to the dealership on 11/22/24 to have the recalls on my vehicle corrected. On pickup I was informed that the pillars had not been fixed became there were no parts available. The following day while driving on the highway something hit the side of my vehicle. When I arrived at my destination I noticed on the passenger side windshield pillar was missing and the passenger doors were scratched. I’m concerned because the drivers side pillar may fall of and hurt someone. In addition I’m concerned about the windshield falling due to the cracking of the sealant. I need to use my vehicle to go to work.
NHTSA ODI #11628135
Mileage unknown · Nov 19, 2024
Unknown Or Other
THE FRONT SEAL OF WINDSHIELD SEEMS TO BE LETTING QUITE A BIT OF AIR FLOW THROUGH WINDOW INTO VEHILE WHEN DRIVING 35+ MILES/HR. THERE IS A RECALL ON THE PARTICUALAR PART THAT NEEDS TO BE REPLACED. THE VIHICLE HAS YET TO BE INSPECTED BY PROFESSIONAL.
NHTSA ODI #11626256
Mileage unknown · Nov 16, 2024
Unknown Or Other
The clips on my windshield are not holding windshield in properly and the black rubber on outside of windshield is deteriorating and my windshield vibrates while driving.
NHTSA ODI #11625654
Mileage unknown · Oct 27, 2024
EngineUnknown Or Other
Doesn’t want to run right
NHTSA ODI #11622195
Mileage unknown · Oct 9, 2024
Unknown Or Other
Got a letter in February from Ford about recall 24S02/NHTSA recall 24V031and have not seen any updates in the last t months ????
NHTSA ODI #11618912
Mileage unknown · Sep 4, 2024
EngineUnknown Or Other
Check engine light showing. Diagnostic testing shows misfire in cylinder #3. Ford dealership ran diagnostic testing ($169.95) and verified concern and found coolant intrusion cylinder #3. Advised, due to mileage (75,976 miles), replacement of long block. Replacement cost estimated at $11k. No repairs have been performed at…
Read full complaint
Check engine light showing. Diagnostic testing shows misfire in cylinder #3. Ford dealership ran diagnostic testing ($169.95) and verified concern and found coolant intrusion cylinder #3. Advised, due to mileage (75,976 miles), replacement of long block. Replacement cost estimated at $11k. No repairs have been performed at this point due to excessive cost. Second Diagnostic test ($89.95) with independent mechanic - confirmed original verification and found evidence of wear on long block. Mechanic stated that he currently had a Ford Edge in the shop with the same issues. There is currently a class action law suit against Ford for same the issue..
NHTSA ODI #11612635
Mileage unknown · Sep 4, 2024
Unknown Or Other
I am the original owner of my 2018 Ford Explorer. I brought it to my dealership for issues and one was, I have been experiencing a loud intermittent obnoxious noise while driving over 55 mph. Sounds like it is coming from the top of my windshield to the roof, before the sunroof. Nothing is loose, up in this area at all. The BOTT…
Read full complaint
I am the original owner of my 2018 Ford Explorer. I brought it to my dealership for issues and one was, I have been experiencing a loud intermittent obnoxious noise while driving over 55 mph. Sounds like it is coming from the top of my windshield to the roof, before the sunroof. Nothing is loose, up in this area at all. The BOTTOM RUBBER TRIM, all across the bottom of my windshield has come away from the windshield showing deformation in its entirely of large GAPS. The technician confirmed this is where the noise is coming from and is a HAZZARD and needs to be replaced for $500.00. I have extended warranty; however, it does not cover this, BUT FORD SHOULD, IT IS DEFECTIVE !!
NHTSA ODI #11612497
Mileage unknown · Jul 25, 2024
Unknown Or Other
The a-piller trim flew off my car while driving down the highway. I was not in a place where I could pull over, so I am unsure if it hit anyone.
NHTSA ODI #11604545
Mileage unknown · Jul 13, 2024
Unknown Or Other
My cars B Pillar (security pad) became unattached from my car while simply driving down the road. This part detaching caused my liftgate to lock and make me unable to open my truck for anyone and also the part could have fallen into the road way and caused a disturbance or accident to cars behind me. There was no indication of m…
Read full complaint
My cars B Pillar (security pad) became unattached from my car while simply driving down the road. This part detaching caused my liftgate to lock and make me unable to open my truck for anyone and also the part could have fallen into the road way and caused a disturbance or accident to cars behind me. There was no indication of my security pad going to detach from my car and with the current recall on the A Pillars it is safe to believe that manufacturing caused this issue as well with the B Pillars as other Explorer owners have had this similar experience with the vehicles.
NHTSA ODI #11601748
Mileage unknown · May 13, 2024
Unknown Or Other
Back up camera went blue screen. I noticed they had recalls on the 2018's that were manufactured in October of 2018 however my car was manufactured before Oct 2018
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration