2018 Ford Explorer

On Saturday 10/18/2025 the rear drivers side tow link of my 2018 Ford Explorer XLT snapped while driving 70 mph under normal driving conditions on a 4-lane section of i-75 in Detroit, MI. This caused a loss of steering, and my family and almost hit the median concrete wall when it sharply veered to the left completely unexpectedly. There were no warning sounds or symptoms and happened at random on a straight away. We then spun out doing multiple 360 spins on 2 wheels, almost flipping completely, and landing in the middle 2 lanes. We had a semi truck and another vehicle narrowly miss us. I was able to then move fast enough to the side of the road and avoid being hit by more oncoming traffic. We called 911 and AAA for towing to Suburban Ford of Troy who did an inspection and found the drivers side rear tow link has snapped due to a seized knuckle. There is a recall for the exact same known issue in the 2011-2017 Ford Explorers. My wife’s 2017 explorer has the same parts as my 2018 and has the recall for the tow links and ball joint due to this known issue, yet Ford is refusing to acknowledge the issue is still affecting later model years. My Explorer only had 74,000 miles on it and never any accidents or abnormal driving conditions/hard driving. My family and I are extremely lucky to be alive after such a catastrophic failure. This type of issue should never happen on any vehicle and is a totally unacceptable engineering failure. Ford needs to inspect this issue on the later models beyond 2017 as this will cost lives. This will kill people and we are actually in shock that we lived through this. Ford should take responsibility and pay for this repair, as well as the other side the same as they do the years the recalled.

The contact owns a 2018 Ford Explorer. The contact stated while his daughter was driving approximately 35 MPH over a bump in the roadway, the steering wheel turned to the left while driving straight on the roadway. The contact stated that his daughter had not seen warning light illuminated. The contact drove to his daughter location and drove the vehicle to an independent mechanic. The mechanic diagnosed the vehicle and determined that the driver’s side rear wheel rear suspension toe link had fractured and needed to be replaced. The contact stated that the mechanic researched online and related the failure to NHTSA Campaign Number: 21V537000 (Suspension). The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 137,000.

On the highway doing 70 mph when the 2018 explorer started to sway back n forth and skipping across the road, got it stopped on the side of road and found out that my rear drivers toe link has broke. I see FORD has a RECALL on the 2016 - 2017 explorers for this problem... I'm lucky that I didn't kill someone or crash the vehicle. It was not a fun ride with my wife and kids in the SUV.

The contact owns a 2018 Ford Explorer. The contact stated while driving approximately 30-35 MPH, there was an abnormal squeaking sound coming from the rear of the vehicle. The vehicle was taken to an independent mechanic who diagnosed that the bushing joint had fractured and needed to be repaired or replaced. The vehicle had not been repaired. The mechanic referred the contact to the dealer. The vehicle had been taken to the dealer who had confirmed the diagnostic result. The vehicle had been repaired. The manufacturer was made aware of the failure and opened a case regarding the failure. The manufacturer had confirmed that there was no recall on the VIN. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 62,500.

After dealer inspection of my 2018 Ford Explorer, I was informed that the rear knuckles needed replacement due to cracked bushing. I was informed that this is a safety issue that needs to be addressed immediately, at a cost of $2400.00. After some cursory research I found that there was a recall for 2011-2017 Ford Explorers with the same issue, but not for 2018. This is obviously a known problem and should be addressed for 2018 vehicles.

The contact owns a 2018 Ford Explorer. The contact stated while driving at approximately 40 MPH, and at various speeds, the vehicle would vibrate and then would start to sway, and the contact could not maintain lane control. The contact stated no warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the wishbone and motor mounts needed to be replaced; however, the wishbone mount was on a national backorder. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 96,000.

The contact called in for a client who owns a 2018 Ford Explorer. The contact works at an independently owned auto body shop. The contact stated that the vehicle was towed into the body shop for inspection. While inspecting the vehicle, the contact became aware that the driver’s rear toe link had fractured. The contact stated that while the owner of the vehicle was driving at an undisclosed speed, he lost control of the vehicle and spun out, and ran off the road causing damage to the vehicle. The contact stated that he was called by the State Police to tow the vehicle. The contact was unaware of any injuries being sustained during the failure. A police report was filed. The vehicle was not yet repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 59,004.

Driving about 50mph on dry country road, good visibility, when suddenly car pulled hard right. We went onto a grass embankment, I managed to pull left back onto the road, but car fish-tailed uncontrollably, we hit crash barrier, and finally came to a stop. Badly shaken but no injuries. Examining car, besides body damage, most notably rear drivers side wheel was mis-aligned with car by about 15 degrees. Photo of suspension I took shows broken toe-link, subsequently confirmed by body shop and loss adjuster. The car had new rear struts 2 days earlier, but at that time no report of a broken toe-link. I have subsequently learnt there is a recall for broken toe-link for Ford Explorers 2013-2017, but mine is 2018. But I suspect the recall should have been broader - my toe-link looks like one subject to recall.