NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
29 reportsClear category filter131,000 miles · Feb 10, 2023
Engine And Engine Cooling
The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle started overheating. The vehicle was taken to an independent mechanic where it was diagnosed with a faulty water pump. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while driving at an undisclosed speed, the vehicle started overheating. The vehicle was taken to an independent mechanic where it was diagnosed with a faulty water pump. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 131,000.
NHTSA ODI #11506685
74,000 miles · Aug 26, 2022
EngineEngine And Engine Cooling
The contact owns a 2018 Ford Explorer. The contact stated that the low fuel warning light illuminated on the instrument panel and the vehicle was overheating. The vehicle was taken to an independent mechanic who added oil in the vehicle and stated that the water pump needed to be replaced. The mechanic also mentioned an issue wi…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that the low fuel warning light illuminated on the instrument panel and the vehicle was overheating. The vehicle was taken to an independent mechanic who added oil in the vehicle and stated that the water pump needed to be replaced. The mechanic also mentioned an issue with the coolant however, the contact could not recall what was stated. The vehicle was not repaired. The manufacturer was contacted and stated that the VIN was not under recall and referred the contact to the NHTSA Hotline. The approximate failure mileage was 74,000.
NHTSA ODI #11481381
79,000 miles · May 6, 2022
Engine And Engine Cooling
The contact owns a 2018 Ford Explorer. The contact stated the water pump was leaking. While driving, the vehicle overheated and stalled. The overheating message was displayed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure m…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated the water pump was leaking. While driving, the vehicle overheated and stalled. The overheating message was displayed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 79,000.
NHTSA ODI #11463623
Mileage unknown · Feb 7, 2022
Engine And Engine CoolingInjury
The contact owns a 2018 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormally strong odor of fumes throughout the vehicle. The contact stated that there was no warning light illuminated. The contact had to roll down the wind to remove the odor from inside the vehicle. The contact stated …
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that while driving at various speeds, there was an abnormally strong odor of fumes throughout the vehicle. The contact stated that there was no warning light illuminated. The contact had to roll down the wind to remove the odor from inside the vehicle. The contact stated that the odor caused her to constantly be nauseated. The vehicle was taken to the dealer who performed an HVAC update on the vehicle however, the failure recurred. The contact stated that medical attention was not sought. The manufacturer was not made aware of the failure. The failure mileage was unknown.
NHTSA ODI #11450797
40 miles · Oct 3, 2018
Engine And Engine CoolingFire
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT ATTEMPTED TO ACCELERATE TO PASS ANOTHER VEHICLE AND NOTICED AN ABNORMAL ODOR COMING FROM THE AIR CONDITIONING VENTS. THE ODOR SMELLED SIMILAR TO BURNING FUEL. THE VEHICLE WAS TAKEN TO COURTESY FORD (LOCATED AT 1107 BRASHEAR AVE, MORGAN CITY, LA 70380, (985) 492-7260) WHERE I…
Read full complaint
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT ATTEMPTED TO ACCELERATE TO PASS ANOTHER VEHICLE AND NOTICED AN ABNORMAL ODOR COMING FROM THE AIR CONDITIONING VENTS. THE ODOR SMELLED SIMILAR TO BURNING FUEL. THE VEHICLE WAS TAKEN TO COURTESY FORD (LOCATED AT 1107 BRASHEAR AVE, MORGAN CITY, LA 70380, (985) 492-7260) WHERE IT WAS DIAGNOSED THAT THE ODOR EMITTED FROM THE COATING ON THE EXHAUST SYSTEM. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT A SMOKE TEST WAS ALSO PERFORMED ON THE VEHICLE. A REPAIR WAS MADE INSIDE THE DRIVER'S SIDE WHEEL WELL. THE CONTACT TEST DROVE TWO SEPARATE 2018 FORD EXPLORERS AND EXPERIENCED THE SAME ODOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #11133132
1,100 miles · Aug 30, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. WHILE ACCELERATING, EXHAUST FUMES EMERGED AND CAUSED A STRONG ODOR. THE VEHICLE WAS TAKEN TO LAMOUREUX FORD (366 E MAIN ST, EAST BROOKFIELD, MA 01515) WHERE THEY STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR RE…
Read full complaint
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. WHILE ACCELERATING, EXHAUST FUMES EMERGED AND CAUSED A STRONG ODOR. THE VEHICLE WAS TAKEN TO LAMOUREUX FORD (366 E MAIN ST, EAST BROOKFIELD, MA 01515) WHERE THEY STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 1,100. *TT UPDATED 10/17/18*JB
NHTSA ODI #11123460
3,500 miles · Aug 17, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, THERE WAS A SULFUR ODOR COMING THROUGH THE AIR VENTS IN THE VEHICLE. THE FAILURE CAUSED THE CONTACT TO BECOME NAUSEOUS AND DIZZY. THE CONTACT WAS CONCERNED FOR HER SAFETY. WINNER FORD (250 HADDONFIELD-BERLIN RD, CHERRY HILL, NJ, (856) 428-4000) DIAGNOS…
Read full complaint
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, THERE WAS A SULFUR ODOR COMING THROUGH THE AIR VENTS IN THE VEHICLE. THE FAILURE CAUSED THE CONTACT TO BECOME NAUSEOUS AND DIZZY. THE CONTACT WAS CONCERNED FOR HER SAFETY. WINNER FORD (250 HADDONFIELD-BERLIN RD, CHERRY HILL, NJ, (856) 428-4000) DIAGNOSED THAT THE SULFUR ODOR WAS COMING FROM THE EXHAUST AND THE CATALYTIC CONVERTER. THE DEALER INFORMED THE CONTACT THAT THE VEHICLE WAS OPERATING NORMALLY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OPENED A CASE. THE FAILURE MILEAGE WAS 3,500.
NHTSA ODI #11120730
1,143 miles · Jul 31, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. WHILE OPERATING THE VEHICLE, THE ODOR OF EXHAUST FUMES WAS PRESENT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER (KENDALL FORD, 250 E. OVERLAND RD, MERIDIAN, ID), BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. AFTER RETRIEVING THE VEHICLE, THE FAILURE CONTINUED. THE VEHICLE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. WHILE OPERATING THE VEHICLE, THE ODOR OF EXHAUST FUMES WAS PRESENT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER (KENDALL FORD, 250 E. OVERLAND RD, MERIDIAN, ID), BUT THE FAILURE WAS UNABLE TO BE DUPLICATED. AFTER RETRIEVING THE VEHICLE, THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR FURTHER DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 1,143. *TT CONSUMER IS SMELLING A EXHAUST ODOR IN CAB INTER./ POSSIBLE ANOTHER TYPE OF SMELL... CUSTOMER STATES THAT HE JUST GETS A BAD ODOR INTERMITTENTLY THOUGHT IT MIGHT BE EXHAUST. UPDATED 10/23/18*JB
NHTSA ODI #11114950
3,000 miles · Jul 19, 2018
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT STATED THAT EXHAUST FUMES SEEPED INSIDE THE VEHICLE CABIN WHILE DRIVING. THE VEHICLE WAS TAKEN TO HEALEY FORD LINCOLN (2528 NY-17M, GOSHEN, NY 10924, (877) 706-3640) AND WAS REPAIRED AT LEAST TWICE FOR THE FAILURE. THE CONTACT WAS UNAWARE OF THE DIAGNOSIS. HOWEVER, THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 2018 FORD EXPLORER. THE CONTACT STATED THAT EXHAUST FUMES SEEPED INSIDE THE VEHICLE CABIN WHILE DRIVING. THE VEHICLE WAS TAKEN TO HEALEY FORD LINCOLN (2528 NY-17M, GOSHEN, NY 10924, (877) 706-3640) AND WAS REPAIRED AT LEAST TWICE FOR THE FAILURE. THE CONTACT WAS UNAWARE OF THE DIAGNOSIS. HOWEVER, THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 3,000.
NHTSA ODI #11112356
Official recalls
7Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Nov 14, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration