NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
58 reportsClear category filter75,000 miles · May 22, 2024
Electrical SystemStructure
The contact owns a 2018 Ford Explorer. The contact stated that on several occasions the vehicle failed to start. Additionally, while driving at various speeds, the vehicle shut off unintendedly. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the alternator was faulty and needed to be rep…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that on several occasions the vehicle failed to start. Additionally, while driving at various speeds, the vehicle shut off unintendedly. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the alternator was faulty and needed to be replaced. The vehicle was not repaired. The contact stated that the A-pillar trim had detached from the vehicle causing excessive wind noise and water to leak into the cabin of the vehicle. The vehicle was not repaired. The contact was made aware of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 75,000.
NHTSA ODI #11590158
Mileage unknown · Jan 11, 2024
Electrical System
My screen went black for my Ford Explorer. I have no access to climate controls, backup Camera, radio, GPS, etc. My local Ford dealership said there was a recall pending but that’s been a few months now. It’s very dangerous driving like that with my 4 and 2 year old in the car.
NHTSA ODI #11564788
Mileage unknown · Dec 7, 2023
Electrical System
Driver door keypad detacted from pillar. Rear lift gate will not open with button on lift gate, key fob or switch in dash board.
NHTSA ODI #11559023
Mileage unknown · Oct 19, 2023
Air BagsElectrical SystemPower Train
I have owned this vehicle for a year and have gone through three batteries. It shows multiple coded for circuit shorts - Passenger mirror motor, tailgate/liftgate/trunk motor as well as the cinch striker motor, instrument panel which has lost communication with cruise control module, power steering module, battery voltage circui…
Read full complaint
I have owned this vehicle for a year and have gone through three batteries. It shows multiple coded for circuit shorts - Passenger mirror motor, tailgate/liftgate/trunk motor as well as the cinch striker motor, instrument panel which has lost communication with cruise control module, power steering module, battery voltage circuit below threshold, driver side curtain deployment control 1 circuit short to ground, switch illumination. When the vehicle is stopped or parked it constanly idles up to 1000 to 1500 rpms. These are all the codes that are showing on my vehicle. There has to be some sort of issue causing these problems. What happens if my airbag deploys without warning causing me to cause a major accident which can harm myself, my spouse, children and the people around me.
NHTSA ODI #11550814
Mileage unknown · Sep 3, 2023
Electrical SystemFuel/propulsion System
The gas gauge isn’t reading correctly. I’m a mother of a one year old son and I didn’t noticed that my car was reading wrong until I put in gas and it didn’t give me the correct reading. I have spoken to many people who owns a Ford Explorer and they have said the same thing. I don’t even know where to start on why it wouldn’t wo…
Read full complaint
The gas gauge isn’t reading correctly. I’m a mother of a one year old son and I didn’t noticed that my car was reading wrong until I put in gas and it didn’t give me the correct reading. I have spoken to many people who owns a Ford Explorer and they have said the same thing. I don’t even know where to start on why it wouldn’t work. The problem has been reported and I didn’t get a warning. It just stopped reading correctly. There’s nothing on my dashboard, no sign or anything. I am confused.
NHTSA ODI #11542408
Mileage unknown · Aug 26, 2023
Electrical System
When the radio is on, a loud buzzing sound from the radio, do not believe it’s in the speakers
NHTSA ODI #11540899
Mileage unknown · Jul 12, 2023
Electrical SystemFuel/propulsion SystemUnknown Or OtherInjury
I Drove Explorer directly to Mayo Clinic in MN shorty after the purchase. It would smell like sulpher at times, gasoline, exhaust and I was getting very poor fuel economy. Averaging 17-2. I got extremely sick and confused and had severe headaches and nausea, vertigo, congnitive impairments, burning eyes and all I wanted to do w…
Read full complaint
I Drove Explorer directly to Mayo Clinic in MN shorty after the purchase. It would smell like sulpher at times, gasoline, exhaust and I was getting very poor fuel economy. Averaging 17-2. I got extremely sick and confused and had severe headaches and nausea, vertigo, congnitive impairments, burning eyes and all I wanted to do was sleep. I felt fluish and I got confused while going to Mayo for testing. Well, I didn’t make it to my appointment, I couldn’t even figure out how to book a hotel or get cash. I ended up lifeless and chose to stay in the Explorer overnight due to the severe fatigue and confusion. I slept in an open air parking garage and had an electric throw and would start the vehicle occasionally to get warm. Well I ended up so sick and mentally confused and cognitively exhausted my sister called the police to let them know something was wrong with me. I ended up in the hospital for a week. I felt like normal during my days in the hospital, I actually thought that I had been sick from the off gassing of the Explorer, but I couldn’t get away from the smells. I have MCS. After I was released I continued to drive down to Jacksonville Florida for my 3 week outpatient appointment. I was getting terrible fuel economy but I didn’t realize it until I was getting 12 miles a gallon and eventually it went as low as 5 miles per gallon. I was so sick from the odors I didn’t realize how much gas I was going through since I left CO. The Ford at that time in April 2019 had 5,000 miles on it and I was told the reason my fuel economy was so poor along with only getting 5-10 miles per gallon and the frightening smells and sickness were caused by the new emission set up and they refused to listen to my story and symptoms and charged me 500.00 to fix what looked to have been poorly installed. I now have a TBI and severe cognitive and an MRI that shows evidence of Carbon Monoxide Poisoning and things only got worse from there. Thank you.
NHTSA ODI #11531793
25,000 miles · Jul 10, 2023
Electrical SystemStructure
The contact owns a 2018 Ford Explorer. The contact stated that the liftgate failed to open. A message indicating a liftgate failure was displayed. The vehicle was taken to a used car dealer, where the liftgate fuse was replaced twice in one year; however, the failure persisted. The Ford dealer was not notified of the failure. Th…
Read full complaint
The contact owns a 2018 Ford Explorer. The contact stated that the liftgate failed to open. A message indicating a liftgate failure was displayed. The vehicle was taken to a used car dealer, where the liftgate fuse was replaced twice in one year; however, the failure persisted. The Ford dealer was not notified of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 25,000.
NHTSA ODI #11531336
Mileage unknown · Jun 28, 2023
Electrical SystemEnginePower Train
Dealer refuses to repair vehicle without issues being present. States They will only fix it once the problem has arisen.
NHTSA ODI #11529383
Mileage unknown · Apr 5, 2023
Back Over PreventionElectrical SystemUnknown Or Other
The Sync infotainment screen is inoperable and black. My backup camera is no longer operational. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however, the part for the repair was on backorder. Th…
Read full complaint
The Sync infotainment screen is inoperable and black. My backup camera is no longer operational. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the application programming interface module (APIM) needed to be replaced; however, the part for the repair was on backorder. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 98,000.
NHTSA ODI #11515668
Official recalls
7Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Nov 14, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Explorer vehicles equipped with 2.3L or 3.5L GTDI engine. Due to an assembly error, the fuel pressure sensor may leak fuel.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line assembly, free of charge. The recall began December 7, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S35.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
AQ22003 · Hertz/vehicles Rented With Open Recalls
Opened Dec 16, 2022 · No close date supplied
Status: open (inferred from source dates) · Latches/locks/linkages:hood:latch
NHTSA is opening this audit query to investigate whether The Hertz Corporation (Hertz) has complied with the requirements of the National Traffic and Motor Vehicle Safety Act (Safety Act). The Safety Act requires, among other things, that a rental company shall not rent a vehicle subject to a safety recall unless the recall remedy has been performed. 49 U.S.C. § 30120(i).NHTSA is in receipt of information that indicates Hertz rented vehicles to customers without having performed required recall repairs. Accordingly, we are opening this audit query to seek additional information concerning this issue.
Illustration