NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
44 reportsClear category filterMileage unknown · Jun 17, 2026
Fuel/propulsion System
My 2017 Ford Explorer XLT with approximately 236,000 miles has an ongoing EVAP/fuel vapor system problem that causes the vehicle to hesitate, stumble, and attempt to stall. The problem occurs most frequently after refueling and also when the fuel level is low. The check-engine light comes on repeatedly, and despite numerous rep…
Read full complaint
My 2017 Ford Explorer XLT with approximately 236,000 miles has an ongoing EVAP/fuel vapor system problem that causes the vehicle to hesitate, stumble, and attempt to stall. The problem occurs most frequently after refueling and also when the fuel level is low. The check-engine light comes on repeatedly, and despite numerous repair attempts, the issue has not been corrected. Repairs and parts replaced have included the purge valve, EVAP-related sensor(s), charcoal canister(s), and associated tubing. Significant money has been spent diagnosing and repairing this condition, but the symptoms continue. After filling the fuel tank, the engine may run rough, hesitate, lose power, and attempt to stall. This creates a safety concern because the vehicle can unexpectedly lose power or stall while driving, entering traffic, slowing for intersections, or operating in other traffic situations. The condition has persisted despite replacement of multiple EVAP system components. Based on the repeated failures and inability to permanently correct the issue, I believe this may indicate a defect affecting other vehicles of the same model year. I am requesting that this issue be investigated due to the potential safety risk associated with engine hesitation, loss of power, and stalling.
NHTSA ODI #11744673
Mileage unknown · Apr 13, 2026
Electrical SystemEngineFuel/propulsion System
Vehicle experienced white exhaust smoke due to oil entering the exhaust system, caused by turbocharger failure. This led to contamination and failure of all O2 sensors, requiring full replacement, along with replacement of both turbochargers. The radiator also failed and had to be replaced. This appears to be a cascading mechan…
Read full complaint
Vehicle experienced white exhaust smoke due to oil entering the exhaust system, caused by turbocharger failure. This led to contamination and failure of all O2 sensors, requiring full replacement, along with replacement of both turbochargers. The radiator also failed and had to be replaced. This appears to be a cascading mechanical failure affecting multiple major systems, including the engine, fuel/propulsion system, and electrical components, rather than normal wear and tear. The failure rendered the vehicle inoperable, leaving me without transportation during a period of financial hardship. The severity and extent of repairs raise concern about a potential broader defect. This also created a safety concern due to excessive exhaust smoke and reduced vehicle reliability while in operation.
NHTSA ODI #11730931
Mileage unknown · Apr 9, 2026
EngineFuel/propulsion SystemUnknown Or Other
1 WATERPUMP FAILED AND LEAKED WATER INTO MY OIL AND BLEW MY ENGINE. THERE WAS NO WARNING. MY CAR HAD NO POWER AND I COULD NOT DRIVE. I WAS ON THE SIDE OF THE ROAD. THE WATERPUMP IS NOT A RECALL BUT THERE ARE ALOT OF PEOPLE WITH THE SAME ISSUE ON THE SAME MODEL . THE ENGINE WAS REPLACED AT MY EXPENSE. 2. PILLAR/TRIM RECALL IS NO…
Read full complaint
1 WATERPUMP FAILED AND LEAKED WATER INTO MY OIL AND BLEW MY ENGINE. THERE WAS NO WARNING. MY CAR HAD NO POWER AND I COULD NOT DRIVE. I WAS ON THE SIDE OF THE ROAD. THE WATERPUMP IS NOT A RECALL BUT THERE ARE ALOT OF PEOPLE WITH THE SAME ISSUE ON THE SAME MODEL . THE ENGINE WAS REPLACED AT MY EXPENSE. 2. PILLAR/TRIM RECALL IS NOT FIXED AND WATER IS GETTING INTO THE INSIDE OF MY CAR AND SHORTING OUT MY PLUGS AND WIRES AND STAHLING MY CAR WHEN IT RAINS. NO WARNING SIGNS OR LIGHTS FOR EITHER PROBLEM. THE CAR HAS BEEN INSPECTED FOR THE RECAL . I WAS JUST TOLD FORD HAS NOT PROVIDED A REPAIR SOLUTION FOR THE PROBLEM. THIS RECAL IS FROM 1/19/2024
NHTSA ODI #11730171
Mileage unknown · Sep 22, 2025
EngineFuel/propulsion SystemUnknown Or Other
It is known that for the specific year make and model that the water pump goes out around 100,000 miles. This water pump was built as an internal water pump, which is not typical for most cars. in order to fix this part, the engine has to be taken out and lots of parts have to be disassembled Just to get to it. The part Itself i…
Read full complaint
It is known that for the specific year make and model that the water pump goes out around 100,000 miles. This water pump was built as an internal water pump, which is not typical for most cars. in order to fix this part, the engine has to be taken out and lots of parts have to be disassembled Just to get to it. The part Itself is fairly cheap, but the labor cost thousands of dollars due to where it is located. Ford knowingly built this car and put that pump where it is at and therefore should be reliable to pay the cost when it is so common that this part goes out around 100,000 miles. if it is a known issue that occurs on these models frequently then it should become a recall because a failing water pump can cause significant issues within the engine and make the vehicle in operable.
NHTSA ODI #11688865
Mileage unknown · May 28, 2025
EngineFuel/propulsion SystemUnknown Or Other
I am submitting this complaint regarding a recurring turbocharger issue in my 2017 Ford Explorer Sport (VIN: [XXX] ). In April 2024, I was forced to replace the turbocharger system at a cost of approximately $2,500. Despite the repair, my vehicle continues to have serious performance issues. Most recently, the check engine ligh…
Read full complaint
I am submitting this complaint regarding a recurring turbocharger issue in my 2017 Ford Explorer Sport (VIN: [XXX] ). In April 2024, I was forced to replace the turbocharger system at a cost of approximately $2,500. Despite the repair, my vehicle continues to have serious performance issues. Most recently, the check engine light returned, and a diagnostic scan from O’Reilly Auto Parts showed error code P219A – Bank 1 Air/Fuel Ratio Imbalance. This code indicates that the engine is still not functioning correctly—pointing to a likely underlying or unresolved defect. During the initial failure, oil leaked extensively into the engine bay and burned off in thick white smoke while I was driving. It was a serious safety concern, and the cause was consistent with Ford’s existing recall for this engine (NHTSA Campaign Number: 16V925000), which was limited to the Police Interceptor Utility model despite the civilian Sport version using the same 3.5L EcoBoost V6 engine and components. It is extremely concerning that my vehicle—outside of the official recall range—suffered the same turbo failure and now continues to show problems even after a costly repair. Either the mechanic’s initial repair was incomplete, or the core design flaw that caused the issue in the first place is still at play, meaning this problem may continue to repeat itself. I respectfully request that: 1.Ford expand the recall to include vehicles with the same components and failures, regardless of their designation. 2.NHTSA investigate the scope of this issue across the broader 2017 Explorer Sport lineup. 3.Ford provide reimbursement or support for the costly repair, which has not resolved the issue. 4.Ford issue a technical service bulletin or revised part guidance if this is an ongoing engineering issue. I am happy to provide full documentation, photos, and service records if needed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11663525
Mileage unknown · Apr 29, 2025
Fuel/propulsion System
Water pump failure, causing over heating in vehicle , not even 100,000miles. Causing to leave us stranded on the road. Apparently there's a lot of complains for this pump causing issues. Please look into this and start a recall process.
NHTSA ODI #11657431
Mileage unknown · Aug 31, 2024
Electrical SystemEngineFuel/propulsion System
Driving on the highway heard large rattling noise coming from engine loss of power engine light came on battery light came on no acceleration cause to slow down on highway fortunately I was able to get to shoulder had it towed to service shop had p0012 code tensioner may have broken off on timing belt causing low oil pressure an…
Read full complaint
Driving on the highway heard large rattling noise coming from engine loss of power engine light came on battery light came on no acceleration cause to slow down on highway fortunately I was able to get to shoulder had it towed to service shop had p0012 code tensioner may have broken off on timing belt causing low oil pressure and causing engine rattling noise and engine shut down but service garage don’t do that type of work
NHTSA ODI #11611949
Mileage unknown · May 30, 2024
Fuel/propulsion System
FUEL TANK LEAK. Heavy odor of gasoline when tank full. Independent mechanic checked for cause and observed residue around the tank where gasoline had escaped from top of tank. Ford Dealership did a diagnosis and subsequent repair, finding that gasket, on top of the tank at the sending unit/fuel pump had cracked, allowing gaso…
Read full complaint
FUEL TANK LEAK. Heavy odor of gasoline when tank full. Independent mechanic checked for cause and observed residue around the tank where gasoline had escaped from top of tank. Ford Dealership did a diagnosis and subsequent repair, finding that gasket, on top of the tank at the sending unit/fuel pump had cracked, allowing gasoline and fumes to escape. The position is in immediate proximity of the vehicle exhaust pipes. - Repaired by Ford Dealership as an absolute necessity for safety, to avoid a potential fire from gasoline dripping on exhaust pipes either while in motion or parked.
NHTSA ODI #11591514
Mileage unknown · Nov 18, 2023
Fuel/propulsion System
Apparently Ford is aware that there is a know issue with the Ford Explorer Water Pump failure which is causing water pump leakage inside engine mixing coolant and oil. This has been reported by thousands of consumers who are faced with an average cost of about $3000 to get this resolved. This should be considered a recall.
NHTSA ODI #11555800
Mileage unknown · Jul 27, 2023
EngineFuel/propulsion System
The water pump went bad which cost me 1500 dollars and the shop whom done it had replaced 15 water pumps on the exact make and model car as mine this year!
NHTSA ODI #11534879
Official recalls
13Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Consequence & remedy
Consequence: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Mar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Sep 11, 2019
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer vehicles equipped with power front seats. The seat frames may have sharp edges.
Consequence & remedy
Consequence: Occupants my contact the sharp edges when reaching between the power front seat and center console, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will install protective tape on the exposed inside edge and tab of the power seat frames, free of charge. The recall began November 8, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S29.
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.
Consequence & remedy
Consequence: If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Additional source detail variants (2)
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Dec 22, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.
Consequence & remedy
Consequence: An oil leak, in the presence of an ignition source, increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA17002 · Exhaust Odor In Passenger Cab
Opened Jul 27, 2017 · Closed Jan 17, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Illustration