NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
237 reportsClear category filter80,000 miles · Aug 25, 2023
Engine
The contact owns a 2017 Ford Explorer. The contact stated while driving 40 MPH, the vehicle jerked. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the coil and the water pump needed to be replaced. The coil was replaced; however, the w…
Read full complaint
The contact owns a 2017 Ford Explorer. The contact stated while driving 40 MPH, the vehicle jerked. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed and determined that the coil and the water pump needed to be replaced. The coil was replaced; however, the water pump was not replaced. The manufacturer was made aware of the failure and referred the contact to an authorized dealer for diagnostic testing. The vehicle was not repaired. The failure mileage was approximately 80,000.
NHTSA ODI #11540758
Mileage unknown · Aug 18, 2023
Engine
WATER PUMP FAILURE. ENGINE LIGHT CAME ON. BY THE TIME I COULD PULL OFF THE FREEWAY (1 MINUTE) THE ENGINE HAD STALLED AND THE CAR WOULDN'T START. TOWED TO REPAIR SHOP AND LEARNED THE PUMP FAILURE HAD ALLOWED WATER AND OIL TO MIX THROUGHOUT THE ENGINE. METAL SHAVINGS WERE FOUND IN THE ENGINE. ENGINE HAD TO BE REPLACED. TOTAL COST …
Read full complaint
WATER PUMP FAILURE. ENGINE LIGHT CAME ON. BY THE TIME I COULD PULL OFF THE FREEWAY (1 MINUTE) THE ENGINE HAD STALLED AND THE CAR WOULDN'T START. TOWED TO REPAIR SHOP AND LEARNED THE PUMP FAILURE HAD ALLOWED WATER AND OIL TO MIX THROUGHOUT THE ENGINE. METAL SHAVINGS WERE FOUND IN THE ENGINE. ENGINE HAD TO BE REPLACED. TOTAL COST BEFORE THE VEHICLE WAS READY: OVER $11,000
NHTSA ODI #11539317
Mileage unknown · Aug 16, 2023
Engine
I noticed that I had to refill the coolant/water on my car because it was low. When I got out of my work I noticed there was water on the floor, but I didn't think of anything because my car was doing fine. When I was almost home I noticed the car fans were like trying to compensate for the heat, but when I look at my dash. My c…
Read full complaint
I noticed that I had to refill the coolant/water on my car because it was low. When I got out of my work I noticed there was water on the floor, but I didn't think of anything because my car was doing fine. When I was almost home I noticed the car fans were like trying to compensate for the heat, but when I look at my dash. My car was overheating with the engine light. I parked it and noticed the water I put this morning was all gone and the car was still leaking. Come to find out it was the water pump and the engine.
NHTSA ODI #11539028
Mileage unknown · Aug 14, 2023
Engine
2017 Ford Explorer with 114,000 miles. Engine coolant light came on while driving. The car was taken to a Ford Dealer and diagnosed with a failed water pump. As the water pump is installed inside of the engine this is now a major repair and if not caught early, can cause permanent damage to the engine. This failure can cause …
Read full complaint
2017 Ford Explorer with 114,000 miles. Engine coolant light came on while driving. The car was taken to a Ford Dealer and diagnosed with a failed water pump. As the water pump is installed inside of the engine this is now a major repair and if not caught early, can cause permanent damage to the engine. This failure can cause the engine to stop leaving you stranded. Currently having the engine repaired at Ford Auto Nation in Tustin Ca.
NHTSA ODI #11538399
60,000 miles · Aug 7, 2023
EngineEngine And Engine Cooling
The contact owns a 2017 Ford Explorer. The contact took the vehicle to a dealer for routine maintenance and was informed by the service technician that the water pump was leaking coolant into an engine cylinder. The contact was provided an estimate for the repair. The manufacturer was not notified of the failure. The vehicle was…
Read full complaint
The contact owns a 2017 Ford Explorer. The contact took the vehicle to a dealer for routine maintenance and was informed by the service technician that the water pump was leaking coolant into an engine cylinder. The contact was provided an estimate for the repair. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 60,000.
NHTSA ODI #11537007
Mileage unknown · Jul 30, 2023
Engine
Coolant was found to be infiltrating cylinders 2 & 3 of the engine. The engine was idling roughly and just about died before the check engine light came on. The service center did a pressure check and used a bore scope to confirm that there was coolant in the cylinders. My understanding of this problem is that the engine begins …
Read full complaint
Coolant was found to be infiltrating cylinders 2 & 3 of the engine. The engine was idling roughly and just about died before the check engine light came on. The service center did a pressure check and used a bore scope to confirm that there was coolant in the cylinders. My understanding of this problem is that the engine begins to misfire as coolant and oil mix and the cylinder walls start and other components deteriorate. When deterioration is bad enough the engine can quit. This can happen at any time including at high speeds on the highway. I'm not totally sure how long the rough idling had been going on, but the incident where the engine almost died and the check engine light came on was at about 80,000 miles. My guess is that the rough idling started around 70,000 miles -- give or take. Ford has not yet done a diagnostic teardown to determine how the coolant is infiltrating the cylinders, but it is a known problem for other sizes of the Ecoboost engine. I have the 2.3L Ecoboost. There was a recall on the 1.6L Ecoboost and there is a class action lawsuit for the 1.5L, 1.6L, and 2.0L versions of the engine.
NHTSA ODI #11535354
Mileage unknown · Jul 27, 2023
EngineFuel/propulsion System
The water pump went bad which cost me 1500 dollars and the shop whom done it had replaced 15 water pumps on the exact make and model car as mine this year!
NHTSA ODI #11534879
141,000 miles · Jul 25, 2023
EngineEngine And Engine Cooling
The contact owns a 2017 Ford Explorer. The contact stated while driving 65-70 MPH, the engine seized. The contact was able to veer to the side of the roadway. The contact stated that upon attempting to restart the vehicle, the message "No Oil Pressure" was displayed. The vehicle was towed to the dealer, where it was diagnosed th…
Read full complaint
The contact owns a 2017 Ford Explorer. The contact stated while driving 65-70 MPH, the engine seized. The contact was able to veer to the side of the roadway. The contact stated that upon attempting to restart the vehicle, the message "No Oil Pressure" was displayed. The vehicle was towed to the dealer, where it was diagnosed that the head gasket was blown, causing coolant and oil to mix. The dealer diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 141,000.
NHTSA ODI #11534413
Mileage unknown · Jul 24, 2023
Engine
OVERHEATING WARNING ILLUMINATED, RESULTED IN VEHICLE SHUTTING DOWN WHILE BRIEFLY PULLING OVER IN A PARKING LOT TO GET DIRECTIONS TO A SPECIFIC HOSPITAL ENTRANCE. STOP TO SHUT DOWN, ABOUT 1 MIN. THIS HAS OCCURRED A TOTAL OF 7 OTHER TIMES OVER THE COURSE OF THE LAST 12 MONTHS, BEGINNING WITH THE FIRST ONE IN JULY OF 2022. MY WIFE …
Read full complaint
OVERHEATING WARNING ILLUMINATED, RESULTED IN VEHICLE SHUTTING DOWN WHILE BRIEFLY PULLING OVER IN A PARKING LOT TO GET DIRECTIONS TO A SPECIFIC HOSPITAL ENTRANCE. STOP TO SHUT DOWN, ABOUT 1 MIN. THIS HAS OCCURRED A TOTAL OF 7 OTHER TIMES OVER THE COURSE OF THE LAST 12 MONTHS, BEGINNING WITH THE FIRST ONE IN JULY OF 2022. MY WIFE WAS IDLING WHILE AWAITING TO PICK UP THE KIDS FROM A GYMNASTICS CLASS. OVERHEATING WARNING ILLUMINATED, RESULTING IN THE VEHICLE SHUTTING DOWN. A MECHANIC WE KNOW WAS ALSO THERE AWAITING HIS CHILDREN AND DISCOVERED VERY LOW COOLANT LEVEL. IT WAS FILLED & THINGS SEEMED FINE UNTIL THIS SPRING, WHERE IT IS A BI-WEEKLY OCCURRENCE. COOLANT BOTTLES ARE ON STAND-BY AS WE HAVE NO OTHER OPTION. EVEN IF THE WATER PUMP IS FAILING, THIS IS ALL WE HAVE TO WORK WITH. OUR OTHER VEHICLE JUST SHUT DOWN MID-DRIVE IN MARCH. IT WAS TOWED TO THE MECHANIC. HERE WE ARE NEARLY 5 MONTHS LATER AND HE DOESN’T HAVE A GUESS AT WHAT THE PROBLEM MIGHT ACTUALLY BE. THAT VEHICLE, A 2012 FORD FOCUS SE.
NHTSA ODI #11534215
Mileage unknown · Jul 12, 2023
Engine
When driving the vehicle, it displayed a dashboard message "Engine Coolant Over Temperature". The vehicle was brought to the local Ford dealer where it is routinely serviced. Grapevine Ford identified that the water pump needed replacing. The part was $419 but it required 14 hours of labor to install it for a labor charge of …
Read full complaint
When driving the vehicle, it displayed a dashboard message "Engine Coolant Over Temperature". The vehicle was brought to the local Ford dealer where it is routinely serviced. Grapevine Ford identified that the water pump needed replacing. The part was $419 but it required 14 hours of labor to install it for a labor charge of $3,425. While the part failure isn't common but it can happen, 14 hours of labor to replace it is the real issue This is clearly an extremely serious design issue. What can the consumer do? A vehicle is needed & the repair was authorized. Reviewing the NHTSA website, multiple similar complaints were found. However, none of them referenced the extremely high labor charge to replace the water pump, which is the real issue.
NHTSA ODI #11531949
Official recalls
13Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2017-2019 Explorer vehicles. The rear suspension toe links may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will replace the toe links, free of charge. Owner notification letters were mailed on March 16, 2026. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 26S08. This recall is an expansion of previous NHTSA recall number 21V537. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning February 25, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Consequence & remedy
Consequence: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Mar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Sep 11, 2019
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer vehicles equipped with power front seats. The seat frames may have sharp edges.
Consequence & remedy
Consequence: Occupants my contact the sharp edges when reaching between the power front seat and center console, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will install protective tape on the exposed inside edge and tab of the power seat frames, free of charge. The recall began November 8, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S29.
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Aug 28, 2017
Ford Motor Company (Ford) is recalling certain 2017 Explorer, Taurus and Police Interceptor Utility and Sedan vehicles. The steering gear heat shield fasteners may corrode, allowing the heat shield to detach.
Consequence & remedy
Consequence: If the heat shield detaches, the steering gear may overheat, increasing the steering effort required by the driver, especially at lower speeds, and increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers to inspect and replace the heat shield fasteners as needed, free of charge. The recall began on September 13, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S23.
May 22, 2017
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Additional source detail variants (2)
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Seats
Ford Motor Company (Ford) is recalling certain 2017 Ford Explorer, F-150, F-250, F-350, F-450 and F-550 vehicles equipped with a manual driver's seat back recliner mechanism. In the event of a crash, the seat back frame may not restrain the occupant due to having inadequate welds. As such, these vehicles may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202a, "Head Restraints" and 207, "Seating Systems."
Consequence: If the occupant is not adequately restrained in the event of a crash, they have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall began on June 7, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 17C08.
Dec 22, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Taurus, 2016-2017 Ford Flex, Lincoln MKT, 2017 Ford Explorer and Ford Explorer Police Interceptor Utility vehicles equipped with 3.5L GTDI engines. Improperly brazed turbocharger oil supply tubes may leak oil on engine components.
Consequence & remedy
Consequence: An oil leak, in the presence of an ignition source, increases the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect, and if necessary, replace the turbocharger oil supply tubes, free of charge. The recall began on January 31, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S46.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA17002 · Exhaust Odor In Passenger Cab
Opened Jul 27, 2017 · Closed Jan 17, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Illustration