NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
427 reportsClear category filterMileage unknown · Jul 17, 2016
EnginePower TrainService Brakes
HUSBAND WAS DRIVING THE VEHICLE WAS ABOUT TO ACCELERATE TO GET UP A HILL ON A CITY STREET AND ENGINE SOUNDED LIKE TRANSMISSION OR OTHER MAJOR PART JUST "DROPPED". STEERING WHEEL FROZE, CAR IDLED VIOLENTLY, COULD NOT MOVE VEHICLE, STARTED TO ROLL BACKWARDS UNTIL EMERGENCY BRAKE WAS APPLIED.ACCELERATION WENT TO LITERALLY ZERO,SUV …
Read full complaint
HUSBAND WAS DRIVING THE VEHICLE WAS ABOUT TO ACCELERATE TO GET UP A HILL ON A CITY STREET AND ENGINE SOUNDED LIKE TRANSMISSION OR OTHER MAJOR PART JUST "DROPPED". STEERING WHEEL FROZE, CAR IDLED VIOLENTLY, COULD NOT MOVE VEHICLE, STARTED TO ROLL BACKWARDS UNTIL EMERGENCY BRAKE WAS APPLIED.ACCELERATION WENT TO LITERALLY ZERO,SUV WOULD NOT MOVE. ORANGE WRENCH LIGHT CAME ON, STATED TO SEE MANUAL.PLACED CAR IN PARK SHUT OFF ENGINE AND WAITED AND STARTED AT BACK UP AGAIN. SCARRY STUFF, 2 CHILDREN 2 AND YOUNGER IN VEHICLE. WON'T LET ME INPUT ON NEXT PAGE, APPROXIMATELY 25-30 MILES AN HOUR, SUV HAS 5,500 MILES ON IT
NHTSA ODI #10885312
3,921 miles · Jul 15, 2016
Electrical SystemUnknown Or Other
WITH ONLY 3.9 K MILES THE VEHICLE STOPPED ACCELERATION AND TURNED OFF. I WAS ABLE TO TURN THE CAR ON, HOWEVER, THE VEHICLE WOULD ONLY MOVE AT IDLE SPEED WHILE IN DRIVE. FORTUNATELY I HAD ENOUGH TO IDLE MY WAY TO THE SIDE OF THE ROAD. THE PART THAT WENT OUT WAS THE THROTTLE BODY. ALTHOUGH THE MANUFACTURER REPLACED THE PART O…
Read full complaint
WITH ONLY 3.9 K MILES THE VEHICLE STOPPED ACCELERATION AND TURNED OFF. I WAS ABLE TO TURN THE CAR ON, HOWEVER, THE VEHICLE WOULD ONLY MOVE AT IDLE SPEED WHILE IN DRIVE. FORTUNATELY I HAD ENOUGH TO IDLE MY WAY TO THE SIDE OF THE ROAD. THE PART THAT WENT OUT WAS THE THROTTLE BODY. ALTHOUGH THE MANUFACTURER REPLACED THE PART ON THE VEHICLE, I FEEL THAT THEY HAVE BEEN VERY IRRESPONSIBLE IN NOT RECALLING THIS PART AND ADVISING BUYERS THAT THE CAR HAS A "FAULTY" THROTTLE BODY. EVERYONE AT FORD THAT I HAVE SPOKE TO ALMOST IMMEDIATELY KNEW WHAT THE ISSUE LEADING ME TO BELIEVE THAT I AM NOT THE ONLY PERSON THAT HAS HAD THIS ISSUE. THIS ISSUE COULD HAVE CAUSED A SEVERE ACCIDENT IF THE CAR WOULD HAVE SHUT OFF OR DE-CCELERATED WHILE DRIVING AT A HIGH RATE OF SPEED.
NHTSA ODI #10885088
4,538 miles · Jul 10, 2016
EnginePower TrainUnknown Or Other
I WAS DRIVING CLOSE TO MY HOUSE AND ALMOST CAUSED A BIG ACCIDENT WHILE I HAD MY CHILDREN ON BOARD. THE CAR STOPPED COMPLETELY ( SUDDENLY STOPPED) AND LOST POWER, I WAS LUCKY THAT NOT ACCIDENT OCCURRED ( CAN U IMAGINE IF I WAS IN THE MIAMI EXPRESSWAY AND THAT HAPPENED). I'M ATTACHING A PIC SHOWING THE CHECK ENGINE, WRENCH LIGHT …
Read full complaint
I WAS DRIVING CLOSE TO MY HOUSE AND ALMOST CAUSED A BIG ACCIDENT WHILE I HAD MY CHILDREN ON BOARD. THE CAR STOPPED COMPLETELY ( SUDDENLY STOPPED) AND LOST POWER, I WAS LUCKY THAT NOT ACCIDENT OCCURRED ( CAN U IMAGINE IF I WAS IN THE MIAMI EXPRESSWAY AND THAT HAPPENED). I'M ATTACHING A PIC SHOWING THE CHECK ENGINE, WRENCH LIGHT THAT CAME ON WHILE I WAS DRIVING. I DID SOME RESEARCH ONLINE AND FOUND OUT THAT MANY AMERICANS ARE HAVING THE SAME ISSUES, IT IS A DEFECTIVE THROTTLE BODY THAT CAUSES THE VEHICLE TO SLOW DOWN AND SHUTDOWN AT ANY TIME. FORD IS ALREADY AWARE OF THE PROBLEM AND YOU GUYS MORE LIKELY ARE AWARE TOO. WHAT ARE YOU GUYS WAITING TO ISSUE A RECALL?? WAITING FOR SOMEONE TO DIE?
NHTSA ODI #10883791
1,665 miles · Jul 8, 2016
Unknown Or Other
EXHAUST OR BURNING SMELL INSIDE INTERIOR CABIN WHEN ACCELERATING.
NHTSA ODI #10883695
1,000 miles · Jul 8, 2016
EnginePower TrainUnknown Or Other
ON MY 2016 EXPLORER LIMITED 3.5 N/A V6 - UNDER HARD (GETTING ON FWY) OR EXTENDED ACCELERATION (UPHILL CLIMB) EXHAUST FUMES CAN BE NOTICED BY THE PASSENGERS IN THE VEHICLE. I KNOW THERE IS AN OPEN INVESTIGATION ON THE 11-15 YEARS BUT THE 16 SHOULD BE INCLUDED AS WELL. THIS HAS BEEN THE CASE FROM NEW TO CURRENT 11K MILES. THIS …
Read full complaint
ON MY 2016 EXPLORER LIMITED 3.5 N/A V6 - UNDER HARD (GETTING ON FWY) OR EXTENDED ACCELERATION (UPHILL CLIMB) EXHAUST FUMES CAN BE NOTICED BY THE PASSENGERS IN THE VEHICLE. I KNOW THERE IS AN OPEN INVESTIGATION ON THE 11-15 YEARS BUT THE 16 SHOULD BE INCLUDED AS WELL. THIS HAS BEEN THE CASE FROM NEW TO CURRENT 11K MILES. THIS HAPPENED ON MY PREVIOUS 2013 MODEL AS WELL.
NHTSA ODI #10883515
5 miles · Jul 6, 2016
Unknown Or Other
THE 2016 MODEL ALSO HAS THE ODOR FROM THE VENTILATION WHICH IS INVESTIGATED NOW. THE ODOR OCCURS DURING DRIVING AT REGULAR METHODS AFTER THE ENGINE CAN HEAT UP FOR A FEW MILES. THIS "NEW CAR" SMELL WAS CALLED REGULAR HEATING OF NEW PARTS BY THE SALESMAN BUT NOW IT HAS BEEN 3000 MILES AND HE ODOR IS STILL HAPPENING. I JUST WANT…
Read full complaint
THE 2016 MODEL ALSO HAS THE ODOR FROM THE VENTILATION WHICH IS INVESTIGATED NOW. THE ODOR OCCURS DURING DRIVING AT REGULAR METHODS AFTER THE ENGINE CAN HEAT UP FOR A FEW MILES. THIS "NEW CAR" SMELL WAS CALLED REGULAR HEATING OF NEW PARTS BY THE SALESMAN BUT NOW IT HAS BEEN 3000 MILES AND HE ODOR IS STILL HAPPENING. I JUST WANT THE 2016 TO BE CHECKED OUT FOR EMISSION TROUBLES TO MAINTAIN A SAFE RIDE FOR FAMILY MEMBERS.
NHTSA ODI #10883161
8,900 miles · Jul 5, 2016
Unknown Or Other
WHEN A STRAIN IS PUT ON THE ENGINE, SUCH AS IN PASSING GEAR, A BURNING RUBBER SMELL IS EMITTED IN THE INTERIOR, EVEN WITH THE AIR CONDITIONING IN RECIRCULATE AIR IN VEHICLE MODE. IN 2013 I DIALOGUED WITH FORD HEADQUARTERS ABOUT THIS SAME ISSUE WITH A 2012 EXPLORER LIMITED THAT I OWNED. IN 2013 THEY SENT ME TO ROYAL OAK FORD …
Read full complaint
WHEN A STRAIN IS PUT ON THE ENGINE, SUCH AS IN PASSING GEAR, A BURNING RUBBER SMELL IS EMITTED IN THE INTERIOR, EVEN WITH THE AIR CONDITIONING IN RECIRCULATE AIR IN VEHICLE MODE. IN 2013 I DIALOGUED WITH FORD HEADQUARTERS ABOUT THIS SAME ISSUE WITH A 2012 EXPLORER LIMITED THAT I OWNED. IN 2013 THEY SENT ME TO ROYAL OAK FORD IN ROYAL OAK. MI AND THE SERVICE MANAGER RODE WITH ME TO OBSERVE THE SMELL. THEY NEVER OFFERED ANY TYPE OF REPAIR. I WAS HOPING THEY WOULD HAVE SOLVED THIS BY 2016, HOWEVER NOW WITH THE WARM SUMMER WEATHER THIS 2016 EXPLORER EMITS THE PUTRID SMELL JUST AS BADLY. IT SMELL LIKE THE RUBBER PADDING ON TOP OF THE ENGINE IS BURNING. VEHICLE HAS 8,900 MILES, PURCHASED BRAND NEW 10/25/15.
NHTSA ODI #10882832
5,000 miles · Jul 5, 2016
EngineUnknown Or Other
BURNING EXHAUST SMELL ENTERING INTO CABIN OF CAR WHEN CAR IS UNDER HARD ACCELERATION/FULL THROTTLE. ESPECIALLY NOTICEABLE WHEN ACCELERATING ONTO A HIGHWAY OR CLIMBING STEEP HILLS. THIS BURNING EXHAUST SMELL MAKES ALL PASSENGERS FEEL SICK BY AFFECTING YOUR RESPIRATORY PASSAGEWAYS LEAVING A LUMP IN YOUR THROAT, BURNING YOUR EYES, …
Read full complaint
BURNING EXHAUST SMELL ENTERING INTO CABIN OF CAR WHEN CAR IS UNDER HARD ACCELERATION/FULL THROTTLE. ESPECIALLY NOTICEABLE WHEN ACCELERATING ONTO A HIGHWAY OR CLIMBING STEEP HILLS. THIS BURNING EXHAUST SMELL MAKES ALL PASSENGERS FEEL SICK BY AFFECTING YOUR RESPIRATORY PASSAGEWAYS LEAVING A LUMP IN YOUR THROAT, BURNING YOUR EYES, GIVING YOU A HEADACHE, AND MAKING YOU FEEL NAUSEOUS. THE RECENT NHTSA INVESTIGATION INTO 2011-2015 MODELS, SHOULD ALSO INCLUDE 2016 MODELS AS WELL. FORD HAS FAILED TO RECOGNIZE THIS PROBLEM AND HAS TRIED MULTIPLE TIMES TO "FIX" MY 2016 FORD EXPLORER. NO RESOLUTION HAS BEEN FOUND AND THEY HAVE REFUSED SO FAR TO TAKE THE CAR BACK.
NHTSA ODI #10882823
7,501 miles · Jul 5, 2016
EngineUnknown Or Other
THROTTLE BODY FAILED ON VEHICLE AT HIGHWAY SPEED. LOST ALL POWER IN THE MIDDLE OF RUSH HOUR TRAFFIC BARELY MISSED A REAR END COLLISION FROM ANOTHER VEHICLE BECAUSE I COULD NOT ACCELERATE.
NHTSA ODI #10882822
1,214 miles · Jul 5, 2016
Fuel/propulsion SystemUnknown Or Other
MY VEHICLE EMITS EXHAUST IN THE CABIN WHILE DRIVING. UPON ACCELERATION AND DECELERATION, THE EXHAUST SMELL IS SO POTENT, ME AND MY PASSENGERS HAVE TO ROLL DOWN THE WINDOWS. I RETURNED THE VEHICLE THE DAY AFTER PURCHASING TO THE FORD DEALERSHIP FOR REPAIRS AND HAVE RETURNED IT FOR REPAIRS MANY TIMES SINCE. THEY HAVE SEALED ALL OP…
Read full complaint
MY VEHICLE EMITS EXHAUST IN THE CABIN WHILE DRIVING. UPON ACCELERATION AND DECELERATION, THE EXHAUST SMELL IS SO POTENT, ME AND MY PASSENGERS HAVE TO ROLL DOWN THE WINDOWS. I RETURNED THE VEHICLE THE DAY AFTER PURCHASING TO THE FORD DEALERSHIP FOR REPAIRS AND HAVE RETURNED IT FOR REPAIRS MANY TIMES SINCE. THEY HAVE SEALED ALL OPENINGS UNDER THE VEHICLE, REPLACED THE EXHAUST SYSTEM, AND REPLACED THE VENTS IN THE BUMPER. FORD HAS ACKNOWLEDGED THERE IS AN ISSUE WITH MY EXPLORER, HOWEVER, THEY ARE UNABLE TO FIX IT. MY LAST REPAIR VISIT IN JUNE 2016, I WAS NOTIFIED THAT I NEED TO COME PICK UP MY VEHICLE BECAUSE THEY COULD DO NOTHING ELSE FOR IT. THEY HAVE TRIED TO REPAIR IT AND THEY ARE UNABLE TO REPAIR THE ISSUE. THIS HAS CAUSED VARIOUS HEALTH ISSUES FOR ME, WHICH INCLUDE, HEADACHES AND NAUSEA. FORD HAS IGNORED ALL OF MY REQUEST TO RESOLVE THIS ISSUE. I AM CONCERNED I AM BEING POISONED BY EXHAUST.
NHTSA ODI #10882646
Official recalls
14Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Consequence & remedy
Consequence: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Mar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Nov 10, 2020
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
Consequence & remedy
Consequence: The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Nov 29, 2017
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.
Jun 28, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.
Mar 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Consequence & remedy
Consequence: Overheating of the engine block increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.
Sep 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
Consequence & remedy
Consequence: If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.
Jul 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA17002 · Exhaust Odor In Passenger Cab
Opened Jul 27, 2017 · Closed Jan 17, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Illustration