← New search

2014 Ford Explorer

Owner reports · Recalls · Investigations

More warning signs than most Explorer years

Owner complaints for the 2014 Ford Explorer are substantially higher than the model-year median of 609.

About this comparison →

When problems were reported

Mileage at the reported incident

1,021 reports with mileage · 654 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 496 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Structure. Review the 276 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 196 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

32 crash reports6 fire reports29 injury reports

Steering complaints

496 reports
Clear category filter
Mileage unknown · Jun 29, 2021
Steering

We were returning from a visit with my son in Ohio. Suddenly a notice appeared on the dashboard about steering control and it was extremely hard to turn the wheel. We tried several methods suggested to correct the problem such as disconnecting the battery and also checking the fuses but no success. Since it appeared I could d…

Read full complaint

We were returning from a visit with my son in Ohio. Suddenly a notice appeared on the dashboard about steering control and it was extremely hard to turn the wheel. We tried several methods suggested to correct the problem such as disconnecting the battery and also checking the fuses but no success. Since it appeared I could drive the vehicle, we drove home but had to really work at steering. We finally arrived back at our home without further incident other than being extremely tired from turning the steering wheel. It was like driving a car which was never equipped with power steering but even harder. After returning home, I took the vehicle to the local Ford dealership. They checked the vehicle and said the steering column had to be replaced. Total cost is going to be $2384.73 plus tax.

NHTSA ODI #11422733

Mileage unknown · Jun 28, 2021
Steering

WHILE DRIVING POWER STEERING FAILURE.. WHEN IT FAILED IT DINGED AND A MESSAGE CAME UP BUT FAILURE WAS WHILE DRIVING. NO OTHER PREVIOUS PROBLEMS. ONLY 44750 MILES AT TIME OF FAILURE.

NHTSA ODI #11422701

Mileage unknown · Jun 19, 2021
Steering

Electrical power steering pump in failure. It's hard to steer and steering wheel gets stuck in a certain position. My wife wife was heading Into oncoming traffic, it allowed the steering to free up and be corrected right before she could have hit another vehicle head on. It is headed to our local dealership for a recall this wee…

Read full complaint

Electrical power steering pump in failure. It's hard to steer and steering wheel gets stuck in a certain position. My wife wife was heading Into oncoming traffic, it allowed the steering to free up and be corrected right before she could have hit another vehicle head on. It is headed to our local dealership for a recall this week and we plan on having them confirm this, if we make it there. the bad part is there was no warning or dash indication light to let us know this was in failure and could have seriously hurt my wife and or kids IF they were in the vehicle.

NHTSA ODI #11421490

112,000 miles · Jun 16, 2021
Steering

The contact owns a 2014 Ford Explorer. The contact stated while driving at 55 mph, the service advanced track and power steering assist warning lights were illuminated. The vehicle was parked and the vehicle loss power steering functionality. The vehicle was towed to an independent mechanic and diagnosed that the electronic powe…

Read full complaint

The contact owns a 2014 Ford Explorer. The contact stated while driving at 55 mph, the service advanced track and power steering assist warning lights were illuminated. The vehicle was parked and the vehicle loss power steering functionality. The vehicle was towed to an independent mechanic and diagnosed that the electronic power steering unit failed and needed to be replaced. The vehicle was not repaired and remained with the mechanic. The manufacturer was made aware of the failure. The approximate failure mileage was 112,000.

NHTSA ODI #11421135

Mileage unknown · Jun 15, 2021
Steering

The steering wheel suddenly became stiff while driving-and a power steering failure light came on-we had to park and be towed-and the Power steering rack and pinion/motor needs replacement. There are hundreds of people with the same problem-90,000 miles and barely driven

NHTSA ODI #11421039

Mileage unknown · Jun 10, 2021
Steering

2014 Ford Explorer, steering wheel gets very hard when turning. Started four days ago, has not stopped since. Was not moving when the issue started. Ford dealership told me it is a very very very common issue with the rack and pinion on this year, and wanted to charge me $4000 to replace it. There is a recall on the power electr…

Read full complaint

2014 Ford Explorer, steering wheel gets very hard when turning. Started four days ago, has not stopped since. Was not moving when the issue started. Ford dealership told me it is a very very very common issue with the rack and pinion on this year, and wanted to charge me $4000 to replace it. There is a recall on the power electric steering system of the 2011 through 2013 Ford Explorers, and apparently it is just as common on the 2014, so I’m wondering why it is not included in the recall. I absolutely am not paying out of pocket to get this fixed. if I die on the road, Ford is the cause..

NHTSA ODI #11420452

Mileage unknown · Jun 3, 2021
Steering

Power steering. Experienced a loss of power steering. It required me to use extra steering effort. Was traveling on the highway was able to pull over to breakdown lane.

NHTSA ODI #11419446

Mileage unknown · May 26, 2021
Steering

At approximately 75,000 miles the steering on my 2014 Ford Explorer became sluggish and unresponsive making the vehicle difficult and unsafe to drive. This problem occurred at all speeds whether stopping at a stop sign or driving on the highway. The vehicle was brought to an authorized Ford dealer/service center at which time …

Read full complaint

At approximately 75,000 miles the steering on my 2014 Ford Explorer became sluggish and unresponsive making the vehicle difficult and unsafe to drive. This problem occurred at all speeds whether stopping at a stop sign or driving on the highway. The vehicle was brought to an authorized Ford dealer/service center at which time it was confirmed the power steering rack, electric pump and shaft assembly were defective and needed to be replaced at great expense to owner. There were never any warning lamps, signals or messages generated by the vehicle. The vehicle was serviced on 4/19/21 (and again on 5/17/21) with symptoms commencing approximately 4 days prior. Upon researching, owner determined there had previously been a Ford safety recall for same issue on similar model(s) but only for years 2010-2013.

NHTSA ODI #11418632

Mileage unknown · May 25, 2021
Steering

The car drove fine - no prior issues. Went to leave for a wedding and the dash board lit up with the following errors: Steering Assist Fault Service Required, Service AdvanceTrac, and Terrain System Fault. The vehicle was nearly impossible to steer. It took all my strength to even move the wheel slightly to be able to pull ba…

Read full complaint

The car drove fine - no prior issues. Went to leave for a wedding and the dash board lit up with the following errors: Steering Assist Fault Service Required, Service AdvanceTrac, and Terrain System Fault. The vehicle was nearly impossible to steer. It took all my strength to even move the wheel slightly to be able to pull back into the driveway and off the road. I researched this online and found there are 100's of other people that have had the same issue, yet ford refuses to do anything. They have issues recalls for 2011-2013 and 2015-2017 explorers for the same issue but not 2014. We did the diagnostics and had to order a new rack and pinion however the part is not in stock and on backorder because so many people are having this issue. This should be an obvious sign to Ford that something is wrong. I am including links to other sites showing other people have had the same issue. I know others have also filed a report with you. I tried talking to ford and opened a case with them but they aren't taking any responsibility. The only thing I am thankful for is that unlike some of the others who weren't so lucky, I wasn't on a major highway or going 60+mph when the steering went out. This is a huge safety concern and it is unfortunate that it appears it will take someone losing their life before Ford decides to admit their at fault. These are just a few of the sites showing similar reports - all with 2014 Ford Explorers. https://m.carcomplaints.com/Ford/Explorer/2014/steering/power_steering_failure.shtml https://robinettelaw.com/blog/2014/08/ford-explorer-recall-for-power-steering-defect/

NHTSA ODI #11418432

100,000 miles · May 24, 2021
Steering

The contact owns a 2014 Ford Explorer. The contact stated while reversing out of the driveway, the steering wheel was firm making it difficult to steer the vehicle. The contact stated that the power steering intermittently failed to perform as designed. The contact stated there was no warning light illuminated. The vehicle was n…

Read full complaint

The contact owns a 2014 Ford Explorer. The contact stated while reversing out of the driveway, the steering wheel was firm making it difficult to steer the vehicle. The contact stated that the power steering intermittently failed to perform as designed. The contact stated there was no warning light illuminated. The vehicle was not taken to a local dealer nor independent mechanic to be diagnosed. The vehicle was not repaired. The contact was relating the failure to NHTSA campaign number: 14V286000 (Steering). The manufacturer was informed of the failure and informed the contact that the VIN was not included. The failure mileage was approximately 100,000.

NHTSA ODI #11418290

Official recalls

6

24V031000 · Structure:body:roof And Pillars

Jan 19, 2024

Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.

Consequence & remedy

Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.

Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.

21V537000 · Suspension:rear

Jul 15, 2021

Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.

Consequence & remedy

Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.

Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.

20V675000 · Suspension:rear

Mar 12, 2021

Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.

Consequence & remedy

Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.

20V692000 · Power Train:axle Assembly:axle Shaft

Nov 10, 2020

Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.

Consequence & remedy

Consequence: The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.

19V435000 · Suspension:rear

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.

Consequence & remedy

Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.

16V245000 · Suspension:rear

Apr 26, 2016

Ford Motor Company (Ford) is recalling certain model year 2014-2015 Ford Explorer vehicles manufactured January 17, 2014 to May 31, 2014. The affected vehicles may have improperly welded rear suspension toe links that may fracture.

Consequence & remedy

Consequence: A fracture of the rear suspension toe link may result in a loss of steering control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. The recall began on November 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S18.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

PE23001 · Windshield Trim Molding Item Detachment

Opened Jan 27, 2023 · Closed Feb 8, 2024

Status: closed (inferred from source dates) · Structure:body:roof And Pillars

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

EA17002 · Exhaust Odor In Passenger Cab

Opened Jul 27, 2017 · Closed Jan 17, 2023

Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body

During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve

Structure:body

During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve

PE16008 · Ford Explorer Exhaust Odor

Opened Jul 1, 2016 · Closed Sep 12, 2017

Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System; Structure:body

During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System

During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).

Structure:body

During the National Highway Traffic Safety Administration?s (NHTSA?s) investigation into the Ford carbon monoxide allegations, the Office of Defects Investigation (ODI) identified additional Vehicle Owner Questionnaire (VOQ) reports with similar exhaust odor claims.Presently, ODI has identified 791 VOQs for Model Year 2011-2017 Ford Explorers pertaining to exhaust odor claims.ODI has identified three crashes and 41 injuries potentially linked this issue.The reported injuries range from unspecified to loss of consciousness, with the majority being nausea, headaches, or dizziness ? all of which can be symptomatic of carbon monoxide exposure.Additionally, Ford provided 2,400 reports including owner complaints, warranty claims, dealer field reports, and legal claims, that involve 2,051 vehicles that may be connected to the exhaust odor issue.NHTSA's Vehicle Test and Research Center tested multiple vehicles, including complaint vehicles, during the investigation.ODI also conducted field inspections of complaint vehicles and crashes involving police units that occurred while the officers were on duty.When possible, data was collected to quantify carbon monoxide levels in the examined vehicles.Based on the information gathered to date, NHTSA upgraded this investigation to an Engineering Analysis (EA17-002).

EA15005 · Front Brake Hose Failure

Opened Sep 28, 2015 · Closed Nov 2, 2018

Status: closed (inferred from source dates) · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On April 29, 2015, the Office of Defects Investigation (ODI) opened PE15-017 to investigate a report alleging incidents of front brake hose failure in model year (MY) 2015 Ford Explorer Police Interceptor vehicles used by the Sacramento Police Department in its pursuit driving training program (VOQ 10705832).On September 28, 2015, ODI upgraded the investigation to an Engineering Analysis (EA15-005) to assess maximum front caliper crimp temperatures under various test conditions, test hose assemblies removed from police interceptor service for any signs of thermal degradation, and further assess field data for evidence of a defect trend related to the alleged defect.The alleged defect results from exposure to extremely high heat at the caliper-side hose crimp. NHTSA?s vehicle testing suggests that the conditions necessary to produce the critical temperatures in the subject components result from drive-soak intervals that can occur during the Sacramento training program.NHTSA's testing of hose assemblies returned from police interceptor service did not identify any evidence of thermal degradation.NHTSA has not confirmed any incidents of caliper crimp failures due to overheating in vehicles not subjected to the Sacramento training course driving.The low number of hose assembly failure reports and the absence of any verified incidents of heat related front brake hose crimp failures since 2015 suggests that the Sacramento PD incidents resulted from conditions unique to the training program.A safety related defect trend has not been identified at this time and further use of Agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The Agency will take further action if warranted by the circumstances.For additional information, see the Closing Report in the document file for EA15-005 on www.nhtsa.gov.

Go deeper into Ford Explorer problems