2006 Ford Explorer

FIRST INCIDENT OCCURRED IN EARLY APRIL 2012: MY CAR WAS EMITTING A FOUL SMELL AND OVERHEATING. UPON INSPECTION, IT WAS DISCOVERED THAT MY RADIATOR WAS LEAKING. I TURNED MY VEHICLE INTO FORD AND IT WAS REPLACED. SECOND INCIDENT OCCURRED EARLY-MID OCT 2012: MY CAR WAS JERKING AND THE CHECK ENGINE LIGHT CAME ON. IT WAS TAKEN TO HAVE THE CODES CHECKED AND IT WAS INDICATED THAT I HAD 2-3 RANDOM "MISS-FIRES" TO MY SPARK PLUGS. AS THIS IS NORMALLY AN EASY AT-HOME FIX, WE WERE ABLE TO REPLACE ALL THE SPARK PLUGS. THE ISSUE WITH THIS INCIDENT WAS THAT IN THE PROCESS OF REMOVING THE SPARK PLUGS, ALL BUT ONE BROKE IN HALF. THIS IS SUCH A COMMON PROBLEM THAT FORD HAS DESIGNED AND SELLS A SPECIFIC TOOL TO REMOVE BROKEN SPARK PLUGS. ONCE THE TOOL WAS PURCHASED, I WAS ABLE TO FIX THE PROBLEM AND MY CAR NO LONGER JERKED AND THE CHECK ENGINE LIGHT WENT OFF. THIRD INCIDENT OCCURRED LATE NOV 2012: VEHICLE STARTED JOLTING AND JERKING EXCESSIVELY AND CHECK ENGINE LIGHT CAME ON. FEELS LIKE TRANSMISSION IS NOT ENGAGING GEARS PROPERLY. AFTER MUCH RESEARCH, I FOUND THAT THIS IS A COMMON AND MAJOR SAFETY ISSUE REGARDING THIS VEHICLE. A SAFETY RECALL NEEDS TO BE DONE IMMINENTLY. ANOTHER ISSUE, STARTED IN THE END OF 2011: WHEN GOING FROM PARK TO REVERSE OR DRIVE, STICK SHIFT WILL STICK AND I WILL HAVE WIGGLE AND PULL HARD TO MAKE IT MOVE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE STALLED AND ALL THE WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT PULLED THE VEHICLE OVER AND RESTARTED IT AND IT FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO A DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS 73,000.

WHILE TRYING TO STOP MY VEHICLE SUDDENLY ACCELERATED AND I HAD TO PUT IT IN NEUTRAL TO COME TO A STOP. I PULLED INTO A PARKING LOT AND SHUT THE ENGINE OFF AND THEN STARTED IT UP AGAIN AND MY ENGINE REVVED AT AROUND 4000 RPM. THE ONLY WAY I COULD DRIVE THE VEHICLE HOME WAS TO KEEP CONSTANT HEAVY PRESSURE ON THE BRAKES. IT ALWAYS WANTED TO ACCELERATE. *TR

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT WHILE AT A COMPLETE STOP, THE VEHICLE HESITATED. THE CONTACT WAS ABLE TO ACCELERATE INTO TRAFFIC HOWEVER WITHIN MOMENTS, FIRE EMITTED FROM UNDER THE HOOD. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND ADVISED THAT THE FIRE ORIGINATED FROM THE RIGHT SIDE OF THE ENGINE BAY AREA. THE FIRE HAD SPREAD TO THE WINDSHIELD AND DASHBOARD AS WELL. THE VEHICLE WAS TOWED TO THE DEALER WHO DID NOT ADVISE THE CONTACT ON THE CAUSE OF THE ENGINE FAILURE THAT COULD HAVE LED TO THE FIRE. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

ENGINE LOST POWER AND BEGAN VIBRATING. ENGINE DRIVEN TO DEALERSHIP AND ENGINE LIGHT CAME ON. DEALERSHIP STATES "SEIZED" SPARK PLUG BUT BECAUSE PART IS DEFECTIVE WANTS TO REPLACE ALL EIGHT PLUGS. UNABLE TO QUOTE COST AS PLUGS ARE KNOWN TO BREAK OFF DURING REMOVAL. PLUG REPLACEMENT RECOMMENDED ORGINALLY TO BE 100000 NOW DROPPED TO 60,000. SERVICE WRITER STATED "YOU MUST HAVE HAD SOMEONE MESSING WITH YOUR SPARK PLUGS". TOLD HIM NO ONE HAS SERVICED MY CAR BUT HIS DEALERSHIP. SPECIAL TOOL DESIGNED BY FORD TO REMOVE THESE PLUGS. COST CANNOT BE QUOTED ($946 FOR ONE PLUG CHANGEOUT PLUS FULL SERVICE FUEL SERVICE PRIOR TO REMOVAL TO "LOOSEN" UP CARBON BUILDUP WHICH THEY SAY CAUSES THE PROBLEM WITH PLUG BREAKAGE) BUT COST RUNS INTO THOUSANDS OF DOLLARS AND SHAVINGS FROM REBORING THE PLUGS FOR REPLACEMENT OF DIFFERENT DESIGN PLUG CAN CAUSE ENGINE TO BE DAMAGED. CAR PURCHASED NEW IN 2006. ONLY DRIVER. ONLY DEALER SERVICED. THIS IS A TERRIBLE PROBLEM.

I NOTICED A YELLOW FLUID LEAKING FROM THE THERMOSTAT HOUSING. I TOOK IT TO A MECHANIC AND HE SAID THAT THE ANTIFREEZE WAS LEAKING FROM SOMEWHERE IN THE MANIFOLD, PROBABLY THE THERMOSTAT HOUSING. WE REPLACED THE THERMOSTAT HOUSING AND BRAND NEW O-RINGS AND ADDED SILICONE SEALANT AROUND THE AFFECTED AREAS. WE ARE STILL SEEING THE LEAKING. I HAVE SEEN THIS COMPLAINT NUMEROUS TIMES AND IT IS TIME THAT FORD TAKE RESPONSIBILITY FOR THE PLASTIC PARTS THAT ARE CONNECTED TO THE ENGINE. FORD MUST USE METAL PARTS TO REPLACE THESE FOR ME BECAUSE PLASTIC WARPS IN THE HEAT OF FLORIDA. THE AFFECTED PARTS ARE THE THERMOSTAT HOUSING AND IT'S CONNECTION TO THE ENGINE. I HAVE A 2006 FORD EXPLORER EDDIE BAUER 4.0 WITH 55K MILEAGE. GOOD MAINTENANCE ALWAYS, OIL CHANGED REGULARLY, FLUIDS CHECKED AND MAINTAINED REGULARLY. FORD MUST FIX THIS! *JS

TL* THE CONTACT OWNS A 2006 FORD EXPLORER. THE CONTACT STATED THAT THE READING FROM THE TEMPERATURE GAUGE INCREASED WHEN THE RADIATOR FAILED. THE RADIATOR LEAKED COOLANT DUE TO DEFECTIVE PLASTIC. THE RADIATOR WAS REPLACED THREE TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED A FOURTH. THE FAILURE MILEAGE WAS 27,000 AND THE CURRENT MILEAGE WAS 100,000.