NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,304 reports94,000 miles · Jan 20, 2021
Tires
WHILE DRIVING HOME FROM WORK LAST WEEK I NOTICED A SLIGHT 'BUMPING' FEEL LIKE AN UNBALANCED TIRE, SO I TOOK A LOOK WHEN I GOT TO MY DRIVEWAY BUT FOUND NOTHING. THE NEXT DAY ON MY WAY TO WORK THE "BUMPING' WAS MUCH WORSE SO I STOPPED TO CHECK AND FOUND A LARGE BULGE ON THE TREAD OF THE RIGHT FRONT TIRE. AFTER SLOWLY RETURNING HOM…
Read full complaint
WHILE DRIVING HOME FROM WORK LAST WEEK I NOTICED A SLIGHT 'BUMPING' FEEL LIKE AN UNBALANCED TIRE, SO I TOOK A LOOK WHEN I GOT TO MY DRIVEWAY BUT FOUND NOTHING. THE NEXT DAY ON MY WAY TO WORK THE "BUMPING' WAS MUCH WORSE SO I STOPPED TO CHECK AND FOUND A LARGE BULGE ON THE TREAD OF THE RIGHT FRONT TIRE. AFTER SLOWLY RETURNING HOME I REMOVED IT AND SET IT ASIDE. A FEW HOURS LATER THE THREADS WERE SEPARATING BADLY SO I LET THE AIR OUT BEFORE IT BLEW APART. I ORDERED A REPLACEMENT TIRE (DIFFERENT BRAND) BUT I'VE STILL GOT THREE MORE OF THESE ON THE VEHICLE .THEY HAVE 36K MILES ON THEM AND A 60K WARRANTY WITH ONLY MODEST THREAD WEAR BUT I STILL CHECK THEM EVERY DAY. I DON'T FEEL SAFE.*DT CONSUMER STATED HE STILL HAS A DEFECTIVE TIRE.*JB
NHTSA ODI #11389077
62,000 miles · Jul 7, 2020
Air BagsInjury
THIS PAST WEEKEND I WAS DRIVING AN 04 FORD EXPLORER WHEN BOTH SIDE AIRBAGS SPONTANEOUSLY DEPLOYED. I WAS NOT IN AN ACCIDENT. I WAS DRIVING DOWN A TWO-LANE ROAD AT LESS THAN 35 MILES PER HOUR WHEN THE AIRBAGS DEPLOYED. I WAS ABLE TO PULL OVER BUT NOT BEFORE SUSTAINING AN INJURY TO MY EAR AND NOT BEFORE THE PASSENGER SUSTAINED …
Read full complaint
THIS PAST WEEKEND I WAS DRIVING AN 04 FORD EXPLORER WHEN BOTH SIDE AIRBAGS SPONTANEOUSLY DEPLOYED. I WAS NOT IN AN ACCIDENT. I WAS DRIVING DOWN A TWO-LANE ROAD AT LESS THAN 35 MILES PER HOUR WHEN THE AIRBAGS DEPLOYED. I WAS ABLE TO PULL OVER BUT NOT BEFORE SUSTAINING AN INJURY TO MY EAR AND NOT BEFORE THE PASSENGER SUSTAINED AN INJURY TO HER RIGHT ARM. I REPORTED THIS TO FORD, WHICH ADVISED TO CARRY THE VEHICLE TO A DEALERSHIP. TOOK IT TO THE DEALERSHIP, WHERE THE SERVICE MANAGER WAS UNCONCERNED WITH THE FACT THAT THE AIRBAGS SPONTANEOUSLY DEPLOYED. HE LOOKED AT THE VEHICLE FOR TWO DAYS ONLY TO REPORT HE WAS NOT AWARE OF WHY THE AIRBAGS DEPLOYED AND STATED THERE WAS NOTHING HE COULD DO ABOUT IT. I REPEAT, I WAS NOT IN AN ACCIDENT AND THE AIRBAGS DEPLOYED WHILE DRIVING. THIS IS OF COURSE QUITE CONCERNING TO ME BUT FORD DOES NOT SEEM TO CARE. PLEASE FOLLOW-UP ON THE SAFETY OF FORD'S VEHICLES.
NHTSA ODI #11337948
120,000 miles · Dec 2, 2019
Wheels
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE WHEEL STUDS DETACHED ON MULTIPLE TIRES WHILE DRIVING. THE FAILURE RECURRED THREE TIMES ON MULTIPLE WHEELS ON DIFFERENT OCCASIONS. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN ONCE TO AN INDEPENDENT MECHANIC WHERE THE STUDS WERE REPLACED; HOWEVER, THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT THE WHEEL STUDS DETACHED ON MULTIPLE TIRES WHILE DRIVING. THE FAILURE RECURRED THREE TIMES ON MULTIPLE WHEELS ON DIFFERENT OCCASIONS. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN ONCE TO AN INDEPENDENT MECHANIC WHERE THE STUDS WERE REPLACED; HOWEVER, THE FAILURE CONTINUED. THE CONTACT ALSO STATED THAT SHE REPLACED MULTIPLE STUDS HERSELF. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000.
NHTSA ODI #11286314
225,000 miles · Oct 2, 2019
Air Bags
THE VEHICLE WAS MOVING AT A SLOW RATE OF SPEED (APPROX 5-10 MPH) ON A BUMPY ROAD. THE DRIVER WAS LOOKING FOR A PARKING SPACE. THE SIDE AIRBAGS DEPLOYED. THE INSURANCE COMPANY HAS DETERMINED THAT THERE WAS NO COLLISION OR REASON FOR THE AIRBAGS TO DEPLOY AND THEREFORE THEY WILL NOT COVER THE DAMAGE.
NHTSA ODI #11265739
Mileage unknown · Sep 26, 2019
Power Train
MY 2004 FORD EXPLORER HAS RECENTLY AND QUICKLY BEGAN SHIFTING VERY BADLY. I ALWAYS COME TO A COMPLETE STOP AND SHIFT INTO NEUTRAL BEFORE SHIFTING INTO REVERSE OR DRIVE BECAUSE WHEN SHIFTING INTO REVERSE FROM P OR D, IT ALWAYS TAKES A WHILE, THEN CLUNKS AGGRESSIVELY INTO PLACE. WHILE DRIVING SOMETIMES DOWNSHIFTING WILL ALSO CLUNK…
Read full complaint
MY 2004 FORD EXPLORER HAS RECENTLY AND QUICKLY BEGAN SHIFTING VERY BADLY. I ALWAYS COME TO A COMPLETE STOP AND SHIFT INTO NEUTRAL BEFORE SHIFTING INTO REVERSE OR DRIVE BECAUSE WHEN SHIFTING INTO REVERSE FROM P OR D, IT ALWAYS TAKES A WHILE, THEN CLUNKS AGGRESSIVELY INTO PLACE. WHILE DRIVING SOMETIMES DOWNSHIFTING WILL ALSO CLUNK INTO PLACE. THIS ISSUE HAS BEEN REPORTED BY COUNTLESS OTHER DRIVERS AND HAS CAUSED MANY POTENTIALLY DANGEROUS SITUATIONS. FROM ACCELERATING SLOWLY THEN BANGING GEARS AND TAKING OFF, TO STUTTERING WHILE TRYING TO ACCELERATE, OR EVEN SWITCHING INTO REVERSE WHILE PARKING, AND HAVING THE CAR TRY TO JUMP BACK A FEW INCHES IS ONLY A FEW ISSUES THIS PROBLEM HAS CAUSED MYSELF AND COUNTLESS OTHERS. PEOPLE ARE REPLACING TRANSMISSIONS LEFT AND RIGHT TO NO AVAIL, ONLY A FEW 10 THOUSAND MILES AFTER INSTALLING NEW TRANSMISSIONS, THEIR CAR STARTS TO EXPERIENCE THE SAME ISSUES AS BEFORE. AT LOW SPEEDS AND IN PARKING LOTS THIS BECOMES A GAME OF LUCK AS YOU ACCELERATE MORE THAN NECESSARY TO TRY TO GET GOING, THEN STOPPING AND WAITING A FEW SECONDS WHILE YOU SHIFT TO NEUTRAL BEFORE SHIFTING TO REVERSE AS FEAR OF IT BANGING INTO GEAR AS YOU TRY TO MANEUVER YOUR CAR AROUND PEOPLE AND OTHER PARKED CARS BECOMES A MORE DANGEROUS TASK THAN IT SHOULD BE. IN SUM, WHILE STATIONARY, SLOW SPEED, OR JUST CRUISING, THE TRANSMISSION WHILE SHIFTING GEARS, OR SHIFTING INTO REVERSE/DRIVE, SOMETIMES WANTS TO BANG INTO GEAR OR LOSE POWER, OR DELAY SHIFTING ONLY TO BANG INTO GEAR MOMENTS LATER. SOME ISSUES WHEN TAKING CARS INTO REPAIR IS FINDING METAL TRANSMISSION SHAVINGS WHERE THEY SHOULDNT BE! FINALLY, THE EXCESSIVE BANGING CAN ALSO DAMAGE THE ENGINE OVER TIME IN ADDITION TO THE TRANSMISSION. PLEASE REFERENCE THE FOLLOWING LINK TO GET A BETTER IDEA OF THE ISSUES: HTTPS://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2004/TRANSMISSION/TRANSMISSION_SLIPPING_SHIFTS_HARD.SHTML THANKYOU
NHTSA ODI #11258464
164,400 miles · Aug 20, 2019
Unknown Or Other
THE IGNITION KEYS LOSES THE PROGRAM AND I CONSTANTLY HAVE TO HAVE NOTH REPROGRAMED. I WAS TOLD THIS WAS A RECALL THAT FORD KNOWS ABOUT. THE CAUSE THE CAR INABILITY TO START
NHTSA ODI #11245234
50,000 miles · Jul 20, 2019
Electrical SystemExterior LightingStructure
PLASTICE PARTS ARE DETERIORATING, DESOLVING IN FRONT INSIDE DRIVE SUN VISOR-LIGHTED VISOR BROKE OFF; CENTERL REAR A/C AND HEAT MOON ROOF LIGHT CONSOLE FALLS OFF-PLASTICE CLIPS DESOLVED AND WILL NOT FASTEN INTO ROOF ASSEMBLY, CAUSING BLOCKED EYESIGHT AND AT TIME ON RIGHT TURN HITTING HEAD OR EYES . THIS IS UNSAFE AND FORD MOTOR K…
Read full complaint
PLASTICE PARTS ARE DETERIORATING, DESOLVING IN FRONT INSIDE DRIVE SUN VISOR-LIGHTED VISOR BROKE OFF; CENTERL REAR A/C AND HEAT MOON ROOF LIGHT CONSOLE FALLS OFF-PLASTICE CLIPS DESOLVED AND WILL NOT FASTEN INTO ROOF ASSEMBLY, CAUSING BLOCKED EYESIGHT AND AT TIME ON RIGHT TURN HITTING HEAD OR EYES . THIS IS UNSAFE AND FORD MOTOR KNOWS OF COMPLAINST. PART ARE NOT AVAILBLE. THIS IS A HIGHWAY SAFETY ISSUE. THE MODEL WAS THE EDDIE BAUER TOP OF THE LINE $40,,835 CAR FMV $5000 ONLY 54000 MILES PRI LEVEL CODE 450240U74 SHIP WGT 4357
NHTSA ODI #11233554
264,000 miles · Jul 2, 2019
Exterior Lighting
TL* THE CONTACT OWNS A 2004 FORD EXPEDITION. THE CONTACT STATED THAT THE BRAKE LAMPS, TURN SIGNALS, AND EMERGENCY FLASHERS FAILED TO OPERATE PROPERLY. THIS WAS A DISTRACTION TO THE CONTACT'S DRIVING BECAUSE HE COULD NOT NOTIFY OTHER DRIVERS OF THE VEHICLE'S MOVEMENTS. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC, BUT THEY D…
Read full complaint
TL* THE CONTACT OWNS A 2004 FORD EXPEDITION. THE CONTACT STATED THAT THE BRAKE LAMPS, TURN SIGNALS, AND EMERGENCY FLASHERS FAILED TO OPERATE PROPERLY. THIS WAS A DISTRACTION TO THE CONTACT'S DRIVING BECAUSE HE COULD NOT NOTIFY OTHER DRIVERS OF THE VEHICLE'S MOVEMENTS. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC, BUT THEY DID NOT HAVE TIME TO DIAGNOSE THE VEHICLE. THE CONTACT CALLED A FORD CUSTOMER SERVICE LINE, BUT THEY DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 264,000.
NHTSA ODI #11228959
99,735 miles · Jun 20, 2019
Power TrainSteeringSuspension
MY STEERING COLUMN BROKE RIGHT OFF! TRYING TO PUT IT IN DRIVE @99,735 MI. HAD TO TOW IT TO SHOP, AND REPLACE THE STEERING COLUMN. I SEE OTHER PEOPLE HAD THIS SAME PROBLEM. THERE SHOULD BE A RECALL FOR THIS!!! I ALSO HAD TO REPLACE THE TRANSMISSION @ 103,000 MILES IT WOULD SKIP 3RD GEAR. SEEMS EVERYONE ELSE HAS TO REPLACE THE…
Read full complaint
MY STEERING COLUMN BROKE RIGHT OFF! TRYING TO PUT IT IN DRIVE @99,735 MI. HAD TO TOW IT TO SHOP, AND REPLACE THE STEERING COLUMN. I SEE OTHER PEOPLE HAD THIS SAME PROBLEM. THERE SHOULD BE A RECALL FOR THIS!!! I ALSO HAD TO REPLACE THE TRANSMISSION @ 103,000 MILES IT WOULD SKIP 3RD GEAR. SEEMS EVERYONE ELSE HAS TO REPLACE THE TRANSMISSION. ALSO BACK BEARINGS!! WHAT A DISGRACE. RECALL THIS DISGRACEFUL WORKMANSHIP! NO HONOR!
NHTSA ODI #11221524
170,000 miles · Feb 6, 2019
Unknown Or OtherInjury
I WAS GETTING STUFF OUT OF MY BACK SEAT AND MY REAR WINDOW JUST BLEW OUT SHATTERING GLASS ALL OVER .THE BOTTOM PIECE THAT SECURES THE GLASS TO THE DOOR WARPRED ABOUT 6 INCHED ON EACH SIDE EXPLODING THE GLASS
NHTSA ODI #11174673
NHTSA investigations
4EA09013 · Vehicle Rollaway Allegations
Opened Aug 18, 2009 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:automatic Transmission:lever And Linkage:column Shift; Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Additional source detail variants (5)
Power Train:automatic Transmission:gear Position Indication (prndl)
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Power Train:automatic Transmission:lever And Linkage:column Shift
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering:column LOCKING:ANTI-THEFT Device
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
Steering
This investigation is being closed based on several considerations.By the most inclusive counting of all alleged rollaway incidents (i.e., counting all alleged rollaway incidents and assuming a singular failure mechanism), the incident rate is low, however during EA09-013, ODI identified a number of different failure mechanisms in 180 incidents related to the alleged defect.The highest rate for any particular failure mechanism, the failure of the Automatic Transmission Parking System, was 4.4/100K.The next-highest failure rate was for the BSI System, at 3.4/100K.For all identified failure mechanisms there has been a drastically declining trend including very few incidents occurring in recent years.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.For additional information regarding this investigation, see the complete closing resume in the document file for EA09-013. The ODI reports cited above can be reviewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:10168454, 10279630, 10280078.
PE09020 · Vehicle Rollaway Allegations
Opened Apr 21, 2009 · Closed Aug 19, 2009
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Additional source detail variants (3)
Steering:column
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering:column LOCKING:ANTI-THEFT Device
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
Steering
IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABILITY TO SHIFT THE VEHICLE INTO PARK.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA09-013) TO FURTHER ASSESS THE SCOPE, FREQUENCY AND RISK TO MOTOR VEHICLE SAFETY OF THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.
RQ08003 · Rear Liftgate Glass Hatch Failure
Opened Jun 23, 2008 · Closed Oct 24, 2008
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate; Structure:body:hatchback/liftgate:hinge And Attachments; Structure:body:hatchback/liftgate:support Device/strut; Visibility:glass, Side/rear
THIS INVESTIGATION WAS OPENED ON JUNE 23, 2008, BASED ON 34 COMPLAINTS INVOLVING EIGHT INJURIES IN WHICH THE REAR LIFTGATE GLASS HATCH ON MODEL YEAR 2004 FORD EXPLORERS OR MERCURY MOUNTAINEERS BROKE OFF AND FELL, USUALLY WHILE INDIVIDUALS WERE OPERATING THE GLASS HATCH OR LOADING OR UNLOADING ITEMS FROM THE REAR OF THE VEHICLE.FORD CONDUCTED RECALL 04V-442 IN 2004 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 2002 AND CERTAIN MODEL YEAR 2003 FORD EXPLORERS AND MERCURY MOUNTAINEERS.THE INFORMATION FORD PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT FAILURES WITH 2004 VEHICLES WERE PRIMARILY LIFTGATE GLASS HATCH HINGE FAILURES RELATED TO CORROSION AT THE HINGE PIN, WHEREAS THE FAILURES THAT PROMPTED THE RECALL WITH THE EARLIER MODELS WERE PRIMARILY RELATED TO PROBLEMS WITH THE GLASS HATCH'S STRUTS OR FRACTURE OF A PRIOR HINGE DESIGN AT THE BOSS/BOLT CONNECTION AT THE GLASS.ODI'S REVIEW OF FORD'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2004 VEHICLES INDICATES THAT THESE RATES ARE SIGNIFICANTLY LOWER THAN THOSE FOR THE RECALLED POPULATION.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ODI WILL CONTINUE TO MONITOR COMPLAINTS AND TAKE APPROPRIATE ACTION AS NECESSARY.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Structure:body:hatchback/liftgate
THIS INVESTIGATION WAS OPENED ON JUNE 23, 2008, BASED ON 34 COMPLAINTS INVOLVING EIGHT INJURIES IN WHICH THE REAR LIFTGATE GLASS HATCH ON MODEL YEAR 2004 FORD EXPLORERS OR MERCURY MOUNTAINEERS BROKE OFF AND FELL, USUALLY WHILE INDIVIDUALS WERE OPERATING THE GLASS HATCH OR LOADING OR UNLOADING ITEMS FROM THE REAR OF THE VEHICLE.FORD CONDUCTED RECALL 04V-442 IN 2004 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 2002 AND CERTAIN MODEL YEAR 2003 FORD EXPLORERS AND MERCURY MOUNTAINEERS.THE INFORMATION FORD PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT FAILURES WITH 2004 VEHICLES WERE PRIMARILY LIFTGATE GLASS HATCH HINGE FAILURES RELATED TO CORROSION AT THE HINGE PIN, WHEREAS THE FAILURES THAT PROMPTED THE RECALL WITH THE EARLIER MODELS WERE PRIMARILY RELATED TO PROBLEMS WITH THE GLASS HATCH'S STRUTS OR FRACTURE OF A PRIOR HINGE DESIGN AT THE BOSS/BOLT CONNECTION AT THE GLASS.ODI'S REVIEW OF FORD'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2004 VEHICLES INDICATES THAT THESE RATES ARE SIGNIFICANTLY LOWER THAN THOSE FOR THE RECALLED POPULATION.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ODI WILL CONTINUE TO MONITOR COMPLAINTS AND TAKE APPROPRIATE ACTION AS NECESSARY.THIS INVESTIGATION IS CLOSED.
Structure:body:hatchback/liftgate:hinge And Attachments
THIS INVESTIGATION WAS OPENED ON JUNE 23, 2008, BASED ON 34 COMPLAINTS INVOLVING EIGHT INJURIES IN WHICH THE REAR LIFTGATE GLASS HATCH ON MODEL YEAR 2004 FORD EXPLORERS OR MERCURY MOUNTAINEERS BROKE OFF AND FELL, USUALLY WHILE INDIVIDUALS WERE OPERATING THE GLASS HATCH OR LOADING OR UNLOADING ITEMS FROM THE REAR OF THE VEHICLE.FORD CONDUCTED RECALL 04V-442 IN 2004 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 2002 AND CERTAIN MODEL YEAR 2003 FORD EXPLORERS AND MERCURY MOUNTAINEERS.THE INFORMATION FORD PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT FAILURES WITH 2004 VEHICLES WERE PRIMARILY LIFTGATE GLASS HATCH HINGE FAILURES RELATED TO CORROSION AT THE HINGE PIN, WHEREAS THE FAILURES THAT PROMPTED THE RECALL WITH THE EARLIER MODELS WERE PRIMARILY RELATED TO PROBLEMS WITH THE GLASS HATCH'S STRUTS OR FRACTURE OF A PRIOR HINGE DESIGN AT THE BOSS/BOLT CONNECTION AT THE GLASS.ODI'S REVIEW OF FORD'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2004 VEHICLES INDICATES THAT THESE RATES ARE SIGNIFICANTLY LOWER THAN THOSE FOR THE RECALLED POPULATION.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ODI WILL CONTINUE TO MONITOR COMPLAINTS AND TAKE APPROPRIATE ACTION AS NECESSARY.THIS INVESTIGATION IS CLOSED.
Structure:body:hatchback/liftgate:support Device/strut
THIS INVESTIGATION WAS OPENED ON JUNE 23, 2008, BASED ON 34 COMPLAINTS INVOLVING EIGHT INJURIES IN WHICH THE REAR LIFTGATE GLASS HATCH ON MODEL YEAR 2004 FORD EXPLORERS OR MERCURY MOUNTAINEERS BROKE OFF AND FELL, USUALLY WHILE INDIVIDUALS WERE OPERATING THE GLASS HATCH OR LOADING OR UNLOADING ITEMS FROM THE REAR OF THE VEHICLE.FORD CONDUCTED RECALL 04V-442 IN 2004 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 2002 AND CERTAIN MODEL YEAR 2003 FORD EXPLORERS AND MERCURY MOUNTAINEERS.THE INFORMATION FORD PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT FAILURES WITH 2004 VEHICLES WERE PRIMARILY LIFTGATE GLASS HATCH HINGE FAILURES RELATED TO CORROSION AT THE HINGE PIN, WHEREAS THE FAILURES THAT PROMPTED THE RECALL WITH THE EARLIER MODELS WERE PRIMARILY RELATED TO PROBLEMS WITH THE GLASS HATCH'S STRUTS OR FRACTURE OF A PRIOR HINGE DESIGN AT THE BOSS/BOLT CONNECTION AT THE GLASS.ODI'S REVIEW OF FORD'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2004 VEHICLES INDICATES THAT THESE RATES ARE SIGNIFICANTLY LOWER THAN THOSE FOR THE RECALLED POPULATION.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ODI WILL CONTINUE TO MONITOR COMPLAINTS AND TAKE APPROPRIATE ACTION AS NECESSARY.THIS INVESTIGATION IS CLOSED.
Visibility:glass, Side/rear
THIS INVESTIGATION WAS OPENED ON JUNE 23, 2008, BASED ON 34 COMPLAINTS INVOLVING EIGHT INJURIES IN WHICH THE REAR LIFTGATE GLASS HATCH ON MODEL YEAR 2004 FORD EXPLORERS OR MERCURY MOUNTAINEERS BROKE OFF AND FELL, USUALLY WHILE INDIVIDUALS WERE OPERATING THE GLASS HATCH OR LOADING OR UNLOADING ITEMS FROM THE REAR OF THE VEHICLE.FORD CONDUCTED RECALL 04V-442 IN 2004 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 2002 AND CERTAIN MODEL YEAR 2003 FORD EXPLORERS AND MERCURY MOUNTAINEERS.THE INFORMATION FORD PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT FAILURES WITH 2004 VEHICLES WERE PRIMARILY LIFTGATE GLASS HATCH HINGE FAILURES RELATED TO CORROSION AT THE HINGE PIN, WHEREAS THE FAILURES THAT PROMPTED THE RECALL WITH THE EARLIER MODELS WERE PRIMARILY RELATED TO PROBLEMS WITH THE GLASS HATCH'S STRUTS OR FRACTURE OF A PRIOR HINGE DESIGN AT THE BOSS/BOLT CONNECTION AT THE GLASS.ODI'S REVIEW OF FORD'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2004 VEHICLES INDICATES THAT THESE RATES ARE SIGNIFICANTLY LOWER THAN THOSE FOR THE RECALLED POPULATION.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ODI WILL CONTINUE TO MONITOR COMPLAINTS AND TAKE APPROPRIATE ACTION AS NECESSARY.THIS INVESTIGATION IS CLOSED.
DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Illustration