IllustrationTHE VEHICLES POWER STEERING FLUID LEAKED AND CAUSED LOSS OF POWER STEERING. *NLM
1995 Ford Explorer
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1995 Ford Explorer do not stand out strongly from the model-year median of 609.
About this comparison →How this year compares
Owner complaints by model year
Compare all Explorer years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 97 of 843 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 205 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 119 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
84 crash reports32 fire reports69 injury reports
Steering complaints
52 reportsTHE LOWER BALL JOINTS AND THE FRONT OUTER TIE ROD END HAD TO BE REPLACED.MR. CONSUMER STATED THE LOWER BALL JOINTS WERE LOOSE AND HAD TO BE REPLACED FOR A SECOND TIME.*JB
CONSUMER STATES THAT WHEN TRYING TO APPLY THE BRAKES THEY CAN HEAR A LOUD NOISE AND THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED. NLMTHE ABS SENSOR WENT BAD CAUSING THE FRONT DISC BRAKE TO WEAR QUICKLY. THERE WAS A RECALL ISSUED REGARDING THE FRONT SWAY BAR LINKS…
Read full complaint
CONSUMER STATES THAT WHEN TRYING TO APPLY THE BRAKES THEY CAN HEAR A LOUD NOISE AND THE BRAKE PEDAL WILL GO TO THE FLOOR CAUSING THE VEHICLE TO HAVE EXTENDED STOPPING DISTANCE. DEALER NOTIFIED. NLMTHE ABS SENSOR WENT BAD CAUSING THE FRONT DISC BRAKE TO WEAR QUICKLY. THERE WAS A RECALL ISSUED REGARDING THE FRONT SWAY BAR LINKS. CONSUEMR WAS CHARGED FOR LABOR AND PARTS. ALSO THE FRONT LOWER BALL JOINTS WERE REPLACED AS WELL AS THE OUTER TIE RODS. *JG
STEERING WHEEL WOULD INTERMITTENTLY LOCK UP DURING OPERATION OF VEHICLE TRAVELING AT ANY SPEED. STEERING WHEEL WILL LOCK UP WHILE TRAVELING FIVE MPH, AND TURNING INTO A DRIVEWAY OR WHILE TRAVELING ON THE INTERSTATE AT HIGH SPEEDS. DEALERSHIP HAS EXAMINED VEHICLE, AND DETERMINED THAT A "BOOT" AROUND A JOINT IN THE STEERING C…
Read full complaint
STEERING WHEEL WOULD INTERMITTENTLY LOCK UP DURING OPERATION OF VEHICLE TRAVELING AT ANY SPEED. STEERING WHEEL WILL LOCK UP WHILE TRAVELING FIVE MPH, AND TURNING INTO A DRIVEWAY OR WHILE TRAVELING ON THE INTERSTATE AT HIGH SPEEDS. DEALERSHIP HAS EXAMINED VEHICLE, AND DETERMINED THAT A "BOOT" AROUND A JOINT IN THE STEERING COLUMN HAD DETERIORATED FROM EXPOSURE TO SAND. PLEASE PROVIDE ANY ADDITIONAL INFORMATION / DOCUMENTATION.*AK
WHILE TRAVELING IN WET CONDITIONS AT 45MPH CONSUMER LOST CONTROL, VEHICLE WENT INTO A SKID, RESULTING IN MINOR INJURIES TO OCCUPANTS. VEHICLE WAS TOTALED. PLEASE PROVIDE FURTHER INFORMTATION. *AK
AT 5,000 MILES A POPPING SOUND IS COMING FROM STEERING COLUMN. DEALER WAS NOTIFIED, AND REPLACED STEERING COLUMN ON TWO SEPARATE OCCASIONS. BUT, PROBLEM IS STILL REOCCURRING. *AK CLIP FOR UPPER BEARING WAS OUT, DEALER REPLACED AND ALSO RETORQUED BOLTS FOR LOWER SHAFT BEARINGS, UPPER AND LOWER STEERING SHAFTS WERE REPLAC…
Read full complaint
AT 5,000 MILES A POPPING SOUND IS COMING FROM STEERING COLUMN. DEALER WAS NOTIFIED, AND REPLACED STEERING COLUMN ON TWO SEPARATE OCCASIONS. BUT, PROBLEM IS STILL REOCCURRING. *AK CLIP FOR UPPER BEARING WAS OUT, DEALER REPLACED AND ALSO RETORQUED BOLTS FOR LOWER SHAFT BEARINGS, UPPER AND LOWER STEERING SHAFTS WERE REPLACED, LOWER WAS REPLACED TWICE , CONSUMER STATES THERE IS STILL PROBLEMS WITH THE STEERING. POPPING NOISE IN RIGHT FRONT SEAT. RADIO INOPERABLE, DEALER REPLACED, RADIO FAILED AGAIN, DEALER REPLACED AND REPOSITIONED WIRING. CONSOLE ASSEMBLY REPLACED. *SLC
CONSUMER WAS DRIVING AT 55 MPH IN LEFT LANE,AND THERE WAS A RATTLING NOISE. CONSUMER WAS FORCED INTO GUARDRAIL. HAD NO STEERING. TOOK VEHICLE TO DEALER, AND THEY SAID IT WAS SWAY BAR. *AK
POWER STEERING UNIT IS LEAKING. CONSUMER MUST HAVE COMPLETE STEERING RACK UNION REPLACED INSTEAD OF JUST STEERING UNIT WHICH IS MORE EXPENSIVE. *AK
NO SUMMARY
LAST YEAR MY CAR WOULD SHUT DOWN. GO FROM REGULAR RPM TO ZERO AND DIE. THIS WOULD LOCK MY STEERING COLUMN. I OBSERVED THAT THIS HAPPENED WHEN THE OUTDOOR TEMPERATURE EXCEEDED ABOUT 90 DEGREES F AND THE CAR WAS EXPOSED TO SUN (MORE LIKELY TO SHUT DOWN THAT IF I WAS COMING OUT OF A COVERED GARAGE WHERE THE TEMP WAS LOWER, UNTIL EX…
Read full complaint
LAST YEAR MY CAR WOULD SHUT DOWN. GO FROM REGULAR RPM TO ZERO AND DIE. THIS WOULD LOCK MY STEERING COLUMN. I OBSERVED THAT THIS HAPPENED WHEN THE OUTDOOR TEMPERATURE EXCEEDED ABOUT 90 DEGREES F AND THE CAR WAS EXPOSED TO SUN (MORE LIKELY TO SHUT DOWN THAT IF I WAS COMING OUT OF A COVERED GARAGE WHERE THE TEMP WAS LOWER, UNTIL EXPOSED TO THE HIGHER OUTSIDE TEMP READ. THE STEERING COLUMN WOULD LOCK AS THE IGNITION SHUT OFF WHETHER I WAS IDLING IN A DRIVE THRU LANE OR EXISTING A FREEWAY RAMP WHERE I WOULD EXPECT TO GO FROM 55 TO 35 TO ZERO AT THE STOP, I WOULD GO TO ZERO AND BYPASS 34-1 MPH. JUST COMPLETE SYSTEM SHUT DOWN AND COLUMN LOCK. I TOOK THE CARE IN AND THEY SAID IT WAS THE FUEL INJECTORS AND PAID $500 FOR WHO KNOWS WHAT BECAUSE THE PROBLEM PERSISTED. IT'S HOT. THE PROBLEM PERSISTS. IT'S DANGEROUS. AM I PLACING MY FAMILY AT RISK? I ALREADY HAD THE AEROSTAR CATCH FIRE IN THE STEERING COLUMN WHILE I WAS AT FULL FREEWAY SPEED . I AM AFRAID THAT A SIMILAR DEFECT IS AT WORK HERE. THE AERO WAS A MANUAL SO I COULD ALWAYS REV TO KEEP THE RPM UP, THE EXPLORE IS AUTO TRANS AND GOES FROM DRIVE TO LOCK. PLEASE HELP ME. *AK
Official recalls
509V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V402000 · Suspension
Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE.
Consequence & remedy
Consequence: VEHICLE HANDLING COULD BE AFFECTED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH THE LEFT AND RIGHT FRONT SWAY BAR LINKS.
99V310001 · Structure:body:hatchback/liftgate:support Device/strut
Nov 3, 1999
VEHICLE DESCRIPTION: ON CERTAIN SPORT UTILITY VEHICLES, THE HYDRAULIC LIFT CYLINDER BRACKET WELDS COULD FRACTURE.
Consequence & remedy
Consequence: WITH A BROKEN BRACKET WELD, THERE IS A POTENTIAL FOR THE LIFTGATE BRACKET TO GRADUALLY BEND INWARD ALLOWING THE LIFT CYLINDER BALL STUD TO DISENGAGE, UNEXPECTEDLY ALLOWING THE LIFTGATE TO FALL FROM AN OPEN POSITION.
Remedy: DEALERS WILL INSTALL LIFTGATE REINFORCEMENT BRACKETS. DEPENDING UPON THE CONDITION OF THE LIFTGATE SHEET METAL IN THE AREA OF THE BRACKET, DEALERS MAY ALSO INSTALL A LARGER REINFORCEMENT.
95V052000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Mar 15, 1995
IN SOME OF THE VEHICLES, BRAKE TUBES WERE MISROUTED BETWEEN THE MASTER CYLINDER AND THE HYDRAULIC CONTROL UNIT AND RESULTS IN EXCEEDING THE ALLOWABLE STOPPING DISTANCES AS REQUIRED BY FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." IN ADDITION, SEALS WITHIN THE MASTER CYLINDER COULD BE ABRADED BY THIS CONDITION OVER TIME RESULTING IN AN INTERNAL LEAK AND A FURTHER REDUCTION IN BRAKE PERFORMANCE.
Consequence & remedy
Consequence: CONSEQUENCE OF NON-COMPLIANCE: STOPPING DISTANCES COULD BE LONGER THAN INTENDED RESULTING IN INCREASED POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REROUTE THE BRAKE TUBES.
95V053000 · Steering:linkages:tie Rod Assembly
Mar 15, 1995
THE INNER TIE ROD ASSEMBLIES WERE IMPROPERLY MANUFACTURED AND CAN FRACTURE CAUSING SHAKING OR SHIMMY AT LOW SPEEDS.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE THE WHEEL ON THE SIDE WITH THE BROKEN TIE ROD TO TUCK INWARD OR OUTWARD AND SLIDE RESULTING IN AN INCREASED POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSPECT THE INNER TIE RODS AND REPLACE THE SUSPECT TIE RODS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA02011 · Safety Belt Assembly Failure
Opened Jul 2, 2002 · Closed May 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI RECEIVED 18 CONSUMER COMPLAINTS AND FORD IDENTIFIED ANOTHER FOUR REPORTS ASSOCIATED WITH THE ALLEGED DEFECT.MOST OF THE COMPLAINTS INDICATE INABILITY TO LATCH THE DRIVER SEAT BELT BUCKLE CAUSED BY A BROKEN LATCH RELEASE SPRING.NONE OF THESE 22 REPORTS RESULTED IN ANY INJURIES OR CRASHES.NO COMPLAINTS HAVE BEEN RECEIVED IN THE PAST 6 MONTHS.FORD CONDUCTED LIFE-CYCLE TESTING ON 6 FIELD SAMPLE BUCKLE ASSEMBLIES.THE RESULTS OF THAT TESTING DEMONSTRATED THAT THE TESTED BUCKLE ASSEMBLIES COULD BE EXPECTED TO OPERATE PROPERLY BEYOND THE EXPECTED LIFE OF THE VEHICLE.BASED ON THE LIMITED NUMBER OF REPORTS AND COMPLAINTS RECEIVED, AND A DECLINING COMPLAINT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT EXIST DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ADDITIONAL INFORMATION
PE02007 · Safety Belt Assembly
Opened Jan 23, 2002 · Closed Jul 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00039 · Front Suspension Stabilizer Bar Link
Opened Sep 20, 2000 · Closed Nov 30, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE99068 · Accelerator Pedal
Opened Nov 1, 1999 · Closed Mar 9, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
PE97010 · Electrical Fire In Center Console
Opened Mar 13, 1997 · Closed Sep 4, 1997
Status: closed (inferred from source dates) · Electrical System
THIS INVESTIGATION REVEALED THAT CONSOLE FIRES IN THE SUBJECT VEHICLES MOST OFTEN OCCURRED WHILE VEHICLES EQUIPPED WITH THE LAMP OUTAGE MODULE (LOM), WHICH IS PART OF THE MESSAGE CENTER, WERE TOWING A TRAILER AND WHICH HAD BEEN MODIFIED BY ADDING AN AFTERMARKET TRAILER WIRING HARNESS INTO THE VEHICLE'S TAILLIGHT CIRCUITS.THE OWNER'S MANUAL STATES NEVER AND MORE THAN OTHER TRAILER LIGHT BULB TO ONE CIRCUIT HOWEVER TRAILERS FREQUENTLY CONTAIN SEVERAL BULBS.THE RESULTING EXCESS CURRENT PASSING THROUGH THE LOM COULD CAUSE IT TO OVERHEAT RESULTING IN A FIRE.PROPER AFTERMARKET INSTALLATION OF TRAILER WIRING REQUIRES THE USE OF A BYPASS MODULE, WHICH OBTAINS POWER FOR THE TRAILER LIGHTS DIRECTLY FROM THE BATTERY RATHER THAN FROM THE VEHICLE'S TAIL LIGHT AND STOP LAMP CIRCUITS, OR THE USE OF THE MANUFACTURER'S WIRING HARNESS.IN A LETTER DATED SEPTEMBER 2, 1997, FORD NOTIFIED ODI THAT IT INTENDS TO TAKE ACTION TO PRECLUDE FURTHER INCIDENTS INCLUDING ISSUING A TECHNICAL SERVICE BULLETIN TO ITS DEALERS, NOTIFYING TRAILER RENTAL ASSOCIATIONS AND AGENCIES WHERE KNOWN, AND ADVISING OWNERS BY LETTER OF THE PROPER METHOD FOR CONNECTION OF TRAILER TOW WIRING ON THE SUBJECT VEHICLES.THERE WAS NO DEFECT TREND IN THE SUBJECT VEHICLES IDENTIFIED AS A RESULT OF THIS INVESTIGATION, AND FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT WARRANTED TO CONTINUE THE INVESTIGATION.