2024 Ford Expedition

Several of automatic sensors were not working (tire pressure) and the horn. The dealer stated I had road damage and wires were torn loose. I'm a 76 year old woman and I do not take this car off road or have any recollection of such an incident. I maintain the underside of the vehicle is improperly protected. They charged me $2300 to fix it.

The third row seats both have reachable access to the third-row PowerFold buttons even in car seats. My two toddlers can easily reach the fold buttons while strapped in to their seats and are able to recline and move their seats forward and backwards. This caused major safety hazard because their car seats become loose. The buttons are placed very close to the third row seat and are accessible to 35 lb children to press and play with them. While strapped into their car seats, my children easily reached and both touched the buttons and loosened their car seats while the car was in motion and I was driving. There is no software setting or built-in dashboard switch to disable the third-row PowerFold buttons in a Ford Expedition. To prevent the seats from accidentally folding, the most effective permanent solutions are removing the associated fuse, disconnecting the physical wiring harness from the button panel, or physically blocking the switch. This is extremely dangerous and needs to be fixed

This is a report of a recurring, life-safety defect involving unintended vehicle movement in a 2024 Ford Expedition. The vehicle has experienced two separate incidents where it was placed in 'Park,' remained stationary for 13-30 seconds, and then began driving itself backward without driver intervention or throttle input. Incident 1: Occurred on March 29, 2026 and I have this one on video. Incident 2: Occurred on April 8, 2026. The video clearly shows the vehicle remaining stationary and in 'Park' for 13 seconds before the unintended movement begins. This delay proves the movement is not a 'start-up rocking' sensation or 'normal clutch drag,' but a delayed mechanical or electronic failure of the park actuator or transmission system. I presented the vehicle for service at a Ford dealership on April 17, 2026. Despite my report of a delayed-onset rollaway, the dealership documented the issue as a 'normal and desired characteristic' of the 10-speed transmission. They characterized the event as a minor 'rocking' sensation that occurs immediately, which is factually contradicted by my video evidence showing a 13-second delay. This leaves me with an unsafe vehicle prone to unintended movement. I am requesting a formal investigation into a potential park-engagement failure.

The contact owns a 2024 Ford Expedition. The contact stated that while driving at various speeds, the message "Drive Assist Unavailable" was displayed. The contact stated that when the vehicle was turned off and restarted, the system was functional. The contact had taken the vehicle to a local dealer, who checked the 12-Volt battery and found that the battery was operational and there were no other electrical issues. The contact stated that later, while starting the vehicle, the message "Loss of Power Steering Assist" was displayed, and the steering wheel was difficult to turn to the left or the right. The vehicle was turned off and restarted, and regained power steering functionality; however, the failure reoccurred. The contact attempted to reset the electrical system by disconnecting the battery terminals. The contact stated that loss of power steering reoccurred with the loss of the Lane Keep Assist feature. The contact had taken the vehicle back to the same dealer who diagnosed the vehicle and checked the wiring harness and coated the terminal connectors with a gel for better connectivity. The vehicle was repaired; however, the failures reoccurred. Additionally, the contact stated that the “Driving Modes” light was illuminated. The contact stated that while attempting to switch modes to Snow or Sport, or another option, the light illuminated with the message that each selected mode was unavailable. The contact stated that the vehicle would be taken back to the dealer for the failure. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 36,000.

The fuel line/fuel pump was leaking. Smelled fumes from the gasoline. Fuel was leaking over the fuel tank from the top of the tank. The vehicle was drivable when fuel was leaking. Very concerned that their could have been a fire due to the fuel leak. Took the vehicle to the Ford service department where it was purchased. Service shop stated that during inspection they noticed that something chewed through the fuel line/fuel pump. Comments made by the service advisors stated that they have seen squirrels/rodents attracted to the soy based ingredients of the parts/wiring. The repair would not be covered under warranty due to "outside influence". The manufacturer is installing a similar part and not covering under warranty. No warning lights; no warning messages. If the same type of soy based part is being installed, what is going to prevent the same thing from happening. Ford is not offering different types of parts and they do not have a way to prevent additional damage. No shield/tape/covering is being offered. Numerous instances of this referenced online due to soy based parts and Ford knowingly installing these parts without a fix or prevention. Consumer is responsible for all repairs. No warranty.

I am filing this complaint regarding Ford Safety Recall 25S49 (NHTSA Campaign Number 25V315). My vehicle is a 2024 Ford Expedition Max, VIN [XXX] . The Ford pass app and the Ford recall site both show the remedy for the recall as "Available", but when I contact my dealer (Maxwell Ford in Austin, TX) they say that the repair cannot be performed because the update is not yet active in the Oasis dealer system. Ford has had months to release the software fix, but continues to delay the rollout to dealerships. Meanwhile, I have been without my vehicle because the rearview camera is unreliable and considered a safety hazard under the recall. I am paying for a new vehicle that is parked at the dealership and undriveable due to Ford's failure to provide a timely remedy. I have contacted Ford Executive Relations and their social media team, but have received no response or resolution. I am requesting that NHTSA hold Ford accountable for failing to make this safety recall fix available in a timely and transparent manner. The communication has been misleading to owners, and the delay is causing both financial and practical hardship. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Passenger sideview mirror does not open upon unlocking and starting the vehicle. I need to stop (if started driving) turn to park, turn off car, open driver's door to signal car that I have left, lock car using remote, wait few seconds and then unlock to reset car then it usually opens. Issues with mirror began happening a month after purchasing brand new car (5/24), first mirror was "popping or clicking" upon turning outright, mirror had been replaced once, over last year issue has been on going and brought to dealershop " deemed a technological glitch" - no warning lights or messages appear - sometimes my control panel screen will turn black upon starting the car which I now know means to look at my passenger mirror. This last occurred on Friday 7/25/25.

The contact owns a 2024 Ford Expedition. The contact stated while driving 75 MPH, the messages "Pre-Collision Assist Not Available", "Front Camera Default -Service Required", "Lane Merge Default", "Check Parking Sensors", "Blind Spot System Fault", "Cross Traffic System failure", and "Normal Cruise Control Active - Adaptive Braking Off" were displayed. The contact stated that a large red warning box appeared stating 'Resume Control" and the brakes were applied independently, causing the vehicle to come to an abrupt stop. The vehicle was taken to a dealer and the contact was informed that a software update would be released in October, and the vehicle was released. The vehicle was taken to two dealers ; however, the vehicle was not diagnosed, but the system was reset. The contact stated that the failure persisted. The manufacturer was notified of the failure. The failure mileage was approximately 3,000.

The issue involves the purchase of a 2024 Ford Expedition Max, VIN [XXX] , which purchased on [XXX] from Legacy Ford in Corbin, KY. Since purchasing this vehicle, I have encountered the following persistent issues that substantially impair the use, value, or safety of the vehicle: The vehicle was sold to me seemingly infested with rodents, which ate away much of the internal wiring of the engine compartment. The wiring is manufactured with soy-based sheathing, which is a well-known defect and further known to attract rodents/vermin and as I only possessed the vehicle in question for 3 weeks and 5 days (when first sensor light came on and only drove it 1383 miles (7 weeks total). I have been forced to make an insurance claim for this damage, which I feel was resultant of a manufacturing defect, but due to the inexcusable part delay in obtaining replacement wiring, the rental on my policy ran out. I have requested on several occasions, a VIN swap for a different vehicle and was told that this was not something the dealership could do. Despite these defects not being addressed at the Legacy Ford in Corbin, KY. I believe the wiring damage is too extensive to be adequately and safely repaired and I have been without my vehicle, while still making payments and paying out of pocket for transportation for 3 months now. Alton Blakely Ford of Corbin still has not repaired this clearly defective vehicle and the defects continue to exist. As of this letter, the vehicle's odometer reads 1,396 and I have only had the vehicle available to me for my usage for 3 weeks and 5 days. The vehicle is still in the shop and the only response I receive from them is that they are waiting on the part and they have no ide when it may be available. I have written to Ford Motor company and after many e-mail exchanges, the matter was closed by them with no resolution. Thank you for your attention to this matter. I look forward to your response. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F