NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
15 reportsClear category filter20,000 miles · Aug 10, 2026
Power Train
The contact owns a 2022 Ford Expedition. The contact stated that while driving 20 MPH, the transmission was sticking. The failure was a recurring failure. The dealer was contacted, and the vehicle received a software update; however, the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the …
Read full complaint
The contact owns a 2022 Ford Expedition. The contact stated that while driving 20 MPH, the transmission was sticking. The failure was a recurring failure. The dealer was contacted, and the vehicle received a software update; however, the failure persisted. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000.
NHTSA ODI #11755911
Mileage unknown · Jun 10, 2026
EngineFuel/propulsion SystemPower Train
While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion …
Read full complaint
While driving on the highway, my 2022 Ford Expedition suddenly lost acceleration. The gas pedal stopped responding completely and the vehicle gradually lost power until it shut off. It had to be towed and the battery was fully drained afterward. It was later diagnosed as a fuel pump failure. This was a sudden loss of propulsion in traffic and created a serious safety concern. Police pulled over and were able to get me towed to the nearest safe stop as my car stopped on a bridge with no shoulder.
NHTSA ODI #11743375
Mileage unknown · Apr 28, 2026
Power Train
Transmission randomly hard down shifts erratically. It feels like i lose control of the vehicle. Shifting is so violent, it's like I were driving over a man hole with a missing cover. These are under normal operating conditions. Not towing, not hard braking. Not extreme cold or hot climate. There are no warning laps on…
Read full complaint
Transmission randomly hard down shifts erratically. It feels like i lose control of the vehicle. Shifting is so violent, it's like I were driving over a man hole with a missing cover. These are under normal operating conditions. Not towing, not hard braking. Not extreme cold or hot climate. There are no warning laps on the dash board. This issue has been reviewed at 2 different FORD dealer / repair shops. The first location changed the transmission fluid. The second one changed the transmission torque converter. Documentation can be provided. There is no computer data that indicated an issue when hooked up to the Ford mechanic computer diagnostic tool. The problem continues to happen after repair. The vehicle is still under FORD warranty. 2 Ford mechanics have test driven the vehicle after repair. They recognize the problem, and provide no remedy other than what has already been done. This vehicle feels unsafe to drive.
NHTSA ODI #11734256
Mileage unknown · Apr 5, 2026
Power Train
Harsh shifting in relation to TBS 23-2250 causing the vehicle response to be unpredictably unsafe merging or suddenly stopping or accelerating.
NHTSA ODI #11729302
Mileage unknown · Feb 27, 2026
Power Train
Transmission has known issue by Ford Motor Company concerning defective components leading to wear and improper function causing potential safety issues with acceleration and deceleration. My vehicle, I purchased used with 32k miles in April of 2025. I started to have issues with shifting approximately 6 months ago when it wo…
Read full complaint
Transmission has known issue by Ford Motor Company concerning defective components leading to wear and improper function causing potential safety issues with acceleration and deceleration. My vehicle, I purchased used with 32k miles in April of 2025. I started to have issues with shifting approximately 6 months ago when it would shift erratically when cold and when vehicle was not warmed up. On several occasions the vehicle, when shifted into reverse to back out of a parking space, the vehicle hesitates and drops harshly into reverse. This has occurred at least 4 times within the last 3 months. The next issue is when the vehicle is initially started up in the morning and placed into gear to leave my driveway I pull out and it appears to be operating fine. When the transmission goes to upshift it will shift on the gauge screen indicating it is in 3rd gear but either I have no gear and the engine will rev without acceleration, or as in the last circumstance, it will shift to 3rd, jump to 8th gear, and have no accelerator input for approximately 5-10 seconds. The shift indicator shows the transmission then shifts from 8th, to 5th, then down to 3rd and drops harshly into gear and proceeds operation as normal. The transmission will not shift as smoothly as it does when it is warm for approximately 3-5 miles. This type of operation has been identified as being contributed to the interior components of the 10R80 transmission. In particular, the CDF clutch is identified in the TSB for this issue 23-2250. I have had my vehicle at the Ford dealer on 2 occasions for this issue and they have not been able to replicate the issue. I was advised the 2nd time that the service technician stated the transmission was low 2 quarts of fluid and they were unable to get the transmission to replicate the harsh shifting condition. This vehicle was serviced less than 2 months prior and no indication of low fluid was noted in the transmission at the time of service.
NHTSA ODI #11720927
Mileage unknown · Feb 4, 2026
Power Train
While transmission is cold. You can start to back up into the street and will come to a complete stop half in the road and half out. Like as if it were in neutral. Then I violently slams back into reverse. From there once it in drive. It will skip gear and slam into a lower gear. The car will also come to a complete stop like in…
Read full complaint
While transmission is cold. You can start to back up into the street and will come to a complete stop half in the road and half out. Like as if it were in neutral. Then I violently slams back into reverse. From there once it in drive. It will skip gear and slam into a lower gear. The car will also come to a complete stop like in reversing when in drive from a cold starting position.
NHTSA ODI #11715443
123,000 miles · Jul 3, 2025
Power Train
The contact owns a 2022 Ford Expedition. The contact stated that while driving at various speeds, the vehicle was sputtering and making a grinding sound while shifting gear. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed and determined that the transmission had failed, and the front …
Read full complaint
The contact owns a 2022 Ford Expedition. The contact stated that while driving at various speeds, the vehicle was sputtering and making a grinding sound while shifting gear. There were no warning lights illuminated. The vehicle was taken to the dealer, who diagnosed and determined that the transmission had failed, and the front differential needed to be replaced. The contact stated that the front deferential was rebuilt; however, the sputtering failure persisted. The manufacturer was informed of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 123,000.
NHTSA ODI #11671064
Mileage unknown · Feb 14, 2025
EnginePower TrainVisibility/wiper
Wipers are the recalled version missing the little block. HOWEVER, the recall is not for my VIN. Coolant keeps disappearing. Hard shifting and or no movement at all while transmission is cold.
NHTSA ODI #11642675
30,000 miles · Jul 15, 2024
Power Train
The contact owns a 2022 Ford Expedition. The contact stated that on several occasions after his wife had reversed and then shifted to drive, the vehicle made a clunking sound and failed to accelerate as intended for several seconds. On another occasion, while stopped at a stop sign, the accelerator pedal was depressed; however, …
Read full complaint
The contact owns a 2022 Ford Expedition. The contact stated that on several occasions after his wife had reversed and then shifted to drive, the vehicle made a clunking sound and failed to accelerate as intended for several seconds. On another occasion, while stopped at a stop sign, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended for several seconds. The vehicle was taken to a dealer where it was diagnosed that the transmission software needed to be updated. The vehicle was repaired; however, on several occasions, while driving at undisclosed speeds, the contact experienced a failure with an abnormal clunking sound coming from the front of the vehicle. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 30,000.
NHTSA ODI #11602416
Mileage unknown · Oct 30, 2023
Electrical SystemPower TrainVehicle Speed Control
The contact owns a 2022 Ford Expedition. The contact stated while driving at various speeds, the infotainment screen went blank without warning. Occasionally the vehicle would inadvertently shut off once the screen went blank. The contact stated that the adaptive driving system feature would independently active, causing the veh…
Read full complaint
The contact owns a 2022 Ford Expedition. The contact stated while driving at various speeds, the infotainment screen went blank without warning. Occasionally the vehicle would inadvertently shut off once the screen went blank. The contact stated that the adaptive driving system feature would independently active, causing the vehicle to jerk out of the driving lane, and the contact would temporarily lose control of the vehicle. In addition, the contact stated that the vehicle would independently surge forward upon depression of the brake pedal without warning; while in reverse(R) or drive(D). The vehicle was taken to the dealer on multiple occasions however, the parts to repair the vehicle were on backorder. The contact filed a complaint with the manufacturer. The vehicle was not repaired. The failure mileage was unknown.
NHTSA ODI #11552703
Official recalls
12Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.
Consequence & remedy
Consequence: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.
Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.
Mar 31, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Navigator and Expedition vehicles. The front brake lines may contact the engine air cleaner outlet pipe and become damaged, possibly resulting in a brake fluid leak and reduced brake function.
Consequence & remedy
Consequence: A loss of brake function increases the risk of a crash.
Remedy: Dealers will inspect the front brake line and replace the brake line or air cleaner outlet pipe, as necessary, free of charge. Owner notification letters were mailed May 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S47.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE24019 · Low-pressure Fuel Pump Failure
Opened Jul 29, 2024 · Closed Sep 19, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:fuel Pump
On July 29, 2024, the Office of Defects Investigation (ODI) opened PE24019 to investigate complaints of low-pressure fuel pump failures in MY 2021 Ford Bronco vehicles. Some consumers reported that the failure occurred without warning while driving, resulting in a complete loss of motive power with no ability to restart the engine. Ford determined that several other vehicle models contain low-pressure fuel pumps substantially similar to the 2021 Ford Bronco, including the 2022-2023 Ford Bronco, 2018-2023 Ford F-150, 2022-2023 Ford Expedition, 2019-2023 Lincoln Navigator, 2020-2023 Ford F-250-F-550, 2024 Ford Super Duty Chassis Cab, 2024-2025 Ford Ranger, 2020-2023 Ford Explorer, 2020-2023 Lincoln Aviator, and 2021-2025 Ford Mustang. ODI's investigation found that the affected vehicles may lose fuel pressure and flow from the fuel delivery module (consisting of a low-pressure fuel pump, jet pump, reservoir, and other parts) due to a low-pressure pump failure. This can cause the engine to stall while driving. The root cause is reduced internal clearance in the fuel pump, increasing friction and sensitivity to vapor lock. Fuel blockage from contamination inside the jet pump also contributed to the failure. Ford stated that the contamination source was unknown. On July 7, 2025, Ford filed recall 25V-455 for certain 2021-2023 Ford F-550 SD/F-450 SD/F-350 SD/F-250 SD, 2021-2022 Lincoln Navigator, 2021-2022 Ford Mustang, 2021-2022 Ford F-150, 2021-2023 Ford Explorer, 2022 Ford Expedition, and 2021-2023 Ford Bronco vehicles produced between July 1, 2021, and July 30, 2022. The recall also included certain 2021-2023 Lincoln Aviator produced between July 1, 2021, and December 21, 2022. Ford explained in its recall filingthat the production dates used for the recall were based on changes in the manufacturing process. Specifically, Ford determined that in June 2021, the supplier modified the jet pump manufacturing process, producing fuel pump chambers with a lower-than-specified internal clearance. In July 2022, the supplier implemented corrective actions to the manufacturing process by adding two additional vacuum pumps to reduce contamination during the production of the jet pump. ODI has identified approximately 1,000 reports involving vehicles covered in this investigation but excluded from recall 25V-455. However, even with such reports, these vehicles experienced comparatively lower failure rates than the vehicles that are subject to Recall 25V-455. Ford has explained that these vehicles were excluded from the recall population because they did not experience the manufacturing changes that prompted the recall. Specifically, according to Ford, vehicles built before July 1, 2021 (the recall production start date), were not affected by the supplier’s change to the jet pump manufacturing process. Even after closing this investigation, ODI will continue to monitor complaints for vehicles excluded from recall 25V-455 to consider whether they exhibit the same risks as the vehicles encompassed by the recall. The recall remedy is currently under development. In view of Ford’s recall action, ODI is closing this Preliminary Evaluation, but will continue to monitor the issue as a remedy is developed and implemented. ODI will take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration