NHTSA owner reports · September 18, 2026 snapshot.
Fuel/propulsion System complaints
10 reportsClear category filterMileage unknown · Aug 9, 2026
Fuel/propulsion System
While stopped at a traffic light, my 2021 Ford Expedition began running rough. When the light changed and I accelerated through the intersection, the vehicle experienced a severe loss of engine power and barely made it through the intersection. After I pulled off the roadway and released the accelerator, the engine stalled. I w…
Read full complaint
While stopped at a traffic light, my 2021 Ford Expedition began running rough. When the light changed and I accelerated through the intersection, the vehicle experienced a severe loss of engine power and barely made it through the intersection. After I pulled off the roadway and released the accelerator, the engine stalled. I was able to restart the engine once while applying approximately one-quarter throttle. It continued running rough and stalled again when I released the accelerator. The vehicle was taken to Robinson Brothers Ford/Lincoln in Baton Rouge, Louisiana. The Ford dealer documented the rough running, low power and stalling and diagnosed the "fuel pump inop." The dealer removed the fuel tank and replaced the fuel pump/sender assembly. The replacement part listed on the dealer invoice is Ford part JL1Z-9H307-G. Vehicle mileage was approximately 79,390. Several months before the complete failure, during very cold weather, I also experienced one brief incident of unusually low engine power shortly after starting the vehicle. I do not know whether that earlier incident was related. I am concerned that this failure may be related to the low-pressure fuel pump failure condition addressed by Ford Safety Recall 25S75 / NHTSA Recall 25V-455, which includes certain 2022 Ford Expeditions. My 2021 Expedition is not currently included in that recall. The loss of power occurred while I was crossing an intersection and created a serious safety risk. I am submitting this complaint so NHTSA can evaluate this fuel pump failure along with failures involving other vehicles excluded from Recall 25V-455.
NHTSA ODI #11755789
Mileage unknown · Jul 29, 2026
EngineFuel/propulsion System
The engine stalled out while trying to pass someone. The car wouldn't go faster when hitting the gas and felt like I couldnt safely slow down to get back over. It felt like something slipped and lost traction, but roads were dry and not rocky or sandy. tapping breaks and letting off gas did nothing. it has happened before but us…
Read full complaint
The engine stalled out while trying to pass someone. The car wouldn't go faster when hitting the gas and felt like I couldnt safely slow down to get back over. It felt like something slipped and lost traction, but roads were dry and not rocky or sandy. tapping breaks and letting off gas did nothing. it has happened before but usually in winter, and gettin up to speed. its like the gear shift got stuck.
NHTSA ODI #11753596
Mileage unknown · Jul 22, 2026
Fuel/propulsion System
1) 2021 EXPEDITION TOWING A TRAILER, 30 MPH ON UPHILL ON RAMP HATHAWAY BRIDGE PANAMA CITY, FL. I FLOOR THE ACCELERATOR PEDAL TO DOWNSHIFT TO TRY TO ACCELERATE. I HEAR A LOUD CLUNK FROM THE TRANSMISSION. THE CAR GOES INTO NEUTRAL-NOTHING, NO ACCELERATION. I QUICKLY LET OFF THE ACCELERATOR PEDAL AND QUICKLY REAPPLY FORCE TO …
Read full complaint
1) 2021 EXPEDITION TOWING A TRAILER, 30 MPH ON UPHILL ON RAMP HATHAWAY BRIDGE PANAMA CITY, FL. I FLOOR THE ACCELERATOR PEDAL TO DOWNSHIFT TO TRY TO ACCELERATE. I HEAR A LOUD CLUNK FROM THE TRANSMISSION. THE CAR GOES INTO NEUTRAL-NOTHING, NO ACCELERATION. I QUICKLY LET OFF THE ACCELERATOR PEDAL AND QUICKLY REAPPLY FORCE TO THE PEDAL IN A SMOOTH MANNER AND TRANSMISSION RE-ENGAGES AND I PULL AWAY. NO ACCIDENT THIS TIME. OCCURRED APRIL 2026. 2) WHEN STOPPED CAR WILL SOMETIMES LURCH FORWARD 2-3 FEET WHEN 1ST SHIFTING TRANSMISSION FROM PARK INTO DRIVE EVEN THOUGH FOOT IS ON BRAKE FIRMLY. OCCURS INTERMITTENTLY.
NHTSA ODI #11752216
Mileage unknown · Jun 29, 2026
Fuel/propulsion System
This vehicle has 70K miles and the fuel pump died, confirmed by Dick Smith Ford in Columbia, SC. There were no warning lights or messages via our Ford app. There were no symptoms prior to failure. The vehicle just died in the middle of the road on a train track with our family in danger. We could have been hit by cars behind us …
Read full complaint
This vehicle has 70K miles and the fuel pump died, confirmed by Dick Smith Ford in Columbia, SC. There were no warning lights or messages via our Ford app. There were no symptoms prior to failure. The vehicle just died in the middle of the road on a train track with our family in danger. We could have been hit by cars behind us or stuck on the train track with a train approaching. We were in the middle of the road on a train track in Columbia, SC, 2.5hrs away from our home. Our family waited 2.5hrs for the vehicle to be towed and then had to take a $200 Uber from Columbia, SC to Charleston, SC to get home. The quoted cost to repair the vehicle just to get it back home is $2,000. Ford has recalled all the Ford trucks for 2021 that use this same engine. Ford has recalled the 2022 Expedition which is identical to the 2021. Ford has recalled the 2021 Lincoln Navigator that is the same platform as the Expedition only aesthetically upgraded. I believe they didn't recall the 2021 Ford Expedition due the the volume of cars that would be recalled.
NHTSA ODI #11747243
Mileage unknown · Apr 5, 2026
Fuel/propulsion System
Down to 3 gallons gas stopped and added to half a tank. Left vehicle running while filling. Pulled out of gas station and vehicle started to sputter, drove 50 more feet and vehicle died and would not restart. Confirmed unleaded and station had no reports of bad gas. Towed to repair facility where dead fuel pump was diagnosed …
Read full complaint
Down to 3 gallons gas stopped and added to half a tank. Left vehicle running while filling. Pulled out of gas station and vehicle started to sputter, drove 50 more feet and vehicle died and would not restart. Confirmed unleaded and station had no reports of bad gas. Towed to repair facility where dead fuel pump was diagnosed and replaced. Ford recall 25S75 includes some 2022 expeditions but not this 2021 with only 43,000 miles and no previous issues.
NHTSA ODI #11729294
Mileage unknown · Nov 10, 2025
EngineFuel/propulsion SystemPower Train
Vehicle stalls out upon driving when trying to accelerate. Has popped up error which states to check fuel pump.
NHTSA ODI #11698531
Mileage unknown · Sep 20, 2025
Fuel/propulsion System
The fuel pump failed without warning leaving the vehicle stranded in the express lane of a highway. This exposed the vehicle and occupants to serious risk of collision. The vehicle does not allow the transmission to shift to neutral to move the vehicle from live traffic lane when the engine is not running. This is the same fue…
Read full complaint
The fuel pump failed without warning leaving the vehicle stranded in the express lane of a highway. This exposed the vehicle and occupants to serious risk of collision. The vehicle does not allow the transmission to shift to neutral to move the vehicle from live traffic lane when the engine is not running. This is the same fuel pump model at the heart of the ongoing recall on other ford vehicles.
NHTSA ODI #11688589
Mileage unknown · Aug 4, 2025
Fuel/propulsion System
Fuel pump part number JL1Z*9H307*G failed at highway speed leaving vehicle stranded in express traffic lanes. But for the prompt response from FHP this would have resulted in a serious crash. The vehicle has almost never been operated below 30% of fuel capacity and has never been operated to near empty fuel. There are no known w…
Read full complaint
Fuel pump part number JL1Z*9H307*G failed at highway speed leaving vehicle stranded in express traffic lanes. But for the prompt response from FHP this would have resulted in a serious crash. The vehicle has almost never been operated below 30% of fuel capacity and has never been operated to near empty fuel. There are no known wear or accidents that impact the fuel system. there were no warnings or other symptoms prior to the complete pump failure.
NHTSA ODI #11678185
Mileage unknown · Jul 29, 2025
Fuel/propulsion System
Fuel pump failed in express lane, unable to move the vehicle from travel lane under its own power.
NHTSA ODI #11676896
Mileage unknown · Aug 15, 2024
Fuel/propulsion System
My catalytic converter of my 2021 expedition is going out. We had a 2019 Ford Expedition Texas Edition and I had the same issue. We purchased our current expedition in April of 2023. This spring the converter was signaled with the check engine light and since then my vehicle has had issues with acceleration, it consumes gas at a…
Read full complaint
My catalytic converter of my 2021 expedition is going out. We had a 2019 Ford Expedition Texas Edition and I had the same issue. We purchased our current expedition in April of 2023. This spring the converter was signaled with the check engine light and since then my vehicle has had issues with acceleration, it consumes gas at an extremely high rate and my engine works harder over time. My concern is that my vehicle will have an engine malfunction or put me into bankruptcy by the amount of gas it consumes per trip. I found that many other expeditions from the years 2018-2022 have similar issues to mine, in fact one of my friends in town had the same issue. I reported my issue to Ford and they said they would not repair. My vehicle has less than 80k miles on it.
NHTSA ODI #11608787
Official recalls
12Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.
Consequence & remedy
Consequence: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.
Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.
Mar 31, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 Lincoln Navigator, Expedition, and 2022-2023 F-250 SD, F-350 SD, F-450 SD, F-550 SD, and F-600 SD vehicles. The windshield wiper arms may break, causing the wipers to fail.
Consequence & remedy
Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed August 5, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S24.Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on April 1, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Jan 31, 2025
Ford Motor Company (Ford) is recalling certain 2021 Expedition, 2021-2022 Super Duty F-250, F-350, F-450, F-550, F-600, and 2020-2022 Lincoln Corsair vehicles. The rearview camera may display a blank or distorted image.
Consequence & remedy
Consequence: Rearview camera failure can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera as necessary, free of charge. Owner notification letters were mailed September 18, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S05.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
May 17, 2022
Ford Motor Company (Ford) is recalling certain 2021 Expedition and Lincoln Navigator vehicles. An engine compartment fire may occur while driving or parked, even with the ignition in the "Off" position.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures and other vehicles, until the remedy is performed. Dealers will inspect and replace the battery junction box, as necessary, and remove a ground wire. On models equipped with standard-duty radiator fan motors, dealers will also install an auxiliary electrical box with a wire jumper. Repairs will be performed free of charge. Interim owner notification letters informing owners of the safety risk were mailed May 25, 2022. Owners will receive a second letter once the remedy is available. Currently the remedy is available for vehicles equipped with heavy-duty radiator fan motors, and those letters were mailed July 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S36.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Additional source detail variants (2)
Air Bags:sensor:side Impact
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration