← New search

2019 Ford Expedition

Owner reports · Recalls · Investigations

More warning signs than most Expedition years

Owner complaints for the 2019 Ford Expedition are substantially higher than the model-year median of 155.

About this comparison →

When problems were reported

Mileage at the reported incident

186 reports with mileage · 308 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Power Train. Review the 217 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Engine. Review the 107 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Seat Belts. Review the 95 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports3 fire reports33 injury reports

Power Train complaints

217 reports
Clear category filter
Mileage unknown · Aug 21, 2025
Power Train

The transmission is clunking and hard shifting causing the car to not just go when you accelerate. The car stutters and takes a minute to actually go when you press the accelerator. This has caused multiple times where pulling out of a parking lot has been dangerous since I can’t properly get up and go when need be. I had a mech…

Read full complaint

The transmission is clunking and hard shifting causing the car to not just go when you accelerate. The car stutters and takes a minute to actually go when you press the accelerator. This has caused multiple times where pulling out of a parking lot has been dangerous since I can’t properly get up and go when need be. I had a mechanic look at my car and he confirmed my transmission needs to be replaced. There was no warning signs or messages about the failure.

NHTSA ODI #11682197

Mileage unknown · Aug 11, 2025
EnginePower Train

- cam phaser rattle, yes. TSB-23-2143 -possible engine auto start failure while stopped at stoplight, or failure while driving -yes, dealer diagnosed multiple times -yes, dealer -no

NHTSA ODI #11680005

Mileage unknown · Aug 10, 2025
Power Train

The 10 Speed Transmission, also known as 10R80, is absolutely horrible and should be banned. I have had Ford rebuild the transmission more than once and also fully replaced with multiple shop visit with other trans issues. Constant jerking, poor shifting, delayed gear recognition, slipping gears while going highway speeds, are a…

Read full complaint

The 10 Speed Transmission, also known as 10R80, is absolutely horrible and should be banned. I have had Ford rebuild the transmission more than once and also fully replaced with multiple shop visit with other trans issues. Constant jerking, poor shifting, delayed gear recognition, slipping gears while going highway speeds, are all causes for great concern. I am worried all the time that I may get in an accident with one of the skipping that occurs several times monthly. This Trans must be fully recalled due to its safety! This is a major safety issue. Who wants to pay $90,000.00 on a car to have constant transmission issues and jerky driving? This jerking has been worsening again lately and worried I need another trans repair. This happened again today which brings me to this complaint as Ford wont fiix the issue, needing a new style trans altogether!

NHTSA ODI #11679716

Mileage unknown · Aug 7, 2025
Air BagsPower TrainSeat Belts

Passenger air bag light came on and passenger seat belt locked up also the transmission had to be fixed

NHTSA ODI #11679214

Mileage unknown · Jul 29, 2025
Power Train

Issues with the transmission (10R80) started in May 2025 around 79,000 miles, and lasted a few weeks before we could get to the Ford dealer. We have not towed anything or taken the vehicle off roading. We experienced very hard shifting, delayed acceleration, lurching, and loss of power. We were unable to drive the vehicle with…

Read full complaint

Issues with the transmission (10R80) started in May 2025 around 79,000 miles, and lasted a few weeks before we could get to the Ford dealer. We have not towed anything or taken the vehicle off roading. We experienced very hard shifting, delayed acceleration, lurching, and loss of power. We were unable to drive the vehicle without one or more of these things consistently happening. One lurch was particularly violent where our momentum carried us forward while the vehicle slowed dramatically. The loss of power was particularly dangerous because I pulled into traffic and then shifting failed and I couldn’t move. I was stuck in the middle of the road until the gears cycled and eventually started working again. The loss of power also happened to my wife. The transmission issues appeared quickly and then rapidly became worse. We took it to Ford and they said the transmission needed replaced. This would allegedly be better than trying to fix it piece by piece. Apparently Ford could potentially help with costs if I submitted a case, but they would want to try to diagnose and fix it first. This meant being without the vehicle for an extended period and then having to return it to the shop if the part fixed didn’t solve the issue. This is unreasonable given that others online reported similar issues and the “fixes” often did not work. We did not have any dashboard lights illuminate as part of our issues. We had the transmission replaced.

NHTSA ODI #11677102

Mileage unknown · Jul 16, 2025
Power Train

While attempting to accelerate and change lanes on the freeway, the vehicle unexpectedly slipped out of gear and appeared to shift into neutral. During this time, the gas pedal became completely unresponsive, leaving me unable to control the vehicle’s speed. Multiple warning lights and audible alerts activated briefly before dis…

Read full complaint

While attempting to accelerate and change lanes on the freeway, the vehicle unexpectedly slipped out of gear and appeared to shift into neutral. During this time, the gas pedal became completely unresponsive, leaving me unable to control the vehicle’s speed. Multiple warning lights and audible alerts activated briefly before disappearing. I released the gas pedal and attempted to accelerate again, at which point the vehicle re-engaged and resumed normal function. This issue first occurred approximately one month ago and has now happened two additional times. Each incident lasted several seconds during active freeway driving, creating a highly dangerous situation where I had no control over acceleration. This poses a serious safety risk, especially when merging or maneuvering in high-speed traffic. Although no accident has occurred yet, the potential for one is significant and deeply concerning.

NHTSA ODI #11674143

50,000 miles · Jul 8, 2025
Power Train

The contact owns a 2019 Ford Expedition. The contact stated while driving 40 MPH and depressing the accelerator pedal, the vehicle failed to respond as indented and started to decelerate unintendedly. The contact became aware of a rattling sound coming from underneath the vehicle. Several warning lights illuminated. The contact …

Read full complaint

The contact owns a 2019 Ford Expedition. The contact stated while driving 40 MPH and depressing the accelerator pedal, the vehicle failed to respond as indented and started to decelerate unintendedly. The contact became aware of a rattling sound coming from underneath the vehicle. Several warning lights illuminated. The contact stated that the failure had occurred on several occasions. The vehicle was taken to the dealer for repair under a recall; however, the contact was provided the cost for a diagnostic test. The vehicle was not repaired. The manufacturer was notified on the failure, and informed the contact that the vehicle was included in Technical Service Bulletin: 22-2428 (Automatic Transmission - Harsh-Delayed Engagement). The approximate failure mileage was 50,000.

NHTSA ODI #11672080

Mileage unknown · Jul 7, 2025
EngineFuel/propulsion SystemPower Train

My transmission started losing power on acceleration, hard jerk/bang when shifting into gear, transmission slipping, loss of power between shifts

NHTSA ODI #11671597

Mileage unknown · Jul 1, 2025
Power Train

Transmission failure, skipping, and stalling. It can be inspected. My family and Is safety was put at risk when the transmission started stalling out while leaving the exit ramp to turn onto a busy road with constant traffic. As soon as the acceleration pedal was pressed after leaving the stop sign stalling occurred and again at…

Read full complaint

Transmission failure, skipping, and stalling. It can be inspected. My family and Is safety was put at risk when the transmission started stalling out while leaving the exit ramp to turn onto a busy road with constant traffic. As soon as the acceleration pedal was pressed after leaving the stop sign stalling occurred and again at the following stop light upon acceleration. Yes the problem has been confirmed by a dealership. It has not been inspected by the police, insurance, or others. No warning before hand other than it would skip certain gears and jerk really hard.

NHTSA ODI #11670655

99,500 miles · Jul 1, 2025
Power Train

The contact owns a 2019 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle briefly hesitated and failed to properly shift into gear. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the deale…

Read full complaint

The contact owns a 2019 Ford Expedition. The contact stated while driving at an undisclosed speed, the vehicle briefly hesitated and failed to properly shift into gear. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 99,500.

NHTSA ODI #11670625

Official recalls

11

26V402000 · Power Train:automatic Transmission

Jun 24, 2026

Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.

Consequence & remedy

Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.

Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.

26V368000 · Structure:interior Panels:center Console

Jun 9, 2026

Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.

Consequence & remedy

Consequence: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.

Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.

26V344000 · Seat Belts:pretensioner

May 27, 2026

Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.

Consequence & remedy

Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.

Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.

25V886000 · Electrical System: Instrument Cluster/panel

Dec 18, 2025

Ford Motor Company (Ford) is recalling certain 2019 Expedition vehicles previously repaired incorrectly under recall number 20V263. The "Transmission Not In Park" warning message and associated chime duration are shorter than intended.

Consequence & remedy

Consequence: If the driver exits the vehicle without the transmission being shifted into park, unintended vehicle movement may result, increasing the risk of injury or crash.

Remedy: Dealers will update the instrument cluster panel software, free of charge. Owner notification letters were mailed January 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C71. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning January 15, 2026.

25V197000 · Seat Belts:pretensioner

May 23, 2025

Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.

Consequence & remedy

Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.

Remedy: Dealers will replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S31. Some vehicles in this recall that were previously inspected under recall 24V-099 and did not have parts replaced will need to have this new recall remedy completed.

24V852000 · Equipment:other:labels

Nov 8, 2024

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

Consequence & remedy

Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

24V099000 · Seat Belts:pretensioner

Feb 9, 2024

Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.

Consequence & remedy

Consequence: Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.

Remedy: Dealers will replace the seat belt retractors, as necessary. Additionally, dealers will install an HVAC drain tube elbow if it is missing. Repairs will be performed free of charge. Owner notification letters were mailed on July 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S06.

23V420000 · Equipment:other:owners/service/other Manual

Jun 9, 2023

Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."

Consequence & remedy

Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.

Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.

20V263000 · Electrical System: Instrument Cluster/panel; Power Train:automatic Transmission:gear Position Indication (prndl)

May 8, 2020

Ford Motor Company (Ford) is recalling certain 2019 Expedition and 2019-2020 Mustang vehicles. The "Transmission Not In Park" warning message and associated chime duration are shorter than intended.

Consequence & remedy

Consequence: If the driver exits the vehicle without the transmission being shifted into park, unintended vehicle movement may result, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S21.

Additional source detail variants (2)

Electrical System: Instrument Cluster/panel

Ford Motor Company (Ford) is recalling certain 2019 Expedition and 2019-2020 Mustang vehicles. The "Transmission Not In Park" warning message and associated chime duration are shorter than intended.

Consequence: If the driver exits the vehicle without the transmission being shifted into park, unintended vehicle movement may result, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S21.

Power Train:automatic Transmission:gear Position Indication (prndl)

Ford Motor Company (Ford) is recalling certain 2019 Expedition and 2019-2020 Mustang vehicles. The "Transmission Not In Park" warning message and associated chime duration are shorter than intended.

Consequence: If the driver exits the vehicle without the transmission being shifted into park, unintended vehicle movement may result, increasing the risk of injury or crash.

Remedy: Ford will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S21.

19V773000 · Suspension:rear

Oct 28, 2019

Ford Motor Company (Ford) is recalling certain 2019 Expedition and Lincoln Navigator vehicles. The rear suspension toe link fasteners may not have been properly tightened to the frame, possibly allowing separation from the frame.

Consequence & remedy

Consequence: A disconnected toe link can cause a sudden change to vehicle handling, increasing the risk of a crash.

Remedy: Ford has notified owners, and dealers will inspect and tighten the rear toe link fasteners, check and adjust the rear toe alignment, and inspect the rear tires for abnormal tire wear, replacing them if necessary. Repairs will be performed free of charge. The recall began November 14, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S36.

19V633000 · Seats:front Assembly:recliner; Seats:mid/rear Assembly

Aug 28, 2019

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence & remedy

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Additional source detail variants (2)

Seats:mid/rear Assembly

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Seats:front Assembly:recliner

Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

RQ24015 · Seat Belt Retractor Pretensioner Inadvertent Deployment

Opened Nov 15, 2024 · Closed Jul 23, 2025

Status: closed (inferred from source dates) · Seat Belts:pretensioner

On November 22, 2023, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) PE23021 to investigate complaints of front seat belt retractor pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints alleged hearing a loud, explosion-like sound immediately followed by the seat belt tightening around the occupant’s torso area. The complaints did not state that a crash occurred that may have resulted in the deployment of the pretensioner system, suggesting that this deployment was inadvertent or otherwise unwarranted. On February 9, 2024, Ford issued safety recall 24V-099, recalling certain MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and June 30, 2019. Ford described the defect as a seat belt retractor pretensioner assembly that may develop corroded squib pins, resulting in high resistance or an open circuit, which could result in an inadvertent deployment of a pretensioner and an increased risk of injury due to the loss of the pretensioner’s protection and a seat belt that remains in the locked position. This recall includes 77,574 vehicles. On November 15, 2024, ODI opened this Recall Query (RQ24015) after receiving 3 complaints involving vehicles not included in recall 23V-099 but that alleged a similar failure. As a result of this investigation, Ford issued safety recall 25V-197 on March 28, 2025, to expand the scope of 24V-099 to include MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and July 31, 2020. This recall includes 105,322 vehicles, some of which are also included in 24V-099. Additionally, on May 23, 2025, Ford issued 25V-197 Amendment #1, which further expands the recall population’s scope for vehicles with build dates of September 2018. This amendment added 7,627 additional vehicles to the 25V-197 population. In response to ODI’s inquiries in RQ24015, Ford indicated that it cannot conclusively determine the root cause of the relevant failure. Ford was able to determine that certain pretensioners may develop corroded squib pins potentially resulting in inadvertent deployment, but it was unable to specify the cause of corrosion. Without a specific root cause, Ford assessed field performance of pretensioners to determine the scope of the recalls. ODI is aware of three vehicles that experienced pretensioner inadvertent deployment that are not included in either 25V-197 or 24V-099. Two of these vehicles are MY 2018 Lincoln Navigator vehicles built prior to October 1, 2018, and both experienced failures after more than six years of use/exposure while the recalled vehicles experienced higher rate of failures with less exposure. The remaining incident involves a MY 2021 Ford Expedition that was built after July 31, 2020. ODI is not aware of any other relevant failures in vehicles built after July 31, 2020. As such, ODI has not currently identified a safety defect trend for this issue in vehicles outside of the recalled populations. ODI will continue to monitor allegations of pretensioner inadvertent deployment in subject vehicles that are not included in 25V-197. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24015). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

PE23021 · Seat Belt Pretensioner Inadvertent Deployment

Opened Nov 22, 2023 · Closed Jul 29, 2024

Status: closed (inferred from source dates) · Seat Belts:pretensioner

On November 22, 2023, the Office of Defects Investigation (ODI) opened PE23-021 to investigate instances of seat belt pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints allege hearing a loud, explosion-like sound immediately followed by the seatbelt tightening around the occupant’s torso area. The complaints do not allege a crash occurred that may have resulted in the deployment of the pretensioner system. The investigation revealed certain seatbelt pretensioners may develop corroded squib pins where the bridge wire (heating element of pyro-technic device) is welded. Extended corrosion and a partial separation of the weld may cause a high resistance or an open circuit condition to occur, potentially resulting in pretensioner inadvertent deployment. Inadvertent pretensioner deployment will result in the seatbelt being locked in position, no longer able to extend or retract as designed, which may result in injury in the event of a crash. 11 minor injuries were reported due this failure. Most injuries were bruising to the torso area caused by the rapid tightening of the seatbelt during an inadvertent deployment. On February 9, 2024, Ford filed recall 24V099 for certain MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles with production dates between October 1, 2018, and June 30, 2019. The recall remedy provides the replacement of both front seatbelt retractors if found to have a production date code within the suspect production date range. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.