NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
33 reportsClear category filter83,000 miles · Sep 27, 2022
Electrical SystemEngine
The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, he heard a loud noise coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failur…
Read full complaint
The contact owns a 2018 Ford Expedition. The contact stated while starting the vehicle, he heard a loud noise coming from the vehicle. The vehicle was taken to the dealer and the contact was informed that the cam phaser needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and informed of the failure however, no assistance was provided. The failure mileage was 83,000.
NHTSA ODI #11486768
Mileage unknown · Sep 9, 2022
Electrical SystemEngineFuel/propulsion System
About 20 times now, while I am on the freeway, sometimes when I am coasting, and other times when I am trying to quickly accelerate, my car down shifts out of nowhere and loses power, again either when I am in the fast lane coasting, or trying to merge into traffic. It's like it is going to stall and when I step on the gas, it j…
Read full complaint
About 20 times now, while I am on the freeway, sometimes when I am coasting, and other times when I am trying to quickly accelerate, my car down shifts out of nowhere and loses power, again either when I am in the fast lane coasting, or trying to merge into traffic. It's like it is going to stall and when I step on the gas, it just revs and doesn't get into gear and go. I have almost been rear ended because I go from 70 to like 40 mph. When I was trying to merge into traffic, I got partially into the other lane and then it just wouldn't go. I could easily have been hit. One time when I was coasting and it did it, a warning came on, and then a check manual, but it went away too fast. I have taken it to the dealer and a repair shop multiple times and they can't replicate it. It could definitely cause an accident as my car suddenly slows down and it won't accelerate. I have to wait about 10-15 seconds until it reengages. It makes aloud clunking/dropping sound as if I ran over something and one time it sounded like a million pebbles were inside my engine and under my car. No diagnostic numbers are coming up and it's like no one knows what I am talking about. But multiple Fords are having this issue and they are not doing anything about it. I took it in during my warranty and now it's out of warranty and I'm going to have to pay for something that they should have repaired from the get go. This is dangerous.
NHTSA ODI #11483699
Mileage unknown · Jul 19, 2021
Electrical SystemFire
Electrical fire under hood occurred spontaneously. Just before my vehicle shut off the dash board read something about to conserve battery shut engine off. Pulled over got out of car and it burned . Insurance agent is investigating. Sherriff and fireman said it was electrical fire under hood. Had I not decided to pull over at re…
Read full complaint
Electrical fire under hood occurred spontaneously. Just before my vehicle shut off the dash board read something about to conserve battery shut engine off. Pulled over got out of car and it burned . Insurance agent is investigating. Sherriff and fireman said it was electrical fire under hood. Had I not decided to pull over at rest stop when I did we would have been on freeway when it ignited.
NHTSA ODI #11425507
Mileage unknown · Mar 5, 2021
Electrical SystemExterior LightingService Brakes
UNDER WARRANTY, MOISTURE WAS PRESENT IN ALL THE REAR BRAKE LIGHTS. THE UPPER (THIRD) BRAKE LIGHT HAD THE MOST CONDENSATION. AN AUTHORIZED FORD DEALER REVIEWED THE ISSUE AND ADVISED FORD DOES NOT COVER MOISTURE WITHIN A LIGHT AS THE MOISTURE WILL DISSIPATE OVER TIME. I ADVISED THE UPPER BRAKE LIGHT WAS NEVER DRY, THEY INSISTED WA…
Read full complaint
UNDER WARRANTY, MOISTURE WAS PRESENT IN ALL THE REAR BRAKE LIGHTS. THE UPPER (THIRD) BRAKE LIGHT HAD THE MOST CONDENSATION. AN AUTHORIZED FORD DEALER REVIEWED THE ISSUE AND ADVISED FORD DOES NOT COVER MOISTURE WITHIN A LIGHT AS THE MOISTURE WILL DISSIPATE OVER TIME. I ADVISED THE UPPER BRAKE LIGHT WAS NEVER DRY, THEY INSISTED WARRANTY WOULD NOT COVER THE ISSUE. I COULD REPLACE THE LIGHT, I RECEIVED A QUOTE AT THAT TIME. NOW THE UPPER BRAKE LIGHT HAS LESS THAN 2 LED'S WORKING AND THE VISIBILITY IS NEXT TO NOTHING. REVIEWING FORUMS, THIS IS AN ISSUE THAT HAS BEEN PRESENT IN THE FORD EXPEDITIONS SINCE THE NEW VEHICLE DESIGN CHANGE. MY CONCERN IS VERY SIMPLE, THAT BRAKE LIGHT IS IMPORTANT IN THE SAFETY OF OUR PASSENGERS, THOSE AROUND THE VEHICLE AND THE VEHICLE ITSELF. WE HAVE NOT BEEN IN A REAR END COLLISION WITH THIS VEHICLE, BUT IT IS DIFFICULT TO SEE BRAKING OF THIS VEHICLE AHEAD WHEN THE VEHICLE IS ONE CAR AHEAD OF YOU BASED ON WHAT I HAVE SEEN WHEN DRIVING BEHIND THIS VEHICLE MYSELF. I CONSIDER THIS BRAKE LIGHT A SIGNIFICANT COMPONENT OF THE SAFETY FEATURES IN OUR VEHICLE. TIMING OF THE ISSUE WAS OVER A PERIOD OF TIME. FIRST PHASE WAS MOISTURE NOT DISSIPATING, SECOND PHASE HAS BEEN THE LED LIGHTING CONTINUES TO STOP WORKING, A FEW LED'S AT FIRST, NOW ONLY A FEW ARE OPERATIONAL, AND DIM AT BEST DUE TO THE CONTINUED MOISTURE IN THE UPPER REAR BRAKE LIGHT ASSEMBLY.
NHTSA ODI #11399251
48,000 miles · May 11, 2020
Electrical SystemUnknown Or Other
THE VEHICLE HAS AN INTERMITTENT ELECTRICAL PROBLEM WHICH CAUSES A CROSS TRAFFIC SYSTEM FAULT, BLIND SPOT SYSTEM FAULT AND THE LIFTGATE OR LIFTGLASS TO INDICATE THAT IT IS AJAR. HEN THESE FAULT THE SAFETY SYSTEMS ARE INOPERATIVE AND POSE A SAFETY CONCERN. THIS OCCURS WHILE IN MOTION AT BOTH ON BOTH CITY STREETS AND AT HIGHWAY…
Read full complaint
THE VEHICLE HAS AN INTERMITTENT ELECTRICAL PROBLEM WHICH CAUSES A CROSS TRAFFIC SYSTEM FAULT, BLIND SPOT SYSTEM FAULT AND THE LIFTGATE OR LIFTGLASS TO INDICATE THAT IT IS AJAR. HEN THESE FAULT THE SAFETY SYSTEMS ARE INOPERATIVE AND POSE A SAFETY CONCERN. THIS OCCURS WHILE IN MOTION AT BOTH ON BOTH CITY STREETS AND AT HIGHWAY SPEEDS. *TR
NHTSA ODI #11324175
23,500 miles · Apr 23, 2020
Electrical SystemStructureUnknown Or Other
THE RETRACTABLE/AUTOMATIC RUNNING BOARD ON THE PASSENGER SIDE INTERMITTENTLY DROPS DOWN WHEN THE CAR IS IN PARK AND IN A STATIONARY POSITION FOR A PERIOD OF TIME. (IE. 2-3 HOURS AT REST) WHEN I RESTART THE VEHICLE AND OPEN/CLOSE THE DOORS, THEN SHUT OFF THE VEHICLE, THE RETRACTABLE RUNNING BOARDS WILL GO BACK UP WHERE THEY BE…
Read full complaint
THE RETRACTABLE/AUTOMATIC RUNNING BOARD ON THE PASSENGER SIDE INTERMITTENTLY DROPS DOWN WHEN THE CAR IS IN PARK AND IN A STATIONARY POSITION FOR A PERIOD OF TIME. (IE. 2-3 HOURS AT REST) WHEN I RESTART THE VEHICLE AND OPEN/CLOSE THE DOORS, THEN SHUT OFF THE VEHICLE, THE RETRACTABLE RUNNING BOARDS WILL GO BACK UP WHERE THEY BELONG...MOST OF THE TIME. SEVERAL DAYS LATER, THE SAME THING HAPPENS AGAIN. I TOOK THE VEHICLE IN FOR SERVICE (CRONIN FORD - HARRISON, OHIO) IN THE FALL OF 2019 AND THEY REPLACED THE RETRACTABLE RUNNING BOARD MOTOR ON THE PASSENGER SIDE ONLY. IN MARCH OF 2020, IT STARTED TO HAPPEN AGAIN, AFTER THE VEHICLE IS AT REST FOR 2-3 HOURS. I AM PLANNING TO TAKE IT IN FOR SERVICE AGAIN, BUT I'M CONCERNED THAT THIS WILL BECOME A RECURRING PROBLEM WELL AFTER THE WARRANTY PERIOD IS OVER.
NHTSA ODI #11322054
29,375 miles · Apr 23, 2020
Electrical SystemPower Train
UPON STARTUP, THE DASHBOARD MONITOR WILL NOT LIGHT UP AND THE TRANSMISSION WILL NOT GO INTO GEAR. THIS INCLUDES NO BACKUP CAMERAS, RADIO, MAPPING FEATURE, OR HANDS FREE BLUETOOTH ON THE MONITOR, WHILE THE DASHBOARD (DIRECTLY IN FRONT OF THE STEERING WHEEL AREA) FLASHES ON/OFF THAT "TRANSMISSION NOT IN PARK", OR "OIL NEEDS TO BE…
Read full complaint
UPON STARTUP, THE DASHBOARD MONITOR WILL NOT LIGHT UP AND THE TRANSMISSION WILL NOT GO INTO GEAR. THIS INCLUDES NO BACKUP CAMERAS, RADIO, MAPPING FEATURE, OR HANDS FREE BLUETOOTH ON THE MONITOR, WHILE THE DASHBOARD (DIRECTLY IN FRONT OF THE STEERING WHEEL AREA) FLASHES ON/OFF THAT "TRANSMISSION NOT IN PARK", OR "OIL NEEDS TO BE CHANGED", YET THE TRANSMISSION IS STUCK IN PARK. AFTER TRYING SEVERAL TIMES TO MANUALLY PUT THE CAR INTO "DRIVE" IT WILL FINALLY START MOVING FORWARD WITH A GRINDING SOUND, BEFORE COMING TO AN ABRUPT STOP. THIS SEQUENCE OCCURS SEVERAL TIMES, UNTIL I TURN THE CAR OFF AND TRY AGAIN. IT SOMETIMES TAKES 4-5 ATTEMPTS OVER 5-10 MINUTES TO GET THE CAR MOVING WITH ALL ITEMS WORKING PROPERLY. IT SEEMS ELECTRICAL, SINCE IT ALWAYS INVOLVES BOTH THE DASH MONITOR AND THE TRANSMISSION AT THE SAME TIME.
NHTSA ODI #11322053
15,000 miles · Sep 13, 2019
Electrical SystemEngineService BrakesInjury
EVEN THOUGH I HAVE PUT THE CAR IN PARK, IT STILL MOVES AND HAS HIT ME AND SOME OF THE PASSENGERS GETTING OUT THE CAR WITH THE DOORS AND OTHER PARTS OF THE VEHICLE ALMOST RUNNING US OVER. THE VEHICLE WAS PUT IN PARK ACCORDING TO DIAL. HOWEVER, IT STILL MOVED.
NHTSA ODI #11255235
500 miles · Jun 19, 2019
Electrical SystemEngineSteering
TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHUT OFF AND THE CONTACT DISCONNECTED THE BATTERY. ALSO, THE RUNNING BOARDS FAILED TO RETRACT AND THE STEERING WHEEL PULLED TO THE LEFT AND RIGHT. THE CONTACT STATED THAT THE DRIVE CONTROL MALFUNCTION SERVICE REQUESTED, HILL DESCENT FAULT,…
Read full complaint
TL* THE CONTACT OWNS A 2018 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHUT OFF AND THE CONTACT DISCONNECTED THE BATTERY. ALSO, THE RUNNING BOARDS FAILED TO RETRACT AND THE STEERING WHEEL PULLED TO THE LEFT AND RIGHT. THE CONTACT STATED THAT THE DRIVE CONTROL MALFUNCTION SERVICE REQUESTED, HILL DESCENT FAULT, ELECTRONIC LIMITED SLIP DIFFERENTIAL, REDUCED TORQUE, DRIVE CONTROL, PRE COLLISION ASSIST NOT AVAILABLE, SERVICE ADVANCETRAC, AND TRACTION CONTROL WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THOROUGHBRED FORD (8501 N BOARDWALK AVE, KANSAS CITY, MO 64154, (816) 505-1818) AND SEEKINS FORD LINCOLN (1625 SEEKINS FORD DR, FAIRBANKS, AK 99701, (907) 459-4000) WHERE IT WAS DIAGNOSED THAT THE STEERING SENSOR NEEDED TO BE RESET AND THE STEERING WHEEL NEEDED TO BE ADJUSTED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: CAS21880081. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 500.
NHTSA ODI #11221265
8,161 miles · Jun 14, 2019
Electrical SystemSeat BeltsSuspension
TAKATA RECALL. ON 4/29/19 THE 2ND ROW MIDDLE SEAT BELT WAS REPLACED AFTER HAVING BEEN IN THE SHOP 2X FOR DIAGNOSIS. IT WOULD NOT RELEASE OUT TO BUCKLE. IT KEPT SNAGGING ON ITSELF INSIDE. ON 6/11/19 THE VEHICLE WAS TAKEN IN TO BE DIAGNOSED FOR BAD STRUT. TURNS OUT 3 OF THE 4 WERE BAD AND NEED REPLACED. THE DEALERSHIP WOULD NOT RE…
Read full complaint
TAKATA RECALL. ON 4/29/19 THE 2ND ROW MIDDLE SEAT BELT WAS REPLACED AFTER HAVING BEEN IN THE SHOP 2X FOR DIAGNOSIS. IT WOULD NOT RELEASE OUT TO BUCKLE. IT KEPT SNAGGING ON ITSELF INSIDE. ON 6/11/19 THE VEHICLE WAS TAKEN IN TO BE DIAGNOSED FOR BAD STRUT. TURNS OUT 3 OF THE 4 WERE BAD AND NEED REPLACED. THE DEALERSHIP WOULD NOT REPLACE THE 4TH STRUT EVEN THOUGH SHE STATED ITS BEEN A BIG PROBLEM LATELY. ALSO THE LIFT GATE WAS INSPECTED AS IT OPENS AND CLOSES ON ITS OWN PERIODICALLY. THEY COULD NOT GET THE LIFT GATE TO RECREATE THE PROBLEM AND SINCE THE VEHICLE DIDNT THROW A CODE FOR IT THEY CANT DO ANYTHING ABOUT IT. I HAVE AN APPOINTMENT FOR 6/19/19 TO HAVE THE 3 STRUTS REPLACED AND THE LIFT GATE CHECKED AGAIN.
NHTSA ODI #11220048
Official recalls
14Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.
Consequence & remedy
Consequence: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.
Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S31. Some vehicles in this recall that were previously inspected under recall 24V-099 and did not have parts replaced will need to have this new recall remedy completed.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence & remedy
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components:master Cylinder
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Service Brakes, Hydraulic:power Assist
Ford Motor Company (Ford) is recalling certain 2017-2018 F-150, Expedition, and Lincoln Navigator vehicles. The brake master cylinder may allow brake fluid to leak from the front wheel circuit into the brake booster.
Consequence: A brake fluid leak can cause reduced brake function and extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will replace the brake master cylinder. If the master cylinder is leaking, the brake booster will also be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S37. This recall is an expansion of NHTSA recall number 22V-150.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Feb 9, 2024
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors, as necessary. Additionally, dealers will install an HVAC drain tube elbow if it is missing. Repairs will be performed free of charge. Owner notification letters were mailed on July 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S06.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Nov 14, 2018
Ford Motor Company (Ford) is recalling certain 2018 Lincoln Navigator, and Ford Expedition vehicles. The second row center seat track assemblies may be missing one or both of the J-Channel reinforcement brackets, possibly allowing the seat to move in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, a seat that moves may not properly restrain the seat occupant, increasing their risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the second row center seat for any missing J-channel reinforcement brackets, replacing the center seat frame assembly as necessary, free of charge. An interim owner notification was sent on December 21, 2018. A second letter will be mailed once the remedy is available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S37
Jun 12, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition, F-150, and Lincoln Navigator vehicles equipped with 3.5L GTDI V6 engines. These vehicles have high pressure fuel pump assemblies with welds that can fracture, which may cause an oil or fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the high pressure fuel pump and associated components, free of charge. The recall began July 17, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S17.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford F-150 and 2018 Ford Expedition and Mustang and Lincoln Navigator vehicles equipped with 10-speed automatic transmissions. A roll pin may not have been installed in the transmission, potentially causing a loss of the "Park" function.
Consequence & remedy
Consequence: Despite the transmission shift lever being placed in 'Park' and the instrument panel display indicating 'Park,' the vehicle may roll away after it has been exited if the parking brake has not been applied, increasing the risk of injury or a crash.
Remedy: Ford will notify owners, and dealers will inspect the transmission to make sure it has the roll pin, installing one if it is missing, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S09.
Apr 4, 2018
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence & remedy
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Additional source detail variants (2)
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2018 F-650 and F-750 vehicles equipped with 6-speed automatic transmissions and 2018 Ford F-150 and Expedition vehicles equipped with 10-speed automatic transmissions (excluding Expedition vehicles with a Rotary Gear Shift Dial on the console). The gear shift cable clip may not be properly seated, allowing the transmission to be in a different gear than indicated by the gear shift lever position.
Consequence: If the gear shift cable clip becomes unseated or dislodged, the gear shift lever position may indicate that the transmission is in 'Park' when it may be in a different gear. Additionally, despite selecting 'Park', if the parking brake is not applied before the vehicle is exited, the vehicle may roll. Either scenario increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on April 13, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 18S10.
Jan 16, 2018
Ford Motor Company (Ford) is recalling certain 2018 Ford Expedition and Lincoln Navigator vehicles. The second row window control modules may intermittently stop the movement of the power window. If something, such as a finger, is pinched by the window glass, the stopped window control module may prevent the window from automatically reversing. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 118, "Power-Operated Window Systems."
Consequence & remedy
Consequence: If the window does not automatically reverse when an obstruction is found, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the second row window electronic control modules, and replace them as necessary based on their build date codes, free of charge. The recall began on February 16, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18C01.
Dec 1, 2017
Ford Motor Company (Ford) is recalling certain 2018 Expedition vehicles. The second row outboard seats may have excessive forward adjustment capability and/or may have an improperly installed bolt that secures the seat back to the seat base. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 202a, "Head Restraints", number 207, "Seating Systems", and number 210, "Seat Belt Anchorage System."
Consequence & remedy
Consequence: If the seat back is not adequately secured, and/or the seat occupant is improperly positioned, there can be an increased risk of injury in a crash.
Remedy: Ford will notify owners, and dealers will inspect the second row outboard seats for proper seat adjustment travel, replacing the seat frame assembly if necessary. Dealers will also inspect the bolts attaching the seat back to the seat base for the proper installation, correcting it as necessary. These repairs will be made free of charge. The recall began on January 10, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C20.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ24015 · Seat Belt Retractor Pretensioner Inadvertent Deployment
Opened Nov 15, 2024 · Closed Jul 23, 2025
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On November 22, 2023, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) PE23021 to investigate complaints of front seat belt retractor pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints alleged hearing a loud, explosion-like sound immediately followed by the seat belt tightening around the occupant’s torso area. The complaints did not state that a crash occurred that may have resulted in the deployment of the pretensioner system, suggesting that this deployment was inadvertent or otherwise unwarranted. On February 9, 2024, Ford issued safety recall 24V-099, recalling certain MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and June 30, 2019. Ford described the defect as a seat belt retractor pretensioner assembly that may develop corroded squib pins, resulting in high resistance or an open circuit, which could result in an inadvertent deployment of a pretensioner and an increased risk of injury due to the loss of the pretensioner’s protection and a seat belt that remains in the locked position. This recall includes 77,574 vehicles. On November 15, 2024, ODI opened this Recall Query (RQ24015) after receiving 3 complaints involving vehicles not included in recall 23V-099 but that alleged a similar failure. As a result of this investigation, Ford issued safety recall 25V-197 on March 28, 2025, to expand the scope of 24V-099 to include MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and July 31, 2020. This recall includes 105,322 vehicles, some of which are also included in 24V-099. Additionally, on May 23, 2025, Ford issued 25V-197 Amendment #1, which further expands the recall population’s scope for vehicles with build dates of September 2018. This amendment added 7,627 additional vehicles to the 25V-197 population. In response to ODI’s inquiries in RQ24015, Ford indicated that it cannot conclusively determine the root cause of the relevant failure. Ford was able to determine that certain pretensioners may develop corroded squib pins potentially resulting in inadvertent deployment, but it was unable to specify the cause of corrosion. Without a specific root cause, Ford assessed field performance of pretensioners to determine the scope of the recalls. ODI is aware of three vehicles that experienced pretensioner inadvertent deployment that are not included in either 25V-197 or 24V-099. Two of these vehicles are MY 2018 Lincoln Navigator vehicles built prior to October 1, 2018, and both experienced failures after more than six years of use/exposure while the recalled vehicles experienced higher rate of failures with less exposure. The remaining incident involves a MY 2021 Ford Expedition that was built after July 31, 2020. ODI is not aware of any other relevant failures in vehicles built after July 31, 2020. As such, ODI has not currently identified a safety defect trend for this issue in vehicles outside of the recalled populations. ODI will continue to monitor allegations of pretensioner inadvertent deployment in subject vehicles that are not included in 25V-197. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24015). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration