2016 Ford Expedition

I was fastening my nephew in his carseat to get ready to leave and as I was buckling the croch part the one side was fastened and went to buckle otherwise and was pulling the buckle up to the clips to fasten and the fastened one came out. Does not stay latched while fastening otherwise with just a little pull on otherwise it unhooks. This happened while in home and buckling up to leave.

The contact owns a 2016 Ford Expedition. The contact stated while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle lost motive power. The contact stated that the failure occurred while driving in the mountains and the vehicle was stuck in the middle of the road. The contact stated that after several attempts, the vehicle restarted. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure had occurred several times; however, the vehicle was taken to the dealer and the failure was not duplicated. The manufacturer was made aware of the failure. The failure mileage was unknown.

while driving on the highway my vehicle shut down and service lamp came on and while drifting tried to put transmission in neutral and restart but had to come to complete stop to restart engine in park. I was in third lane and had no warning before shut down and could not get to the shoulder. (almost got hit trying). I reported to the dealer and they said there was no fault codes stored. I was driving to work on a 4 lane street a week later and again it shut down without previous warning again and had to crash up onto the curb to get off street to again restart in park. dealer said again no codes and could not get it to duplicate problem after driving. It happened two more times so i looked into it myself and i read online that the Throttle body is the likely issue. i returned and paid to have the throttle body replaced. they said would not guarantee the issue would be resolved. it has been months and have had no issues since i had it replaced. They charged me $563.31 not including tax. I can not believe that you have to put a vehicle in park when it stalls to begin with but i also can not believe this issue was never recalled since it is a major safety issue and see lots of people and complained of the same issue.

The contact owns a 2016 Ford Expedition. The contact stated that the vehicle was making an abnormal rattling sound on cold starts. The contact stated that the failure recurred while driving from a complete stop and while coming to a stop. The contact also stated that the vehicle was experiencing rough idling. Additionally, the contact stated while driving at approximately 35 MPH, the vehicle inadvertently stalled. The check engine warning light was illuminated. The vehicle was taken to P&B Auto Repair Shop, where it was diagnosed that the cam phasers had failed and needed to be replaced. The vehicle was not repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 128,000.

The contact owns a 2016 Ford Expedition. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The check engine warning light was illuminated. The contact pulled over and restarted the vehicle, but the failure recurred. The vehicle was taken to an independent mechanic, who determined that the throttle body needed to be replaced. The contact replaced the throttle body; however, while driving, the vehicle made an abnormally loud sound. The contact inspected the vehicle and discovered that the throttle body hose clamp had detached. The contact reconnected the hose clamp, but the failure persisted. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 85,605.

The contact owns a 2016 Ford Expedition. The contact stated that on several occasions, while in reverse(R), the contact observed a warning chime and a "Steering Assist Fault" message was displayed, and the steering wheel became firm. The contact stated that on other occasions while driving at various speeds, the steering wheel became stiff. The vehicle was taken to a dealer where it was diagnosed that the steering gear needed to be replaced. The contact related the failure to an unknown recall. The manufacturer was notified of the failure. The failure mileage was approximately 150,000.

While driving on [XXX] at approximately 35 mph the vehicle displayed a wrench warning lamp and at same time vehicle went into limp mode. No power I had to coast to the side of road, engine running but no power. Turned engine off restarted vehicle and drove short distance home. Holiday Ford in Gordon, Texas was contacted they advised bring vehicle in for diagnostic test. Vehicle was driven to Holiday Ford dealership in Gordon, Texas for an appointment 4 days after the occurrence but on the way to dealership it occurred again turned engine off restarted an drove to dealership. Picked vehicle up same day but it occurred again . Took back to dealership, they kept vehicle for 4 days and advised they couldn’t find anything wrong. The vehicle has gone to limp mode 3 times. I was lucky very little traffic it would be very much safety hazard in moderate to heavy traffic. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Ford Expedition. The contact stated that the back-over prevention camera was inoperable. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case and informed the contact that the VIN was not under recall for the failure. The failure mileage was approximately 53,000.

The contact owns a 2016 Ford Expedition. The contact stated while driving approximately 35 MPH, the blower fan stopped functioning. The contact stated that failure was intermittent at first but became a recurring failure while driving at various speeds. There was no warning light illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic to be diagnosed or repaired. The contact researched online and related the failure to NHTSA Campaign Number: 22V648000 (Visibility, Electrical System). The contact had recently checked the wiring harness on the blower fan and became aware that there were burn marks on the wiring harness connector possibly caused by a short circuit. The manufacturer was informed of the failure. The failure mileage was approximately 133,000.

Steering wheel is loose and wobbly as if it will fall off. I noticed that Ford issued a recall in March 2018 for this problem (see below) however it does not include my 2016 Ford Expedition that is having the exact same issue. DEARBORN, Mich., March 14, 2018 – Ford Motor Company is issuing two safety recalls in North America. Details are as follows: Select 2014-18 Ford Fusion and Lincoln MKZ vehicles for loose steering wheel bolts that could lead to a steering wheel detaching from steering column Ford is issuing a safety recall in North America for approximately 1.3 million 2014-18 Ford Fusion and Lincoln MKZ vehicles for potentially loose steering wheel bolts that could result in a steering wheel detaching from the steering column. In affected vehicles, the steering wheel bolt may not maintain torque, allowing the bolt to loosen over time, and if not serviced, a steering wheel could potentially detach and lead to a loss of steering control and increased risk of a crash. Ford is aware of two accidents with one injury allegedly related to this condition. Affected vehicles include: 2014-17 Ford Fusion vehicles built at Flat Rock Assembly Plant, Aug. 6, 2013 to Feb. 29, 2016 2014-18 Ford Fusion vehicles built at Hermosillo Assembly Plant, July 25, 2013 to March 5, 2018 2014-18 Lincoln MKZ vehicles built at Hermosillo Assembly Plant, July 25, 2013 to March 5, 2018 The recall involves approximately 1,378,637 vehicles in North America with 1,301,986 in the United States and federalized territories, 62,479 in Canada and 14,172 in Mexico. The Ford reference number for this recall is 18S08. Dealers will replace the steering wheel bolt on the vehicle with a longer bolt with more robust thread engagement and larger nylon patch placed properly for proper torque retention— at no cost to customers.