NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
890 reportsMileage unknown · Aug 18, 2005
Vehicle Speed ControlFire
DT: THE CONSUMER HAS FORD EXPEDITION 2000. VEHICLE WAS PARKED IN GARAGE AT APPROXIMATELY 10:00 AM ON AUGUST 2, 2005. VEHICLE WAS TURNED OFF AND GARAGE WAS CLOSED, AND AT APPROXIMATELY 1:00 PM, AFTER SMELLING SMOKE THEY DISCOVERED AN INTENSE FIRE UNDER THE HOOD THAT AGGRESSIVELY GREW AND WITHIN A COUPLE OF MINUTES AND CONSUMED T…
Read full complaint
DT: THE CONSUMER HAS FORD EXPEDITION 2000. VEHICLE WAS PARKED IN GARAGE AT APPROXIMATELY 10:00 AM ON AUGUST 2, 2005. VEHICLE WAS TURNED OFF AND GARAGE WAS CLOSED, AND AT APPROXIMATELY 1:00 PM, AFTER SMELLING SMOKE THEY DISCOVERED AN INTENSE FIRE UNDER THE HOOD THAT AGGRESSIVELY GREW AND WITHIN A COUPLE OF MINUTES AND CONSUMED THE ENTIRE GARAGE.HOME AND BUSINESS. THEIR HOME IS OVER 80 PERCENT BURNED, THEY LOST BOTH VEHICLES IN FIRE. THE PEOPLE ESCAPED THE FIRE. *AK *NM
NHTSA ODI #10133345
75,000 miles · Aug 12, 2005
Vehicle Speed ControlFire
DT: TRUCK STARTED SMOKING AND CAUGHT ON FIRE IN PARKING LOT. THE FIRE OCCURED PRIOR TO THE CONSUMER RECEIVING THE RECALL NOTICE FOR THE FAULTY CRUISE CONTROL WHICH CAUSED THE FIRE. THE TRUCK WAS TOTALED. *AK *NM
NHTSA ODI #10120246
32,000 miles · Aug 7, 2005
Structure
WATER HAS LEAKED THROUGH THE WINDSHIELD WIPER AREA CAUSING THE GEM MODULE TO FAIL. THIS CAUSES MANY ELECTRICAL COMPONENTS TO FAIL AS WELL, (I.E. POWER DOOR LOCKS, POWER WINDOWS, ETC..). *NM
NHTSA ODI #10131824
Mileage unknown · Aug 2, 2005
Equipment
2000 FORD EXPEDITION JACK EQUIPMENT CONFORMS TO A SEDAN RATHER THAN A SUV.***NO ANSWER REQUIRED***.*MR WHEN THE JACK WAS FULLY EXTENDED, IT DIDN'T LIFT THE TIRE OFF THE GROUND. THE JACK WAS HIGHLY UNSTABLE AND WHEN VEHICLE DROVE BY, THE VEHICLE ROCKED DANGEROUSLY BECAUSE A WOOD 4 X 4 HAD TO BE USED JUST TO REACH THE POINT WHERE…
Read full complaint
2000 FORD EXPEDITION JACK EQUIPMENT CONFORMS TO A SEDAN RATHER THAN A SUV.***NO ANSWER REQUIRED***.*MR WHEN THE JACK WAS FULLY EXTENDED, IT DIDN'T LIFT THE TIRE OFF THE GROUND. THE JACK WAS HIGHLY UNSTABLE AND WHEN VEHICLE DROVE BY, THE VEHICLE ROCKED DANGEROUSLY BECAUSE A WOOD 4 X 4 HAD TO BE USED JUST TO REACH THE POINT WHERE THE SUV COULD EVEN GET OFF THE GROUND. *JB
NHTSA ODI #10132377
Mileage unknown · Jul 25, 2005
Vehicle Speed ControlFireInjury
2000 FORD EXPEDITION CAUGHT ON FIRE WHILE PARKED IN THE GARAGE.*MR THE VEHICLE WAS PARKED IN THE CONSUMER'S GARAGE FOR ABOUT 3 1/2 HOURS WHEN IT SUDDENLY CAUGHT ON FIRE. THE CONSUMER'S WIFE WAS TREATED FOR SMOKE INHALATION. *NM
NHTSA ODI #10131260
52,000 miles · Jul 25, 2005
SteeringCrashInjury
THE PASSENGER SIDE TIE ROD BROKE AT 65 MPH, CAUSING CONSUMER TO STRIKE A BRIDGE. CONSUMER SUSTAINED INJURIES. *AK THE INSURANCE COMPANY INVESTIGATION FOUND THAT THE FRONT PASSENGER SIDE TIE ROD WAS SEPARATED. FORD SENT OUT LETTERS TO OWNERS OF THESE TYPE VEHICLES TELLING THEM IT IS ESSENTIAL TO HAVE THE STEERING AND FRONT …
Read full complaint
THE PASSENGER SIDE TIE ROD BROKE AT 65 MPH, CAUSING CONSUMER TO STRIKE A BRIDGE. CONSUMER SUSTAINED INJURIES. *AK THE INSURANCE COMPANY INVESTIGATION FOUND THAT THE FRONT PASSENGER SIDE TIE ROD WAS SEPARATED. FORD SENT OUT LETTERS TO OWNERS OF THESE TYPE VEHICLES TELLING THEM IT IS ESSENTIAL TO HAVE THE STEERING AND FRONT SUSPENSION INCLUDING THE TIE RODS INSPECTED EVERY 15,000 MILES. PRIOR TO ACCIDENT BRAKES WERE REPLACED WITH NEW COMPONENTS AND A FULL SAFETY INSPECTION WAS PERFORMED ON THE VEHICLE. *TT
NHTSA ODI #10119336
131,008 miles · Jul 19, 2005
Unknown Or Other
TRAVELING @ 65 MPH ON I-580 IN RICHMOND, CALIFORNIA, MY SPARE TIRE FELL FROM ITS CABLE HELD BRACKET BELOW THE FRAME WHERE IT IS SECURED ON THE VEHICLE, BOUNCED ON THE GROUND, THEN STRUCK THE BOTTOM OF THE REAR BUMPER, WHICH WEDGED THE TIRE BETWEEN THE BUMPER AND GROUND, CAUSING THE REAR OF THE SUV TO CATAPULT OFF THE GROUND. TH…
Read full complaint
TRAVELING @ 65 MPH ON I-580 IN RICHMOND, CALIFORNIA, MY SPARE TIRE FELL FROM ITS CABLE HELD BRACKET BELOW THE FRAME WHERE IT IS SECURED ON THE VEHICLE, BOUNCED ON THE GROUND, THEN STRUCK THE BOTTOM OF THE REAR BUMPER, WHICH WEDGED THE TIRE BETWEEN THE BUMPER AND GROUND, CAUSING THE REAR OF THE SUV TO CATAPULT OFF THE GROUND. THE FORCE AND PRESSURE ON THE TIRE BEING WEDGED BETWEEN THE VEHICLE AND THE GROUND CAUSED THE TIRE TO POP FROM BEHIND THE VEHICLE AND PROCEED ACROSS THREE LANES OF TRAFFIC AT A HIGH SPEED, EVENTUALLY ENDING UP IN THE CENTER DIVIDER OF THE FREEWAY. I WAS ABLE TO MAINTAIN CONTROL, BUT BARELY. THERE IS DAMAGE TO THE UNDERCARRIAGE OF THE TRUCK AT THE REAR BUMPER, PLUS THE STRESS AND DIFFICULTY OF KEEPING THE TRUCK IN A STRAIGHT LINE WHILE TRYING TO COME TO A STOP AFTER THE REAR TIRES WERE LIFTED OFF THE GROUND APPROX. 6-8". THE PRESS FITTTING ON THE CABLE THAT HOLDS THE SPARE TIRE IN PLACE SEPARATED CLEANLY FROM THE CABLE. THE CABLE DID NOT BREAK OR FRAY, JUST THE PRESS- FITTED COUPLING CAME LOOSE AND SEPARATED FROM THE CABLE, ALLOWING THE SPARE TIRE TO FALL TO THE GROUND. THIS SPARE TIRE HAS NEVER BEEN REMOVED FROM THE SPARE POSITION SINCE THE VEHICLE WAS NEW, AND OF COURSE,IS THE ORIGINAL EQUIPMENT SPARE TIRE THAT COMES FROM THE FACTORY, AND THE VEHICLE IS MAINTAINED TO FACTORY SPECS, NO MODIFICATIONS, NO ALTERATIONS, ALL ORIGINAL EQUIPMENT. I SECURED THE PARTS THAT I COULD FIND FROM THE HIGHWAY. I CONTACTED THE LOCAL FORD DEALER, MICHAEL STEAD FORD, OF SAN RAFAEL, ON JULY 13TH AND ORDERED A REPLACEMENT SPARE TIRE WINCH AND CABLE SET FOR THE EXPEDITION. THE PART ARRIVED YESTERDAY AND WAS INSTALLED. I DO HAVE THE OLD WINCH, CABLE, AND CLAMP THAT HOLDS THE SPARE TIRE IN PLACE. CERTAINLY THERE MUST BE A BETTER AND MORE SECURE WAY TO SECURE THE CABLE TO THE FITTING THAT SUPPROTS THE SPARE TIRE UNDER THE CAR THEN THIS SMALL FITTED UNIT THAT IN MY CASE CAME LOOSE.
NHTSA ODI #10129397
Mileage unknown · Jul 18, 2005
Electrical SystemFire
LAST MONTH, MY 2000 FORD EXPEDITION CAUGHT ON FIRE IN MY DRIVEWAY AFTER SITTING FOR ABOUT 3 HOURS. THE ENGINE COMPARTMENT BURST INTO FLAMES AND MELTED EVERY PLASTIC AND RUBBER COMPONENT INSIDE, INCLUDING THE DRIVER-SIDE FRONT TIRE. WITH THE HELP OF THE ROUND ROCK FIRE DEPT., THE FIRE WAS PUT OUT BEFORE IT CONSUMED THE ENTIRE V…
Read full complaint
LAST MONTH, MY 2000 FORD EXPEDITION CAUGHT ON FIRE IN MY DRIVEWAY AFTER SITTING FOR ABOUT 3 HOURS. THE ENGINE COMPARTMENT BURST INTO FLAMES AND MELTED EVERY PLASTIC AND RUBBER COMPONENT INSIDE, INCLUDING THE DRIVER-SIDE FRONT TIRE. WITH THE HELP OF THE ROUND ROCK FIRE DEPT., THE FIRE WAS PUT OUT BEFORE IT CONSUMED THE ENTIRE VEHICLE. A FIRE INVESTIGATION REPORT WAS TAKEN AND CONCLUDED IT STARTED IN THE FUSE BOX AREA DUE TO AN ELECTRICAL SHORT.
NHTSA ODI #10129055
50,000 miles · Jul 11, 2005
Electrical SystemInjury
IN SPRING OF 2004 THE OWNER OF A 2000 FORD EXPEDITION VIN. NO. [XXX]. UPON OPENING THE HOOD OF THE VEHICLE, THE COMPONENTS SURROUNDING THE CRUISE CONTROL COMPONENT AND SEVERAL OTHER COMPONENTS INCLUDING THE ABS MODULE WERE SO HOT THAT THE DRIVER OF THE VEHICLE RECEIVED MINOR BURNS DISCONNECTING THE RUPTURED PART OF THE ABS SYST…
Read full complaint
IN SPRING OF 2004 THE OWNER OF A 2000 FORD EXPEDITION VIN. NO. [XXX]. UPON OPENING THE HOOD OF THE VEHICLE, THE COMPONENTS SURROUNDING THE CRUISE CONTROL COMPONENT AND SEVERAL OTHER COMPONENTS INCLUDING THE ABS MODULE WERE SO HOT THAT THE DRIVER OF THE VEHICLE RECEIVED MINOR BURNS DISCONNECTING THE RUPTURED PART OF THE ABS SYSTEM. THE VEHICLE HAD BEEN IDLE AND TURNED OFF FOR APPROXIMATELY ONE (1) HOUR WHEN THE EVENT OCCURRED. UPON THE VEHICLE BEING STARTED THE NEXT DAY, THE HORN WOULD NOT WORK, THE ABS SYSTEM LIGHT WAS ILLUMINATED AND THE CRUISE CONTROL WOULD NOT ENGAGE. IN APRIL 2004, THE CRUISE CONTROL SWITCH WAS REPLACED. IN LATE MAY, THE CRUISE CONTROL SWITCH WAS STILL INOPERATIVE AFTER REPLACEMENT. ON JUNE 14,2005 THE COMPLAINTS CALLED FORD WITH THE ADDITIONAL INFORMATION THAT THE VEHICLE WAS CONTINUING TO SHORT OUT IN VARIOUS WAYS INCLUDING PLACING THE VEHICLE IN THE DRIVE POSITION AND A NEW PROBLEM OF THE RADIO SYSTEM WOULD MALFUNCTION. WHEN PLACED BACK IN PARK,THE RADIO WAS RE-ACTIVATE. VEHICLE WAS EXAMINED BY PARKER FORD AND THEY ADVISED THE HORN CIRCUIT HAD BEEN OVERLOADED AND A FUSE BLOWN IN THE HORN MODULE. THEY ALSO ADVISED THE ABS MODULE AND PUMP WERE IN NEED OF REPLACEMENT. THE COMPLAINANT BELIEVES THIS VEHICLE REPRESENTS A CONTINUING FIRE HAZARD AND THAT THE DAMAGED COMPONENT FAILURES, ALL OF WHICH OCCURRED AT THE SAME TIME WERE DIRECTLY RELATED TO THE DEFECTIVE CRUISE CONTROL SWITCH. COMPLAINANT BELIEVES THAT ADDITIONAL VEHICLES MAY BE AT RISK DUE TO SIMILAR OVERLOADS ON THE ELECTRICAL SYSTEMS. VEHICLE HAS NEVER BEEN WRECKED, SUBMERGED IN WATER OR ALTERED IN ANYWAY FROM THE ORIGINAL FACTORY DESIGN.COMPLAINANT HAS 24 YEARS PRIOR LAW ENFORCEMENT EXPERIENCE. VEHICLE HISTORY IS ALSO WELL KNOWN TO CURRENT KENTUCKY STATE TROOPER. REQUEST NHTSA IN DEPTH REVIEW OF POTENTIAL FOR CONTINUING PROBLEMS AND COLLATERAL FAILURES OF OTHER COMPONENTS ASSOCIATED WITH SPEED CONTROL SWITCH. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10128329
Mileage unknown · Jul 11, 2005
Steering
DT: CONSUMER STATES THAT WHEN DRIVING 45-50 MPH AND THE TIE ROD BROKE ON THE DRIVER SIDE FRONT. WHEN THE CONSUMER SPOKE TO FORD, THEY STATED IT HAPPENS QUITE OFTEN WITH THAT VEHICLE. THE VEHICLE WAS INSPECTED AT FORD 7 MONTHS AGO. THE VEHICLE WAS TOWED TO A GARAGE. THERE WAS NO WARNING, IT JUST HAPPENED. THIS HAPPENED JULY…
Read full complaint
DT: CONSUMER STATES THAT WHEN DRIVING 45-50 MPH AND THE TIE ROD BROKE ON THE DRIVER SIDE FRONT. WHEN THE CONSUMER SPOKE TO FORD, THEY STATED IT HAPPENS QUITE OFTEN WITH THAT VEHICLE. THE VEHICLE WAS INSPECTED AT FORD 7 MONTHS AGO. THE VEHICLE WAS TOWED TO A GARAGE. THERE WAS NO WARNING, IT JUST HAPPENED. THIS HAPPENED JULY 9, 2005 AT 5:30 PM. THE VEHICLE NEEDS TO BE REALIGNED AND THE OTHER TIE ROD NEED TO BE CHECKED. THE VEHICLE WAS UNSTEERABLE AND IT PULLED ABOUT 3 FEET TO THE RIGHT. AT THAT TIME, THE CONSUMER STOPPED THE VEHICLE. *NM
NHTSA ODI #10128307
Official recalls
7Sep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A FIRE AT THE SWITCH COULD OCCUR.
Remedy: BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
Jan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
Remedy: AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
Mar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
Consequence & remedy
Consequence: THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
Remedy: DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Sep 9, 2002
CERTAIN 4X2 SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE REAR TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR 4.2 VEHICLES.
Consequence & remedy
Consequence: CUSTOMERS MAY INFLATE THEIR REAR TIRES BASED ON THE INCORRECT TIRE PRESSURE INFORMATION ON THE CERTIFICATION LABEL.
Remedy: A SUPPLEMENTARY LABEL WILL BE SENT TO CUSTOMERS TO PLACE NEAR THE CERTIFICATION LABEL TO IDENTIFY THE APPROPRIATE REAR TIRE PRESSURE. THE CUSTOMER MAY ALSO HAVE THE DEALER INSTALL THE LABEL ON THE VEHICLE, IF THEY SO DESIRE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING SEPTEMBER OR OCTOBER 2002. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Nov 28, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." THE AFFECTED EXPEDITION/NAVIGATOR OWNER GUIDES DO NOT IDENTIFY THE LOCATIONS OF SEATING POSITIONS EQUIPPED WITH TETHER ANCHORAGES, AND DO NOT PROVIDE INSTRUCTIONS FOR SECURING CHILD SEATS TO THESE TETHER ANCHORAGES. THE F150 SC OWNER GUIDES DO NOT PROVIDE THE PROCEDURE FOR SECURING CHILD SEATS TO THE TETHER ANCHORAGES. THE TAURUS/SABLE OWNER GUIDES DO NOT IDENTIFY THE CENTER REAR SEATING POSITION AS HAVING LATCH COMPATIBLE LOWER ANCHORAGES.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH OWNER GUIDE INSERTS REVISED TO PROVIDE THE REQUIRED INFORMATION, AND INSTRUCTIONS FOR AFFIXING THESE INSERTS TO THEIR OWNER GUIDES. CUSTOMERS WILL ALSO BE ADVISED THAT IF THEY PREFER, THEIR DEALER WILL AFFIX THE INSERTS TO THEIR OWNER GUIDES.
Mar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES. THE TRAILER HITCH ASSEMBLY TO THE FRAME ATTACHING BOLTS COULD LOSE THE CLAMP LOAD.
Consequence & remedy
Consequence: THE TRAILER HITCH COULD THEN SEPARATE FROM THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TRAILER HITCH MOUNTING BOLTS AND NUT PLATES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05015 · Windshield Leak Causes Electric Failures
Opened Oct 13, 2005 · Closed Dec 6, 2006
Status: closed (inferred from source dates) · Electrical System; Exterior Lighting; Visibility:windshield Wiper/washer
CONSUMERS ALLEGED THAT WHEN IT RAINED OR SNOWED, WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD.MOISTURE FLOWING THROUGH THE SEAL THAT SURROUNDS THE FRONT WINDSHIELD FOLLOWS A PATH THROUGH THE SEAL INTO THE GENERIC ELECTRONIC MODULE (GEM) AND FUSE BOX, AND MAY CAUSE THE ELECTRICAL COMPONENTS IN THE VEHICLE TO MALFUNCTION.OVERALL, THE NUMBER OF REPORTS ALLEGING WIPER FAILURES AND LIGHTING FAILURES IS RELATIVELY SMALL.IN REVIEWING A LARGE SAMPLE OF THE 1503 COMPLAINTS FOR WINDSHIELD LEAKS, ODI'S ANALYSIS REVEALS THAT 0.04% OF THE TOTAL VEHICLE POPULATION REPORTED IMPROPER WINDSHIELD WIPER OPERATION AND 0.01% OF THE TOTAL VEHICLE POPULATIONREPORTED LIGHTING FAILURES.THE WARRANTY CLAIMS REVEAL THAT APPROXIMATELY 0.10% OF THE POPULATION HAS BEEN SERVICED FOR WIPER MALFUNCTIONS AND 0.08% FOR LIGHTING MALFUNCTIONS AS A RESULT OF WINDSHIELD LEAKING. ODI'S ANALYSIS OF THE FIELD PERFORMANCE STATISTICS AND AVAILABLE TECHNICAL INFORMATION HAS NOT ESTABLISHED THAT A DEFECT TREND EXISTS IN THE MALFUNCTION, FAILURE OR INTERMITTENT OPERATION OF THE FRONT WINDSHIELD WIPERS OR HEADLIGHTS.SEE THE ATTACHED SUMMARY REPORT.
Additional source detail variants (3)
Electrical System
CONSUMERS ALLEGED THAT WHEN IT RAINED OR SNOWED, WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD.MOISTURE FLOWING THROUGH THE SEAL THAT SURROUNDS THE FRONT WINDSHIELD FOLLOWS A PATH THROUGH THE SEAL INTO THE GENERIC ELECTRONIC MODULE (GEM) AND FUSE BOX, AND MAY CAUSE THE ELECTRICAL COMPONENTS IN THE VEHICLE TO MALFUNCTION.OVERALL, THE NUMBER OF REPORTS ALLEGING WIPER FAILURES AND LIGHTING FAILURES IS RELATIVELY SMALL.IN REVIEWING A LARGE SAMPLE OF THE 1503 COMPLAINTS FOR WINDSHIELD LEAKS, ODI'S ANALYSIS REVEALS THAT 0.04% OF THE TOTAL VEHICLE POPULATION REPORTED IMPROPER WINDSHIELD WIPER OPERATION AND 0.01% OF THE TOTAL VEHICLE POPULATIONREPORTED LIGHTING FAILURES.THE WARRANTY CLAIMS REVEAL THAT APPROXIMATELY 0.10% OF THE POPULATION HAS BEEN SERVICED FOR WIPER MALFUNCTIONS AND 0.08% FOR LIGHTING MALFUNCTIONS AS A RESULT OF WINDSHIELD LEAKING. ODI'S ANALYSIS OF THE FIELD PERFORMANCE STATISTICS AND AVAILABLE TECHNICAL INFORMATION HAS NOT ESTABLISHED THAT A DEFECT TREND EXISTS IN THE MALFUNCTION, FAILURE OR INTERMITTENT OPERATION OF THE FRONT WINDSHIELD WIPERS OR HEADLIGHTS.SEE THE ATTACHED SUMMARY REPORT.
Exterior Lighting
CONSUMERS ALLEGED THAT WHEN IT RAINED OR SNOWED, WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD.MOISTURE FLOWING THROUGH THE SEAL THAT SURROUNDS THE FRONT WINDSHIELD FOLLOWS A PATH THROUGH THE SEAL INTO THE GENERIC ELECTRONIC MODULE (GEM) AND FUSE BOX, AND MAY CAUSE THE ELECTRICAL COMPONENTS IN THE VEHICLE TO MALFUNCTION.OVERALL, THE NUMBER OF REPORTS ALLEGING WIPER FAILURES AND LIGHTING FAILURES IS RELATIVELY SMALL.IN REVIEWING A LARGE SAMPLE OF THE 1503 COMPLAINTS FOR WINDSHIELD LEAKS, ODI'S ANALYSIS REVEALS THAT 0.04% OF THE TOTAL VEHICLE POPULATION REPORTED IMPROPER WINDSHIELD WIPER OPERATION AND 0.01% OF THE TOTAL VEHICLE POPULATIONREPORTED LIGHTING FAILURES.THE WARRANTY CLAIMS REVEAL THAT APPROXIMATELY 0.10% OF THE POPULATION HAS BEEN SERVICED FOR WIPER MALFUNCTIONS AND 0.08% FOR LIGHTING MALFUNCTIONS AS A RESULT OF WINDSHIELD LEAKING. ODI'S ANALYSIS OF THE FIELD PERFORMANCE STATISTICS AND AVAILABLE TECHNICAL INFORMATION HAS NOT ESTABLISHED THAT A DEFECT TREND EXISTS IN THE MALFUNCTION, FAILURE OR INTERMITTENT OPERATION OF THE FRONT WINDSHIELD WIPERS OR HEADLIGHTS.SEE THE ATTACHED SUMMARY REPORT.
Visibility:windshield Wiper/washer
CONSUMERS ALLEGED THAT WHEN IT RAINED OR SNOWED, WATER LEAKED INTO THE VEHICLE AROUND THE WINDSHIELD.MOISTURE FLOWING THROUGH THE SEAL THAT SURROUNDS THE FRONT WINDSHIELD FOLLOWS A PATH THROUGH THE SEAL INTO THE GENERIC ELECTRONIC MODULE (GEM) AND FUSE BOX, AND MAY CAUSE THE ELECTRICAL COMPONENTS IN THE VEHICLE TO MALFUNCTION.OVERALL, THE NUMBER OF REPORTS ALLEGING WIPER FAILURES AND LIGHTING FAILURES IS RELATIVELY SMALL.IN REVIEWING A LARGE SAMPLE OF THE 1503 COMPLAINTS FOR WINDSHIELD LEAKS, ODI'S ANALYSIS REVEALS THAT 0.04% OF THE TOTAL VEHICLE POPULATION REPORTED IMPROPER WINDSHIELD WIPER OPERATION AND 0.01% OF THE TOTAL VEHICLE POPULATIONREPORTED LIGHTING FAILURES.THE WARRANTY CLAIMS REVEAL THAT APPROXIMATELY 0.10% OF THE POPULATION HAS BEEN SERVICED FOR WIPER MALFUNCTIONS AND 0.08% FOR LIGHTING MALFUNCTIONS AS A RESULT OF WINDSHIELD LEAKING. ODI'S ANALYSIS OF THE FIELD PERFORMANCE STATISTICS AND AVAILABLE TECHNICAL INFORMATION HAS NOT ESTABLISHED THAT A DEFECT TREND EXISTS IN THE MALFUNCTION, FAILURE OR INTERMITTENT OPERATION OF THE FRONT WINDSHIELD WIPERS OR HEADLIGHTS.SEE THE ATTACHED SUMMARY REPORT.
DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
PE05033 · Electrical System Failure
Opened Jun 15, 2005 · Closed Oct 13, 2005
Status: closed (inferred from source dates) · Electrical System; Equipment:electrical; Visibility:windshield
ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, EA05015, TO ALLOW FURTHER INVESTIGATION OF THE ISSUE AND TO ASSESS THE NATURE OF THE POTENTIAL SAFETY CONSEQUENCE.
Additional source detail variants (3)
Electrical System
ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, EA05015, TO ALLOW FURTHER INVESTIGATION OF THE ISSUE AND TO ASSESS THE NATURE OF THE POTENTIAL SAFETY CONSEQUENCE.
Equipment:electrical
ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, EA05015, TO ALLOW FURTHER INVESTIGATION OF THE ISSUE AND TO ASSESS THE NATURE OF THE POTENTIAL SAFETY CONSEQUENCE.
Visibility:windshield
ODI HAS RECEIVED 39 REPORTS ALLEGING THAT WATER LEAKS AROUND THE WINDSHIELD CAUSING ELECTRICAL FAILURES, INCLUDING BUT NOT LIMITED TO THE WINDSHIELD WIPERS AND THE HEADLAMPS.FORD REPORTS THAT WATER ENTERING THE VEHICLE CAN WET THE POWER DISTRIBUTION BOX (PDB) AND THE GENERIC ELECTRONIC MODULE (GEM).THESE COMPONENTS CONTROL VARIOUS ELECTRICAL SYSTEMS IN THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS, EA05015, TO ALLOW FURTHER INVESTIGATION OF THE ISSUE AND TO ASSESS THE NATURE OF THE POTENTIAL SAFETY CONSEQUENCE.
PE04078 · Speed Control Deactivation Switch Fire
Opened Nov 19, 2004 · Closed Mar 22, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control:cruise Control
IN ITS LETTER DATED JANUARY 27, 2005 TO ODI, FORD INDICATED THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL # 05V-017) TO REMEDY AN OVERHEATING SPEED CONTROL DEACTIVATION SWITCH IN APPROXIMATELY 738,490 SUBJECT VEHICLES.THE VEHICLES AFFECTED BY THE RECALL ARE CERTAIN 2000 MODEL YEAR (MY) FORD F150, FORD EXPEDITION AND LINCOLN NAVIGATOR EQUIPPED WITH SPEED CONTROL AND CERTAIN 2001 MODEL YEAR F150 SUPERCREW VEHICLES BUILT THROUGH AUGUST 7, 2000.SINCE OPENING PE04-078, ODI HAS IDENTIFIED OTHER REPORTS OF KEY OFF ENGINE COMPARTMENT FIRES IN FORD VEHICLES WITH SIMILAR SPEED CONTROL DEACTIVATION SWITCHES THAT WERE NOT THE SUBJECT OF THIS PRELIMINARY EVALUATION OR FORD'S RECALL 05V-017.FORD'S RESPONSE TO THE ODI INFORMATION REQUEST LETTER DATED DECEMBER 3, 2004, PROVIDED AN ADDITIONAL 107 ALLEGATIONS OF KEY OFF ENGINE COMPARTMENT FIRES THAT WERE ALSO IN VEHICLES NOT SUBJECT TO THIS INVESTIGATION OR INCLUDED IN THE FORD RECALL 05V-017.AN ENGINEERING ANALYSIS (EA) IS WARRANTED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS RELATING TO KEY OFF ENGINE COMPARTMENT FIRES IN VEHICLES OUTSIDE THE SCOPE OF THIS PRELIMINARY EVALUATION.ODI WILL EXPAND THE SCOPE OF IT'S INVESTIGATION AT THE EA PHASE TO INCLUDE THE 1995 THROUGH 2002 MODEL YEARS OF THE FORD F150, FORD EXPEDITION AND LINCOLN NAVIGATOR VEHICLES.
SQ00016 · Wheel Stud And Nut
Opened Sep 15, 2000 · Closed Dec 6, 2001
Status: closed (inferred from source dates) · Wheels
IN DECEMBER 1999, FORD ISSUED TECHNICAL SERVICE BULLETIN 99-26-3, ENTITLED INCREASED WHEEL NUT AND STUD SIZE-SERVICE TIP,FOR 2000 MODEL YEAR EXPEDITION, NAVIGATOR, AND CERTAIN F-150 VEHICLES, BUILT ON OR AFTER NOVEMBER 27, 1999.THESE VEHICLES HAVE INCREASED WHEEL STUD AND NUT DIAMETERS FROM 12MM TO 14MM.THE WHEEL NUT TORQUE WAS INCREASED FROM 100 FT-LB. TO 150 FT-LB., RESPECTIVELY.ODI HAS RECEIVED THREE REPORTS OF WHEELS SEPARATING FROM 2000 MODEL YEAR EXPEDITION VEHICLES, INCLUDING TWO CRASHES.TWO ADDITIONAL REPORTS ALLEGE BROKEN STUDS AND/OR LOOSE WHEEL NUTS.LOOSE WHEEL NUTS CAN ALLOW THE WHEEL TO WOBBLE AND CAUSE WHEEL STUD BREAKAGE.THERE ARE NO SIMILAR ODI REPORTS ON 2000 MODEL YEAR LINCOLN NAVIGATOR VEHICLES.THE FAILURES APPEAR TO BE ATTRIBUTED TO IMPROPER WHEEL NUT TORQUE; HOWEVER, THERE IS NO EVIDENCE THAT THERE ARE TORQUE QUALITY DEFICIENCIES AT THE ASSEMBLY PLANTS.DUE TO THE MILEAGES THE INCIDENTS OCCURRED, IT IS MOST LIKELY THAT IMPROPER WHEEL NUT TORQUES WERE APPLIED DURING SERVICING, BECAUSE IN ALL CASES WHEN LOOSE WHEELS WERE RE-TORQUED TO A LEAST 100 FT-LB., THERE WERE NO FAILURE RE-OCCURRENCES.
Illustration