IllustrationCAR WAS SITTING, ENGINE RUNNING, IN PARK FOR 10 MINUTES AND THEN SUDDENLY WITH NO ONE INSIDE, MOVED FORWARD AND CRASHED INTO THE WINDOW OF A BUSINESS. THERE WAS A WITNESS THERE.
2004 Ford Excursion
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Ford Excursion do not stand out strongly from the model-year median of 80.
About this comparison →How this year compares
Owner complaints by model year
Compare all Excursion years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
210–25K
425–50K
850–75K
1975–100K
15100–150K
11150K+
78 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports3 fire reports2 injury reports
Power Train complaints
7 reportsWE PURCHASED 2004 FORD EXCURSION WITH THE 6.0L DIESEL ENGINE NEW IN FEBRUARY 2004. IT HAS BEEN TO THE DEALER NOW 2 TIMES FOR THE BACK UP SENSOR, APPROXIMATELY 5 TIMES FOR THE TURBO, UNABLE TO COUNT THE NUMBER OF TIMES FOR THE LACK OF POWER, THE VENT WINDOWS NOT WORKING, 3 TIMES FOR THE MOTOR ON THE POWER DRIVERS SEAT, BALL JOINT…
Read full complaint
WE PURCHASED 2004 FORD EXCURSION WITH THE 6.0L DIESEL ENGINE NEW IN FEBRUARY 2004. IT HAS BEEN TO THE DEALER NOW 2 TIMES FOR THE BACK UP SENSOR, APPROXIMATELY 5 TIMES FOR THE TURBO, UNABLE TO COUNT THE NUMBER OF TIMES FOR THE LACK OF POWER, THE VENT WINDOWS NOT WORKING, 3 TIMES FOR THE MOTOR ON THE POWER DRIVERS SEAT, BALL JOINTS 1 TIME, AND NOW OTHER FRONT END PARTS. THIS VEHICLE IS PRIMARILY USED TO GO TO CHURCH AND TRAVEL WITH THE ENTIRE FAMILY ON THE WEEKENDS FOR DAY TRIPS. WE HAVE HAD IT TO GRAHAM FORD SEVERAL TIMES, GERMAIN FORD SEVERAL TIMES, (BOTH ARE IN COLUMBUS, OHIO) AND THE LAST PLACE WE HAVE IT IS DONLEY FORD IN MOUNT VERNON, OHIO. WE CAN GET A FULL HISTORY OF ALL REPAIRS ON THIS VEHICLE IF NEEDED. THERE HAVE BEEN SO MANY THINGS GONE WRONG WITH THE TRUCK THAT IT IS DIFFICULT TO KEEP TRACK. THE SERVICE ADVISOR IS NOW TELLING MY WIFE TO "JUST TRADE IT IN". WE JUST WANT ALL OF THE PROBLEMS FIXED CORRECTLY AND FIND THE CAUSE OF THE ELECTRICAL FAILURES/ISSUES/PROBLEMS INSTEAD OF JUST FIXING WHAT BREAKS AND NOT FIXING THE CAUSE. WE PAID 50,000 BUCKS FOR THIS VEHICLE AND HAVE HAD NOTHING BUT PROBLEMS. THE START WAS WHEN WE WANTED TO GO TO MAINE AND COULD NOT TAKE IT BUT HAD TO TAKE OUR OLDER CONVERSION VAN. *TR
I OWN A 2004 FORD EXCURSION WHICH HAS ON TWO OCCASIONS FAILED TO START AND WAS TOWED TO FAIRVIEW FORD. THE FIRST OCCURRENCE THE DEALER REPLACED THE CAMSHAFT SENSOR AND REFLASHED THE COMPUTER. THE SECOND INCIDENT THE CAR WAS ALSO TOWED BY ROADSIDE ASSISTANCE FROM MY DRIVEWAY. THE TOW TRUCK DRIVER WAS ALSO UNABLE TO START THE …
Read full complaint
I OWN A 2004 FORD EXCURSION WHICH HAS ON TWO OCCASIONS FAILED TO START AND WAS TOWED TO FAIRVIEW FORD. THE FIRST OCCURRENCE THE DEALER REPLACED THE CAMSHAFT SENSOR AND REFLASHED THE COMPUTER. THE SECOND INCIDENT THE CAR WAS ALSO TOWED BY ROADSIDE ASSISTANCE FROM MY DRIVEWAY. THE TOW TRUCK DRIVER WAS ALSO UNABLE TO START THE VEHICLE. I WAS CONTACTED LATER IN THE DAY BY MY SERVICE ADVISOR SAYING THAT THE VEHICLE STARTED FINE AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. ON A THIRD OCCURRENCE THE VEHICLE STALLED IN A PARKING LOT AND WOULD NOT RESTART FOR MY WIFE. AFTER SHOPPING FOR APPROXIMATELY 45 MINUTES MY WIFE RETURNED AND WAS ABLE START THE VEHICLE AND IT WAS DRIVEN STRAIT TO THE DEALER. THE DEALER WAS AGAIN UNABLE TO DUPLICATE THE PROBLEM. I HAVE ALSO GIVEN FAIRVIEW FORD SIX ATTEMPTS TO FIX MISALIGNED DOORS THAT ARE VISIBLY MISALIGNED AND CAUSE THE DOOR TO HAVE TO BE SLAMMED TO CLOSE THEM. THE DOORS WERE MISALIGNED WHEN PURCHASED AND THE DEALER IS UNABLE TO FIX THEM. AT ONE POINT AFTER THE DEALER TRIED TO ALIGN THE FRONT DRIVERS SIDE DOOR I COULD STICK MY FINGERS IN BETWEEN THE DOOR AND THE BODY ALL THE WAY TO THE OUTSIDE WITH THE DOOR CLOSED. THE VEHICLE HAS BEEN IN THE SHOP A TOTAL OF 35 DAYS AND NOW HAS 16K MILES. MY WIFE IS AFRAID TO DRIVE THE VEHICLE WITH MY THREE YOUNG CHILDREN FOR FEAR OF STALLING AND CAUSING AN ACCIDENT. *NM
VEHICLE HAS HAD A VIBRATION SINCE IT WAS NEW. HAVE PUT 4 DIFFERENT SETS OF TIRES AND 2 DIFFERENT SETS OF WHEELS AND VIBRATION STILL EXISTS. FORD HAS TRIED TO NARROW DOWN WHERE VIBRATION IS COMING FROM, BUT THE DEALERSHIP IS AT A LOSS. KEEP POINTING THEIR FINGER AT THE TIRES, HOWEVER THE DEALERSHIP BALANCED THE TIRES THEMSELVES A…
Read full complaint
VEHICLE HAS HAD A VIBRATION SINCE IT WAS NEW. HAVE PUT 4 DIFFERENT SETS OF TIRES AND 2 DIFFERENT SETS OF WHEELS AND VIBRATION STILL EXISTS. FORD HAS TRIED TO NARROW DOWN WHERE VIBRATION IS COMING FROM, BUT THE DEALERSHIP IS AT A LOSS. KEEP POINTING THEIR FINGER AT THE TIRES, HOWEVER THE DEALERSHIP BALANCED THE TIRES THEMSELVES AND AGREED THAT THE VIBRATION STILL EXISTS.
DT: VEHICLE WAS INVOLVED N AN ACCIDENT DUE TO BRAKE FAILURE. THE ABS WENT OUT. WHEN OPENED THE HOOD FOR INVESTIGATION THE MASTER CYCLINDER SEPARTED FROM THE BRAKE BOOSTER CYLINDER. NO LOCK ON BOLT AND THE NUT SHEARED ITSELF OFF. CALLED FORD AND LEFT MESSAGE. HAD TO PUT NEW TRANSMISSION AT 16,000 MILES AS WELL. HAD 2 MECHA…
Read full complaint
DT: VEHICLE WAS INVOLVED N AN ACCIDENT DUE TO BRAKE FAILURE. THE ABS WENT OUT. WHEN OPENED THE HOOD FOR INVESTIGATION THE MASTER CYCLINDER SEPARTED FROM THE BRAKE BOOSTER CYLINDER. NO LOCK ON BOLT AND THE NUT SHEARED ITSELF OFF. CALLED FORD AND LEFT MESSAGE. HAD TO PUT NEW TRANSMISSION AT 16,000 MILES AS WELL. HAD 2 MECHANICS LOOK AT THIS AND SUGGESTED FORD SHOULD TAKE NOTICE. *AK *TT
I HAVE A 2004 FORD EXCURSION WITH 9000 MILES ON IT PRESENTLY AND HAVE HAD NUMEROUS INCIDENTS WITH THE VEHICLE LOSING POWER AND GETTING STUCK IN THE MIDDE OF THE ROAD AND HIGHWAY. THIS PROBLEM FIRST OCCURED IN DECEMBER 2004 WITH 5000 MILES ON IT . SINCE THEN IT HAS BEEN BACK TO THE DEALERSHIP NUMEROUS TIMES FOR THE SAME PROBLEM A…
Read full complaint
I HAVE A 2004 FORD EXCURSION WITH 9000 MILES ON IT PRESENTLY AND HAVE HAD NUMEROUS INCIDENTS WITH THE VEHICLE LOSING POWER AND GETTING STUCK IN THE MIDDE OF THE ROAD AND HIGHWAY. THIS PROBLEM FIRST OCCURED IN DECEMBER 2004 WITH 5000 MILES ON IT . SINCE THEN IT HAS BEEN BACK TO THE DEALERSHIP NUMEROUS TIMES FOR THE SAME PROBLEM AND I HAVE BEEN TOLD THEY CAN NOT FIND THE PROBLEM. THE PROBLEM DID OCCUR WHEN THEY DROVE THE TRUCK . THEY PUT A EGR VALVE AND REPROGRAMMED THE COMPUTER, SINCE THEN THEY ARE STUMPED AND SAID THEY CANT FIND THE PROBLEM. IT WAS JUST AT THE DEALERSHIP FOR A MONTH , IT ALSO HAD A RECALL TO OVERHAUL THE TRANSMISSION , SINCE I GOT THE TRUCK BACK THE LOSS OF POWER HAS OCCURRED TO MY WIFE AND KIDS . I FEEL THIS VEHICLE IS VERY UNSAFE AND SHOULD NOT BE ON THE ROAD FOR MY FAMILIES SAFETY AS WELL AS OTHERS. I SINCE SPOKE WITH FORD CUSTOMERS RELATIONS AND THEY TOLD ME THEY COULD NOT DO ANYTHING BECAUSE THE DEALERSHIP CAN NOT FIND THE PROBLEM. THIS TRUCK IS NOT EVEN 1 YEAR OLD YET , TO THE DATE IT WAS MANUFACTURED. *AK
WHILE DRIVING,THE AUTOMATIC 4 WHEEL DRIVE ENGAGED WITHOUT WARNING. THE 4 WHEEL DRIVE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. THE DRIVER DROVE TO THE DEALER. THE MECHANIC INFORMED THE DRIVER THAT THE PROBLEM CAN NOT BE DUPLICATE. THE DRIVER INFORMED THE MECHANIC THIS PROBLEM HAS HAPPEN BEFORE AND HAS NOT BEEN RESOLVED.…
Read full complaint
WHILE DRIVING,THE AUTOMATIC 4 WHEEL DRIVE ENGAGED WITHOUT WARNING. THE 4 WHEEL DRIVE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. THE DRIVER DROVE TO THE DEALER. THE MECHANIC INFORMED THE DRIVER THAT THE PROBLEM CAN NOT BE DUPLICATE. THE DRIVER INFORMED THE MECHANIC THIS PROBLEM HAS HAPPEN BEFORE AND HAS NOT BEEN RESOLVED. PLEASE FILL FURTHER DETAILS. *JB
Official recalls
211V352000 · Exterior Lighting:brake Lights; Exterior Lighting:tail Lights
Jul 13, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence & remedy
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Additional source detail variants (2)
Exterior Lighting:brake Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Exterior Lighting:tail Lights
FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.
Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
05V270000 · Electrical System:wiring
Jun 10, 2005
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA05003 · Engine Stalling
Opened Feb 15, 2005 · Closed Nov 2, 2005
Status: closed (inferred from source dates) · Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine:diesel
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System:wiring:front Underhood
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
Engine And Engine Cooling:engine:diesel
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
Engine And Engine Cooling
IN A JUNE 7, 2005 LETTER, FORD NOTIFIED ODI THAT IT WOULD BE CONDUCTING A SAFETY RECALL OF APPROXIMATELY 180,000 FORD F-SUPER DUTY, EXCURSION AND E-SERIES VEHICLES EQUIPPED WITH 6.0L DIESEL ENGINES TO CORRECT TWO WIRING RELATED CONDITIONS THAT COULD RESULT IN ENGINE STALL (NHTSA RECALL NO. 05V-270, FORD NO. 05S34).THE AFFECTED VEHICLES WERE BUILT BETWEEN SEPTEMBER 29, 2003 AND MAY 31, 2004.ACCORDING TO FORD, VEHICLES WITH THE CONDITIONS MAY STALL WITHOUT WARNING AND MAY OR MAY NOT RESTART.FORD WILL INSTRUCT OWNERS OF VEHICLES INCLUDED IN THE RECALL TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE FUEL INJECTOR CONTROL MODULE WIRE HARNESS UPGRADED OR REPLACED AND OR HAVE A NEW INJECTION CONTROL PRESSURE SENSOR CONNECTOR INSTALLED.DURING A MAY 2005 PRESENTATION TO ODI, FORD IDENTIFIED A NUMBER OF POTENTIAL FAILURE MECHANISMS THAT COULD AFFECT ENGINE PERFORMANCE IN VARIOUS SEGMENTS OF THE SUBJECT VEHICLE POPULATION, INCLUDING THE WIRING CONDITIONS ADDRESSED BY 05V-270.THE WIRING CONDITIONS, WHICH BOTH AFFECT ENGINE FUELING, WERE THE MOST LIKELY CONDITIONS TO RESULT IN ENGINE STALL.THE RECALLED VEHICLES COMPRISE APPROXIMATELY 43% OF THE SUBJECT VEHICLE POPULATION AND ACCOUNT FOR 75 OF THE 113 ODI REPORTS THAT HAVE A VALID VIN (66%).THE VOQ COMPLAINT RATE FOR THE RECALL POPULATION IS 45/100K WHILE THE RATE FOR VEHICLES OUTSIDE THE RECALL POPULATION IS 17/100K AND THEIR TREND (BY DATE OF RECEIPT) IS DECLINING.BASED ON THE ANALYSIS, ODI BELIEVES FORD?S ACTIONS ARE SUFFICIENT TO ADDRESS THE CURRENT SAFETY RISKS AND THE INVESTIGATION IS THUS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY RELATED DEFECT DOES NOT EXIST.FURTHER ACTION WILL BE TAKEN IF WARRANTED BY FUTURE CIRCUMSTANCES.
PE04070 · Engine Stalling
Opened Oct 7, 2004 · Closed Feb 15, 2005
Status: closed (inferred from source dates) · Engine And Engine Cooling:engine:diesel
TWENTY FIVE OF THE ODI FAILURE REPORTS ARE DUPLICATIVE OF FORD COMPLAINTS.TWENTY ODI REPORTS DO NOT CONTAIN A VIN (AND MAY OR MAY NOT BE DUPLICATIVE OF FORD REPORTS).THE 14 ALLEGED CRASHES AND 2 ALLEGED INJURIES WERE ALL MINOR.SUBMITTED DURING PRELIMINARY EVALUATION (PE) 04-070, FORD'S RESPONSE TO ODI'S INFORMATION REQUEST (IR) LETTER CONTAINED ABOUT 5,000 CONSUMER REPORTS (MORS) AND 8,700 FIELD REPORTS (CQIS).FORD REVIEWED THE COMPLAINTS AND CATEGORIZED THEM.THE MANUFACTURER REPORTS SHOWN ABOVE REPRESENT A COUNT OF UNIQUE VEHICLES THAT FORD CATEGORIZED AS ALLEGEDLY STALLING DUE TO A SUBJECT ENGINE COMPONENT ('A' CATEGORY, SEE FORD'S IR RESPONSE LETTER FOR FURTHER DETAIL); SOME OF THESE VEHICLES RECEIVED MULTIPLE REPORTS.ODI HAS NOT YET CONFIRMED FORD'S CATEGORIZATION OF THESE REPORTS, NOR HAS ODI CONFIRMED FORD'S CATEGORIZATION OF THE REMAINING REPORTS (WHICH FORD STATES DO NOT PERTAIN TO THE ALLEGED DEFECT).FORD SUBMITTED NEARLY 19,000 WARRANTY CLAIMS, MANY OF WHICH INVOLVED CLAIMS FOR A TECHNICAL SERVICE BULLETIN (TSB 04-13-08) AND FIELD SERVICE ACTION (FSA 03B05) WHICH FORD IDENTIFIED AS POTENTIAL REMEDIES FOR STALLING COMPLAINTS.ODI HAS NOT CONFIRMED THAT EITHER OF THESE ARE A REMEDY FOR ENGINE STALLING COMPLAINTS.SEVERAL OTHER DEALER COMMUNICATIONS RELATED TO ENGINE STALL WERE ALSO SUBMITTED AS WELL AS OVER 50 PRODUCT MODIFICATIONS, 15 OF WHICH INVOLVE REVISIONS TO THE SOFTWARE FOR THE ELECTRONIC ENGINE CONTROL UNIT.FURTHER INVESTIGATION IS REQUIRED AND ODI IS UPGRADING PE04-070 TO AN ENGINEERING ANALYSIS (EA).DURING THE EA, ODI WILL ESTABLISH AND UPDATE MANUFACTURER FAILURE REPORT COUNTS, FURTHER INVESTIGATE THE FREQUENCY AND TREND OF STALLING COMPLAINTS, AND DETERMINE THE SCOPE AND SAFETY IMPLICATION OF STALLING EVENTS.ODI WILL ALSO INVESTIGATE FORD'S REMEDIES, THEIR EFFECTIVENESS, AND WHETHER FURTHER ACTION IS REQUIRED.