2023 Ford Escape

I am reporting a recurring safety issue involving sudden loss of power while driving in my 2023 Ford Escape. The vehicle has experienced multiple incidents where, while accelerating or pulling into traffic, it suddenly loses power, hesitates, or fails to respond to the accelerator. In some cases, the RPM drops unexpectedly, and the vehicle will not move or respond for several seconds. After this delay, the vehicle may jerk or surge forward suddenly. This creates a dangerous situation, especially when entering busy roads or intersections, as it puts me at risk of being struck by oncoming traffic. This issue has occurred multiple times and has been brought to the dealership on several occasions. The vehicle has undergone multiple repair attempts, including major engine-related repairs such as cylinder head and cooling system work, as well as a fuel system component replacement. Despite these efforts, the problem persists. On multiple visits, the dealership has stated they were unable to duplicate the issue, even though the condition continues to occur during normal driving. The vehicle has been out of service for an extended number of days due to these ongoing issues. This defect is intermittent but poses a serious safety hazard due to the unpredictable loss of power and delayed acceleration. I am concerned about the risk of an accident or injury if this issue is not properly identified and corrected. I am requesting that this issue be investigated, as it appears to be a recurring defect that may affect other vehicles of the same make and model

My 2023 Ford Escape acts like it is about to stall out once I hit the gas from a stop. It has happened multiple times. After idling for 10 minutes when I go to take off it will shift so hard that it pushes you forward in your seat. It has not been taken to a dealership yet since no light comes on and it doesn’t happen all the time. It has put my safety at risk since I was turning on the highway and it took 10-15 seconds to get up to speed.

Purchased brand new 11/2023, immediately started with electrical problems 01/2024, also would put car in reverse and car would cut off, was dropped off at service but never given a reason for the issue or a repair. 01/2025 car had acceleration issues, dropped off at service and was given a rental and given car back with no explanation. 6/2025 car went into limp mode and was towed to service where they found shards of metal throughout motor, replaced motor and then started having problems with cab filling with exhaust, was told they had no rental available and could continue to drive the car with my baby in it, then told was just a gasket needed to be replaced, car had same issue immediately, returned back to service where the turbo then needed to be replaced as well as catalytic converter gasket, after repair, called numerous times complaining that car would shift very hard and wouldn’t accelerate while driving or pulling out on an intersection or from a stop light, was told valve body needed to be replaced, then check engine light came on immediately after pickup, returned car and purge valve needed to be replaced, after pickup issue of car not accelerating continued, was told no issue found, car acceleration issues has became worse and now have been told soonest available appointment and rental is 02/12/2026.

My 2023 Ford Escape Plug-In Hybrid has experienced repeated high-voltage battery safety issues and prolonged loss of intended function. In February 2025, Ford notified me under recall 24S79 that I must immediately stop charging the vehicle due to the risk of internal battery cell short, potential battery thermal venting, and fire. That “do not charge” instruction lasted approximately six months, eliminating the core plug-in hybrid functionality of the vehicle. Ford originally stated the remedy would be available in Q2 2025, but the repair was not completed until late August 2025. The recall documentation stated that an internal battery cell short could cause the “Stop Safely Now” warning and sudden loss of motive power, which presents a serious safety risk while driving, especially when transporting my family. During the “do not charge” period the vehicle’s plug-in hybrid capability was unusable, and Ford acknowledged the risk of fire and loss of power. In November 2025, I received a new high-voltage battery recall 25SC4 (NHTSA 25V789) for the same general hazard category (internal short, potential fire, loss of motive power). The new recall states that no remedy is available at this time. This means the vehicle is again subject to a serious unresolved safety defect involving the same critical system. The repeated battery failures and the absence of a current fix create an ongoing safety concern, and the vehicle cannot be reliably used or sold during this open recall with no remedy. I am requesting NHTSA review the repeated HV battery defects, extended loss of plug-in hybrid functionality, delayed first recall remedy, and the current “no remedy available” condition, and assess whether further investigation or corrective action is needed for these vehicles.

As I was driving home with about 5 minutes to go, in my brand new (2 week old)2023 Ford Escape, I smelled something burning. I pulled over and saw smoke so I turned off the car and got out. As I got out of the car I looked under and saw fire. I got away from the car and as I did, the fire kept growing and growing from under the hood. The fire went high enough to hit the trees on the side of the roasd. The police and fire department came and were able to put out the fire but not before the car was distroyed. There were no warning lights or any other symtoms of a problem prior to smelling burning. The Ford company has not responded to me from the day my wife spoke to a representative on Monday, October 2nd. The car fire was on Saturday, September 30th. It's been 3 days. My insurance company was going to do an inspection. Ford wants nothing to do with us. We have a police report and a fire report. This clearly was a engine or electrical problem with this car. I was lucy this happened on a small street and not on the highway where pulling over would have been difficult. Lucky I could smell it so I knew to stop. Lucky I didn't have one or both of my toddler grandchildren in the back seat in their car seats! I would never have been able to get them out in time!

engine light came on took it into dealership. they said it was evap system then fixed it. picked car up in a wednesday by the friday, light came on again. took back into dealership, they didn’t detect any leaks.. said they were going to put in a canister purge solenoid. found out about 23S27.. apparently my vehicle vin doesn’t fall under that recall.. but yet my vehicle has all the signs.