2023 Ford Escape

The contact owns a 2023 Ford Escape. The contact stated while the vehicle was parked, the check engine warning light illuminated. The contact took the vehicle to the dealer where the vehicle was diagnosed, and it was determined that rodents had damaged the coil wiring. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 23,106.

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds and depressing the accelerator pedal, the vehicle failed to respond as needed. The contact stated that the RPM was not increasing on the gauge on the instrument cluster. There was no warning illuminated. The contact stated that the failure was intermittent but became a recurring failure. Additionally, the contact reported several electrical failures. The contact stated that the instrument cluster was blank, and the windows failed to respond while attempting to raise or lower the windows. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the transmission software needed to be re-flashed, and the 12-Volt battery needed to be replaced. The vehicle was repaired. The contact stated that the failure reoccurred, and the vehicle was taken back to the same dealer. The dealer replaced the 12-Volt battery; however, the failure recurred. The manufacturer was informed of the failure. The failure mileage was approximately 15,500.

Summary of Issues: 1. March 2024 – First Incident: •Warning lights appeared on the dashboard while driving (including ABS and power steering). •Vehicle was taken to Camelback Ford. •Dealership diagnosed a software update failure due to low voltage. •Battery was recharged, software updated, and codes cleared. ⸻ 2. April 6, 2024 – Battery Replacement: •Vehicle continued to experience electrical issues. •Battery was replaced by dealership under warranty. ⸻ 3. June 11, 2024 – Second Incident: •Dashboard warning lights returned. •Dealership again cleared codes, no new repair or replacement performed. •Explanation given was “modern cars have more computers” and that these issues were “normal.” ⸻ 4. July 12, 2024 – Third Incident: •While stopped at a red light, the entire dashboard shut off and restarted on its own. •Engine remained on, but the sudden blackout raised serious safety and reliability concerns. •Vehicle was not moved after the incident. •Dealership advised to return only if issue happens again. ⸻ Ongoing Concern: This vehicle has experienced repeated electrical system failures including instrument cluster blackout and communication errors, despite warranty repairs and a new battery. These intermittent issues pose a potential safety risk, especially if they occur while driving. The lack of a consistent fix raises concerns about the vehicle’s electrical integrity and reliability.

I purchased a Ford Escape 2023 in Green Bay, Wisconsin on [XXX] from Dorsch Ford Dealership. On October 7, 2023 I tried to start my vehicle and the battery was drained/dead. This continued through January of 2024, and I received a new battery. I thought the problem was fixed. Not so, and it has continued throughout the past two years. My vehicle will go into Deep Sleep Mode at different times of the day. I have to drive it to regenerate the battery. At times I do not even have lights when I start the Ford Escape. I have taken it to a Ford Dealership in Appleton. I am suppose to go again on March 25, 2025 and it will be my tenth time. The service person stated why should I even come because they can not find the problem. There is a parasitic draw and it needs to be found, or the battery is not operating properly, and needs to be replaced. I am a school teacher, and I thought I was buying a safe and reliable car. This is not the case. I have over 100 pages of documentation. I have filed complaints with Ford and with the State of Wisconsin Lemon Law to no avail. Also, I am close to warranty and then I will have to pay out of pocket. The Ford Motor Company is violating the consumer laws and not following their obligation to make repairs on my car. This is similar to the Bronco/Maverick battery issue. Something more electrical is happening under the hood. The service people I have dealt with even stated that I don't drive the car regularly. I have to now get up at 4am to get the battery charged. I can not access the added features such as remote start. I paid for something I didn't receive! Plus, what happens when I am driving and the vehicle decides to have a major malfunction? This is wrong on all levels. Please look into this matter immediately. I have had one recall concerning the door locks which were repaired last summer. I am worried and nervous to continue driving the Ford Escape 2023 because of its battery. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2023 Ford Escape. The contact stated while driving 40 MPH, the "Blind Spot Detection System Fault" message was displayed. The contact stated that several unknown warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the trailer tow wiring harness (Part Number: LX6Z-15A416-B). The contact was informed that the wiring harness was damaged by the heat shield. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The approximate failure mileage was 9,000.

While driving on an interstate, the Instrument cluster / digital gauge cluster screen behind my steering wheel turned off. I was driving with my adaptive cruise control on when all of a sudden I see the screen go black and I was no longer able to see how fast the car was going, the engine temperature, or how much fuel I had, as well as all of the other metrics on that dashboard. The car never lost power, because the entertainment screen in the middle of my dash remained on and responsive during the short period of time that my instrument cluster screen was off, and I never lost power steering. Instinctively, I pressed on the break pedal and pulled off of the road onto the shoulder, so I’m not sure if the cruise control would have stayed on. After a few minutes on the shoulder, the instrument cluster screen turned back on, not quite like it does when you turn on the car, but it flashed a bunch of the warning lights and slowly came back to normal. I was able to drive my car safely and without another incident back home, however I am very concerned about this happening again. There were no warning lights, signals, or sounds before this happened. Driving on any road, weather it’s a highway or an interstate, it is very important to be able to see how fast you are traveling for the safety of yourself, your children, and the other drivers. There is a popular recall among this same vehicle type, however mine was not included in the previous recall even though it just repeated the same problem the other ford escapes were having. My local dealership is not taking this problem seriously, and I am very concerned.

The contact owns a 2023 Ford Escape. The contact stated that upon starting the vehicle, the center console display remained off. The contact was able to continue driving the vehicle however, the center console and the display was independently turning on and off. No warning lights were illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 8,000.

The contact owns a 2023 Ford Escape. The contact stated while driving at various speeds, there was an abnormal sound coming from the engine and the front driver’s side tire. In addition, the instrument panel was occasionally turned off independently. Additionally, during rainy weather driving the brakes were making abnormal sounds. The contact stated that several unknown warning lights were occasionally illuminated. The vehicle was taken to a local dealer on several occasions and was diagnosed; however, the failure could not be replicated. The vehicle was taken to another local dealer, Mullinax Ford of Kissimmee (1810 E Irlo Bronson Memorial Hwy, Kissimmee, FL 34744); for a second opinion; however, the failure could not be replicated. The vehicle was also taken to a third local dealer, Tropical Ford (9900 S Orange Blossom Trl, Orlando, FL 32837); but the cause of the failure could not be determined. The vehicle was taken to a local independent mechanic where it was diagnosed and determined that an unknown material might have intruded into the engine. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 5,000.

The contact owns a 2023 Ford Escape. The contact stated on several occasions while driving, or while the vehicle was parked, all four doors locked inadvertently with the keys inside the vehicle. The contact stated the hatch failed to lock securely and there was no other way to get into the vehicle. The emergency brake light had illuminated. In addition, the contact stated that the cruise control was inoperable. The vehicle was taken to a local dealer where it was diagnosed but the vehicle could not be repaired on several occasions. The contact stated that a systems update was performed; however, the failure reoccurred. The manufacturer was made aware of the failure. The failure mileage was approximately 4,000.