NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
32 reportsClear category filter36,000 miles · Apr 14, 2026
Engine
The contact owns a 2022 Ford Escape. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment and underneath the vehicle. The check engine warning light was illuminated. The failure had occurred on several occasions. The vehicle was taken to a dealer, where it …
Read full complaint
The contact owns a 2022 Ford Escape. The contact stated that while driving at an undisclosed speed, there was an abnormal sound coming from the engine compartment and underneath the vehicle. The check engine warning light was illuminated. The failure had occurred on several occasions. The vehicle was taken to a dealer, where it was diagnosed, and it was determined that the brakes needed to be replaced. The vehicle was not repaired. The vehicle was taken to an independent mechanic, where it was diagnosed that the cause of the failure was not yet determined; however, the mechanic determined that the brakes were not responsible for the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 36,000.
NHTSA ODI #11731080
Mileage unknown · Mar 18, 2026
Electrical SystemEngineStructure
The power window on our 2022 Ford Escape will remain down after being rolled down and cannot be raised. This issue has occurred three separate times. When it happens, the vehicle cannot be secured and is exposed to weather and theft. The failure appears to be intermittent but recurring, indicating a possible design or electrical…
Read full complaint
The power window on our 2022 Ford Escape will remain down after being rolled down and cannot be raised. This issue has occurred three separate times. When it happens, the vehicle cannot be secured and is exposed to weather and theft. The failure appears to be intermittent but recurring, indicating a possible design or electrical defect rather than misuse. This creates a safety and security risk, especially if the failure occurs while away from home or during bad weather. This problem has happened multiple times and is not resolved by normal operation of the window switch. Engine problems are occurring as well due to the stated recalls provided by nhtsa.
NHTSA ODI #11725185
Mileage unknown · Mar 4, 2026
Engine
The Incident: While traveling at highway speeds on a public freeway, the engine suffered a catastrophic failure and stalled without warning. This caused an immediate loss of propulsion, power steering, and power braking. I was forced to navigate the vehicle across multiple lanes of high-speed traffic with no engine power, nearly…
Read full complaint
The Incident: While traveling at highway speeds on a public freeway, the engine suffered a catastrophic failure and stalled without warning. This caused an immediate loss of propulsion, power steering, and power braking. I was forced to navigate the vehicle across multiple lanes of high-speed traffic with no engine power, nearly resulting in a fatal collision. Background and Safety Risk: This is the second terminal engine failure this vehicle has suffered in under 60,000 miles. The first engine was replaced by a Ford dealer at approximately 30,000 miles due to a similar failure. The replacement engine has now failed at approximately 53,000 miles. This vehicle is also subject to Safety Recall 25S76 (Fuel Injector/Fire Hazard). Current Status: The defect has been confirmed by a Ford dealership which previously performed a full engine replacement. The manufacturer has not provided a permanent remedy for the current failure or the active fire recall. The vehicle remains a substantial and life-threatening safety risk to the driver and the public. No warning lights or symptoms appeared prior to the sudden engine shut-off at freeway speeds.
NHTSA ODI #11721960
Mileage unknown · Dec 29, 2025
EngineFuel/propulsion SystemPower Train
A car started jerking erratically. I put it in, drive or reverse. And the light on the transmission selector would just blink on and off and it would not go in gear when it did finally go in gear. It would not shift out of fourth gear. We'll erratic transmission would not shift cars behind me had to hit their brakes. Because my …
Read full complaint
A car started jerking erratically. I put it in, drive or reverse. And the light on the transmission selector would just blink on and off and it would not go in gear when it did finally go in gear. It would not shift out of fourth gear. We'll erratic transmission would not shift cars behind me had to hit their brakes. Because my vehicle would not move very dangerous. I took the vehicle in the Ford. They said it needs a transmission. I've got 65000 miles on this vehicle. It's 5000 miles past a warranty. Warning light did come on. My vehicle is now at an independent transmission shop and they say, I need a new transmission. I don't have the money to fix this. And Ford is wrong if we're not correcting it i will have the documents today. We're ford, it would only give me a small $7000 trade in allowance. Because it needed a transmission. I will be receiving the paperwork from Ford and the paperwork from the transmission shop that has my vehicle. Thank you.
NHTSA ODI #11707474
Mileage unknown · Dec 23, 2025
Electrical SystemEngineFuel/propulsion System
Engine light is now on and when i fill my car up with gas it has a stall and takes 3-4 times to turn on. My safety is at risk if this recall is not repaired and my car catches fire. Started a month ago and it's challenging to schedule with Ford.
NHTSA ODI #11706845
Mileage unknown · Dec 21, 2025
EngineFire
A Terrifying Ordeal and a Broken Promise: M.A’s Story A Known Danger Ignored In August 2025, M.A, a [XXX] woman living with Multiple Sclerosis, received a letter from Ford Motor Company. It was a recall notice for her 2022 Ford Escape, warning that a defect in the turbo system could cause engine fires. Despite this known dang…
Read full complaint
A Terrifying Ordeal and a Broken Promise: M.A’s Story A Known Danger Ignored In August 2025, M.A, a [XXX] woman living with Multiple Sclerosis, received a letter from Ford Motor Company. It was a recall notice for her 2022 Ford Escape, warning that a defect in the turbo system could cause engine fires. Despite this known danger, the letter contained a chilling instruction: there was "no recommendation to stop operating the vehicle." Trusting the manufacturer, M.A continued to drive her car—her essential link to independence. A Nightmare on the Road Two months later, in October 2025, that trust nearly cost M.A her life. While driving in Windsor, Ontario, she saw smoke, then flames erupt from under the hood. In a horrifying instant, the engine compartment burst into fire. Paralyzed by panic—a "brain freeze" moment where she couldn't even unlock her door—she was trapped. Only with the help of bystanders was she pulled to safety, where she watched helplessly as her car and everything she owned—clothes, jewelry, two laptops, an iPad, and three suitcases—were consumed by flames. Physical and Emotional Devastation The fire was extinguished, and the car was towed away, but the damage to M.A’s life was just beginning. The traumatic event triggered a severe relapse of her Multiple Sclerosis, worsening her physical disability. The profound stress and sadness have been overwhelming. She is now without a vehicle, struggling daily with lost mobility and independence. Abandoned by the Company at Fault When M.A contacted Ford for help, seeking accountability for the defect they had already acknowledged, she was met with indifference. Customer service representatives, both by phone and on Facebook, directed her only to her insurance company, washing their hands of responsibility for the catastrophic failure their recall had warned about INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11706397
Mileage unknown · Nov 12, 2025
EngineFuel/propulsion System
Recall has been issued since 7/16/25 and a serious safety risk issue has not been resolve. It is mentally draining and scary that whenever we drive our car there is always a risk of safety like car catching on fire. We have been patiently waiting for a long time now. Consumer safety should always be a priority specially we have …
Read full complaint
Recall has been issued since 7/16/25 and a serious safety risk issue has not been resolve. It is mentally draining and scary that whenever we drive our car there is always a risk of safety like car catching on fire. We have been patiently waiting for a long time now. Consumer safety should always be a priority specially we have 2 kids inside the car.
NHTSA ODI #11698864
49,100 miles · Nov 6, 2025
EngineEngine And Engine CoolingFuel System, Gasoline
The contact owns a 2022 Ford Escape. The contact stated that while driving at 30 MPH, the vehicle began to skid, and there was smoke coming from the engine and the exhaust. The wrench symbol was displayed. The engine warning light was illuminated. The contact stated that the turbocharger and the engine became inoperable. The con…
Read full complaint
The contact owns a 2022 Ford Escape. The contact stated that while driving at 30 MPH, the vehicle began to skid, and there was smoke coming from the engine and the exhaust. The wrench symbol was displayed. The engine warning light was illuminated. The contact stated that the turbocharger and the engine became inoperable. The contact had received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The local dealer was contacted and confirmed that parts were on backorder. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The contact stated that the manufacturer stated that there would be no action unless the vehicle blew up or there was a fatality. The failure mileage was approximately 49,100.
NHTSA ODI #11697892
Mileage unknown · Nov 4, 2025
EngineFuel/propulsion SystemFire
I am writing to formally demand immediate action regarding my 2022 Ford Escape, VIN [XXX] a 0% financing plan and Ford’s New Vehicle Limited Warranty. Since purchase, the Escape has suffered serious safety defects, including gasoline fumes inside the cabin, burning odors, and repeated performance failures tied to the fuel syste…
Read full complaint
I am writing to formally demand immediate action regarding my 2022 Ford Escape, VIN [XXX] a 0% financing plan and Ford’s New Vehicle Limited Warranty. Since purchase, the Escape has suffered serious safety defects, including gasoline fumes inside the cabin, burning odors, and repeated performance failures tied to the fuel system. On [XXX] and again on [XXX], the vehicle flamed up while being driven, requiring emergency intervention to extinguish. In August 2025, Ford issued Safety Recall 25S76, admitting that these vehicles may suffer fuel injector cracking, fuel leaks, and under-hood fires while being driven. Ford further admitted that no permanent repair remedy exists. The interim software update provided does not correct the defect. As a retired U.S. Army Combat Medic and Purple Heart recipient, I live with PTSD triggered by vehicle fires and explosions. The Escape’s condition has placed me in a state of medical crisis, making it impossible for me to safely operate the vehicle. FORD HAS DISCONTINUED THE LINE. I WANT A REPLACEMENT CAR OR I WANT TO BE COMPENSATED FOR THE RISK OF LOSS OF LIFE IF I DRIVE THE CAR. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11697416
58,500 miles · Oct 24, 2025
EngineFuel System, Gasoline
The contact owns a 2022 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with several unknown codes. The contact stated that the diagnostic codes were like the failure description for the unrepaired …
Read full complaint
The contact owns a 2022 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with several unknown codes. The contact stated that the diagnostic codes were like the failure description for the unrepaired recall. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline); however, the part for the recall repair was not available. The contact explained to the dealer about the unrepaired recall; however, the contact was informed that the repair had already been performed on the vehicle. In addition, the contact was informed that the repair would not be performed a second time free of charge. The manufacturer was not made aware of the failure. The failure mileage was 58,500.
NHTSA ODI #11695389
Official recalls
19Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Explorer, Escape, Lincoln Aviator, and Lincoln Corsair vehicles. The windshield wiper motor may fail and prevent the windshield wipers from operating properly.
Consequence & remedy
Consequence: Windshield wipers that fail to operate properly can reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the front wiper motors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed April 2, 2026. Additional letters will be sent once the final remedy is available, anticipated in October 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S14. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, Lincoln Corsair, 2020-2024 Lincoln Aviator, and Explorer vehicles. The image on the center display may flip or invert, resulting in an incorrectly displayed rearview image when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An incorrectly displayed rearview image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the accessory protocol interface module (APIM) software, free of charge. Owner notification letters were mailed June 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C11. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Dec 1, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2025 Escape vehicles. The liftgate hinge covers may not be properly secured and detach from the vehicle.
Consequence & remedy
Consequence: A detached liftgate hinge cover can create a distraction or a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and reinstall, or replace any missing liftgate hinge covers as necessary, free of charge. Owner notification letters were mailed June 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SD6. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on December 3, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Jul 11, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco Sport and 2020-2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software. In addition, dealers will replace the high-pressure fuel rail assembly and fuel injectors, free of charge. As an interim repair, dealers will update the engine control software, free of charge. Interim owner notification letters notifying owners of the safety risk were mailed August 29, 2025. Second letters will be sent once the final remedy is available, anticipated in July 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S76. This recall expands and replaces previous recall numbers 22V-859, 24V187, and 25V165. Vehicles previously remedied under 22V-859, 24V187, and 25V165 will need to have the new final remedy performed once it is available.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2023 Bronco Sport vehicles previously repaired incorrectly under recall numbers 22V-859 or 24V-187. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the powertrain control module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S21.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2022 Escape, and 2021-2022 Lincoln Corsair vehicles previously repaired incorrectly under recall number 24V-330. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S16.
Dec 20, 2024
Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.
Consequence & remedy
Consequence: Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.
Remedy: Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
May 10, 2024
Ford Motor Company (Ford) is recalling certain 2022-2024 Maverick, 2020-2022 Escape, and 2021-2022 Lincoln Corsair vehicles. The Hybrid Powertrain Control Module (HPCM) software may cause the vehicle to shift into neutral unexpectedly, causing a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will update the HPCM software, free of charge. Owner notification letters were mailed May 22, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S33.
Mar 8, 2024
Ford Motor Company (Ford) is recalling certain 2022-2023 Bronco Sport and 2022 Escape vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Owner notification letters were mailed on April 24, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S16. This recall is an expansion of previous recall number 22V-859.
May 26, 2023
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.
Nov 18, 2022
Ford Motor Company (Ford) is recalling certain 2020-2023 Escape and 2021-2023 Bronco Sport vehicles equipped with 1.5L engines. A fuel injector may crack and leak fuel inside the engine compartment.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will update the engine control software to include fuel injector leak detection and install a drain tube, free of charge. Interim owner notification letters informing owners of the safety risk were mailed January 9, 2023. Remedy parts are expected to be available in 1st Quarter of 2023. Owner notification letters were mailed February 28, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S73. This recall includes all vehicles previously recalled under 22V-191. Vehicles previously remedied under 22V-191 will need to have the new remedy performed.
Jul 7, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence & remedy
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Additional source detail variants (3)
Structure:body:bumpers:active Shutters/grill
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Engine And Engine Cooling
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape, 2021-2022 Lincoln Corsair, and 2022 Maverick vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.
Consequence: An engine compartment fire increases the risk of injury.
Remedy: Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will modify the under engine shield and active grille shutter, free of charge. Owner notification letters were mailed August 19, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S47.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2020-2022 Escape and 2021-2022 Bronco Sport vehicles equipped with 1.5L engines. The engine oil separator housing may crack and develop an oil leak.
Consequence & remedy
Consequence: An oil leak in the presence of an ignition source such as hot engine or exhaust components, can increase the risk of a fire.
Remedy: Dealers will inspect the oil separator for damage or oil leaks, and replace the oil separator and seals, as necessary, free of charge. Owner notification letters were mailed April 18, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S21.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Additional source detail variants (2)
Hybrid Propulsion System
Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Electrical System:propulsion System:traction Battery
Ford Motor Company (Ford) is recalling certain 2022 Corsair and 2021-2022 Escape vehicles equipped with a 2.5L Hybrid powertrain. The high voltage battery may fail, resulting in a sudden loss of drive power.
Consequence: A sudden loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the high voltage battery, free of charge. Owner notification letters were mailed March 28, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S48.
Nov 23, 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco Sport and Escape vehicles. The rear brake linings may have been manufactured incorrectly, which can affect braking performance. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: During certain situations, the driver may have to apply more brake pedal force, and the distance required to stop the vehicle may be extended, increasing the risk of a crash.
Remedy: Dealers will replace the front brake pads, free of charge. Owner notification letters were mailed August 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C31.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24008 · Underhood Fires Caused By Fuel Leak
Opened Apr 11, 2024 · Closed Oct 30, 2025
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:injectors
On April 11, 2024, NHTSA’s Office of Defects Investigation (“ODI”) opened this Recall Query (“RQ”) to investigate the adequacy of, including various safety concerns associated with, the remedy program in recalls 22V-859 (filed Nov. 18, 2022) and 24V-187 (filed Mar. 8, 2024). The vehicle population associated with these recalls includes certain MY 2020-2022 Ford Escape vehicles and MY 2021-2023 Ford Bronco Sport vehicles equipped with 1.5L engines. The safety defect in each recall involves high-pressure fuel injectors that are susceptible to cracking, allowing liquid fuel and fuel vapor to migrate onto hot surfaces within the engine compartment potentially resulting in underhood vehicle fires. The remedy programs described in recalls 22V-859 and 24V-187 are identical and involve both a software component and a hardware component. Specifically, Ford developed an updated engine control software designed to detect a pressure drop in the high-pressure fuel rail, provide instrument cluster messaging to the driver, invoke a strategy to disable the high-pressure fuel pump, derate the engine output, and lower the temperatures of possible ignition sources within the engine compartment. Additionally, Ford would install a tube into the engine’s cylinder head drain hole to shunt spilled liquid fuel past the various hot surfaces within the engine compartment and ultimately discard the spilled liquid fuel onto the roadway. ODI identified various safety concerns with this remedy program, which, among other things, notably did not include repairing or replacing the defective part and potentially did include the introduction of new safety defects (like fuel spilling near the spark plugs and fuel spilling onto the public roadway). NHTSA opened this investigation to evaluate these concerns with the remedy program, including whether the vehicles were still susceptible to underhood fires even post-remedy. As described in more detail in the Additional Summary posted simultaneously with this resume, ODI conducted a thorough investigation that included analyzing data and other materials received in response to two Information Requests, as well as inspections of post-remedy vehicles that experienced an underhood fire. ODI and Ford worked to identify and locate vehicles that experienced post-remedy fires and conduct joint vehicle inspections. ODI’s investigation also prompted Ford to initiate a more in-depth evaluation of the defect, including Ford’s conducting component level testing of high-pressure fuel injectors. ODI met with Ford on several occasions throughout this investigation to jointly conduct certain of these described tasks and to discuss test results. A collateral issue surfaced as a result of this investigation: in March 2025, Ford realized that despite relevant repairs having been recorded as successfully completed, approximately 33,576 vehicles subject to recalls 22V-859 and 24V-187 did not have the software component of the remedy program installed correctly. Thus, on March 27, 2025, Ford filed a new related recall (25V-165) for these vehicles, notifying NHTSA and the public that they were still at risk of experiencing an underhood vehicle fire due to cracked fuel injectors despite the consumer having had their vehicle remedied pursuant to one of the two earlier recalls. In June 2025, Ford committed to implementing a new remedy program to repair the vehicles. On July 11, 2025, Ford documented this commitment in a new recall filing (25V-467), which explains that Ford’s upcoming remedy program will involve proactive replacement of all high-pressure fuel injectors within the recall population. In view of the recall action taken by Ford, ODI is closing this Recall Query, which was opened given NHTSA’s concerns that the initial remedy programs of the software to detect the pressure drop plus installation of the drain tube did not constitute an adequate repair. The agency reserves the right to take additional action if warranted by future circumstances.
PE23013 · Failed Door Check Arm Attachment Point
Opened Jul 7, 2023 · Closed Jan 24, 2024
Status: closed (inferred from source dates) · Structure:body:door ; Structure:body:door:hinge And Attachments
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Structure:body:door
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Structure:body:door:hinge And Attachments
On July 7, 2023, the Office of Defects Investigation (ODI) opened PE23-013 to investigate instances of check arm bracket failure in the front doors in model year (MY) 2020-2021 Ford Escape vehicles. At the time of opening, ODI received 118 Vehicle Owner Questionnaires (VOQs) alleging this failure. To date, ODI has received 593 VOQs alleging this failure, with a variety of reported failure conditions. The most common reported failure condition was reduced door functionality (e.g. door was more difficult to open or close) and the least common was inadvertent door opening. Other reported failure conditions include inability to latch and inability to open. Three VOQs reported injuries, one of which requiring medical attention. ODI conducted a consumer survey which yielded an additional 44 injuries (although the VOQs did not indicate any injury), none of which requiring medical attention. All these injuries were bumps/bruises from the door closing on occupants’ arms and legs while entering and exiting the vehicle. The function of the check arm system is to provide hold-open assist at specific angles and to assist with door closing energy. It does not provide vertical support of the door and is independent of the latching mechanism. This failure is progressive and detectable by vehicle occupants. Consumers commonly report hearing a popping or snapping noise when opening and closing the door. This noise is caused by some of the welds between the bracket and door structure failing and detaching. There may also be visible damage present to the welds in the door structure. Continued use of the door may result in all welds separating and the bracket fully detaching from the door structure, which could lead to increased resistance in closing and opening the door, restrained window operation, and the door freely rotating when open. ODI inspected 3 consumer vehicles in the field, and 2 test vehicles at Ford’s testing facility. The test vehicles were retrofitted with the failed component. ODI observed an increased door closing resistance, however, was unable to reproduce an inadvertent open while parked or driving, or a failure to latch or open condition. Testing also verified this failure did not affect the door ajar warning system. This system provides an audible and visual warning in the event a door did not achieve primary latch position. Ford has provided details on a one-time-repair customer satisfaction program (23B56), stating that they will provide customers with a letter, currently targeted for March 2024, to bring their vehicle to a Ford dealership for a proactive repair. Dealers will inspect the door check arm welds for damage and will either provide a rivet plate to reinforce the existing door check arm or will provide a replacement door, depending on the level of damage present. Customers will be eligible for reimbursement if they previously paid to repair this issue. In view of the high detectability of failure, low potential hazard to drivers, and Ford’s customer satisfaction program to provide a proactive repair, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration