2018 Ford Escape

My engine gave a warning, check engine light went on. I took it to the dealer and the mechanic said the engine failed due to coolant intrusion. Upon searching the issue, this is apparently a common issue in these ecoBoost engine cars that Ford has not issued a recall on, but did send out some satisfaction notice. I never received this notice for some reason. The notice indicates the need to monitor coolant leak, but I never noticed any and wasn't looking for it since I never received the notice. I have contacted Ford about compensating me for a new engine on a 5 year old car, to which they said no because my car is over 84,000 miles (it is as 85,487). I need Ford to recall this issue and frankly it should be criminal not to actively pursue a fix for a known huge and expensive issue that I honestly cannot afford to repair.

The contact owns a 2018 Ford Escape. The contact stated while driving 40 MPH, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to an independent mechanic, and it was determined that coolant intrusion had damaged the engine. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 21N12, but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 72,000.

The contact owns a 2018 Ford Escape. The contact stated while driving at an undisclosed speed, the engine misfired. Additionally, the contact noticed a burning odor on the interior of the vehicle. The vehicle was taken to the dealer. The contact was informed that the failure was related to TSB Number: 22-2134. The contact was then informed that the vehicle could not be repaired under TSB Number: 22-2134, because the TSB had expired, and the vehicle had a Salvage Title. Additionally, the contact received notification NHTSA Campaign Number: 22V413000 (Power Train). The contact was informed by the dealer that the recall repair would not be completed due to the Salvaged Title. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 108,000.

While driving this vehicle (~88,000 miles) on a route of ~100 miles, the car started shuddering / shaking at highway speed for 30 - 90 seconds every 10 - 15 minutes. I was 50 miles in to the drive when the shaking began. The shaking was startling and distracting. I drove the car to the dealer that night. While driving to the dealer, the car continued to shudder / shake for even longer durations at greater frequency. Additionally, the car had weak acceleration when the gas pedal was compressed. This created significant challenges when trying to navigate traffic (merging on to highway, accelerating car from stop, etc.). I have a video of the dash which shows the car exceeding 4000 RPM and not exceeding 25mph. I can share this video over e-mail, but could not attach to this form. - The dealer believes this is a malfunction of the powertrain (transmission). It is available for inspection at the time of this writing. However, I am working with Ford and the dealer on a repair solution as this is my primary car. - My safety was at risk because the car shaking was distracting and the lack of acceleration presented challenges with merging, passing cars, accelerating from stop, etc. - Vehicle is currently with dealer beginning inspection - initial suspicion is transmission issue. - No warning lights came on as I was experiencing this issue.

While driving this vehicle (~87,000 miles), the engine began to overheat. The engine light had come on the day before (Saturday). The engine began to overheat the next day (Sunday) while driving on the highway. I quickly pulled off the highway and drove the vehicle back home while staying at a low speed. If I had not taken this action, the engine overheating could have posed a safety risk. Upon receiving repairs at a Ford dealer, I later learned that this engine overheating is a known issue by Ford. It is caused by coolant intrusion to the engine. Two customer satisfaction programs have been issued for this problem: 19B37, 21N12. However, given the safety issue (engine overheating), I was surprised this repair was not fully covered. This issue happened in my vehicle after the extended warranty period of 84,000 miles.

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the Engine Overheated message was displayed. The vehicle was taken to the dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was informed that the VIN was included in Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the mileage warranty had expired. The contact stated that he had not received notification of the Customer Satisfaction Program. The failure mileage was approximately 109,000.

The contact owns a 2018 Ford Escape. The contact stated that while pulling out of the driveway at 10 - 15 MPH, at approximately 100 meters down the street, the transmission fault message was displayed on the instrument panel. The contact immediately turned around and parked in the driveway. The contact learned of NHTSA Campaign Number: 22V413000 (Power Train) and believed that the failure the vehicle had experienced was related to the recall. The vehicle was taken to the dealer where it was confirmed that the VIN was not included in the recall. The dealer diagnosed that the transmission had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure where it was confirmed that the VIN was not included in the recall nor was the warranty coverage available. The manufacturer opened a case regarding the failure and referred the contact to the dealer for further assistance. The approximate failure mileage was 39,000.

Subject: Complaint Regarding Electrical Malfunction in 2018 Ford Escape To Whom It May Concern, I am writing to report a concerning electrical malfunction that occurred in my 2018 Ford Escape, resulting in a critical safety issue. At 55,000 miles, the Accessory Protocol Interface Module (APIM) failed, subsequently causing the touch screen, navigation system, voice command functionality, and hands-free communication features to cease operation. Additionally, this failure disabled the phone charging capabilities, posing a safety concern due to the loss of essential functionalities. The malfunction of the APIM at such a relatively low mileage directly impacted the navigation system, voice commands, and the hands-free communication system, rendering them non-functional. As a consequence, this electrical issue posed safety risks, particularly concerning the failure of the navigation system and voice commands, which are crucial for safe driving practices. The incident occurred, and subsequent repair cost of $1,163.72, were serviced at SERRA Ford dealership in Farmington Hills, MI. The nature of this electrical failure not only incurred financial costs but also posed potential safety hazards, especially with the impairment of critical functionalities like the rear-view camera, navigation, and hands-free communication. I urge the National Highway Traffic Safety Administration (NHTSA) to investigate this matter promptly, as it not only caused inconvenience and financial burden but also compromised the safety features of the vehicle. This complaint aims to highlight the serious implications of electrical failures in Ford Escape vehicles, emphasizing the potential risks it poses to drivers, passengers, and others on the road. Please consider this complaint as a formal report to address and rectify these safety concerns, preventing similar incidents in other vehicles. Your attention to this matter is highly appreciated.