2018 Ford Escape

I lost engine power trying to accelerate while entering the highway. Check Engine light flashed several times then went steady. I pulled over into the slow lane with my flashers on and with reduced power to get off the highway exit straight to the Dealer. The Check Engine light stayed on steady. This is apparently part of a known issue with the 1.5l GTDI engine. There was a Technical Service Bulletin created for it 22-2322 and a Customer Service Program fix was set up- 21N12

We started to notice a rough idle when starting the vehicle, the check engine light came on. The rough idle continued to get worse. We took it to a Certified Mechanic to have it inspected. Based upon the check engine status, they did further diagnosis through various tests. They determined that the coolant appeared to be seeping into the #1 cylinder. They checked the Ford website for any recalls and found a TSB ( Technical Service Bulletin} # 19-2346 regarding the 2.0L Eco-Boost engine. Ford's TSP says to replace the engine block, but does not indicate at who's expense. If this is defective and Ford knows, the consumer should not be responsible to pay for this major expense. What do we do? Within the ;next couple weeks we plan to take the car into a Ford Dealership to do their own diagnosis.

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle failed to shift into gear properly, with the transmission warning light illuminated. The contact also stated that the vehicle failed to shift into reverse and was unable to operate while in reverse. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000.

I own a 2018 Ford Escape. Current mileage is 58,847 and was serviced regularly. In July of this year, the transmission failed completely while driving. No warnings or symptoms prior to complete failure. I was very lucky that the highway I was traveling on was not busy and I was able to coast into a parking lot. I had to pay a towing fee to have it taken to my local Ford dealer where they informed me my transmission had failed!! The transmission fluid was found to be burnt and contained a lot of metal shavings in it. The cost to replace the transmission with a remanufactured one was over $9500. My local Ford dealer installed a remanufactured transmission on July 22, 2025. I continued to have issues such as shift hesitation and other error messages. I took it back to the dealer on Aug 25, 2025. I requested to the tech that the transmission fluid be checked. He stated that after only 30 days, the oil was already discolored from being too hot and there were metal shavings in the fluid. Only about 600 miles were put on the vehicle since the transmission repair. The service manager stated that it will surely fail again based on the condition of the fluid. The service manager also stated that it is possible that I will need a THIRD transmission! In doing research, I found that my particular model is prone to premature transmission failure. There are several Class Action lawsuits against Ford Motor Co for 2018 - 2020 Escapes for this defective transmission. And in addition, it states that Ford was aware of the issues and yet continued to manufacture vehicles with this particular transmission in it. Why was there no recall issued? Why did Ford Motor Co not make consumers aware of the problem in order to be able to take preventative measures? With 700,000 of these vehicles on the road, this is a serious safety issue which could result in loss of control while driving, and possible catastrophic results. Ford Motor Co should be liable for the defective transmission.

The contact owns a 2018 Ford Escape. The contact stated that while driving 80 MPH and depressing the accelerator pedal, the vehicle failed to respond as intended. An independent mechanic was contacted. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the transmission needed to be replaced. The transmission was replaced, and the vehicle was repaired. The manufacturer was notified of the failure and opened a case. The approximate failure mileage was 85,822.

Engine failure. No engine lights are on and vehicle is driving fine, but engine block could crack due to coolant intrusion problem. Coolant intrusion is a defect in the motor well know to Ford and mechanics.Ford customer satisfaction program:21N12 and 19B37.TSB tech. serv. bulleting 22-2134 and 19-2375. Problem has been confirmed by private mechanic shop and Ford dealer. No warning lights, no messages, no symptoms. Problem appeared scheduled maintenance & multipoint inspection.

Coolant intrusion . Coolant leak caused the vehicle to overheat and thus making it unable to drive . Had to tow to a repair facility and they confirmed that it’s a coolant intrusion, a common issue with Ford Escape .Engine warning light came up and there were mis fires in engine. In a week , got an engine overheat warning in the morning when I started the car .