2018 Ford Escape

I purchased a 2018 Ford Escape in February 2024 with 80,000 miles from a dealership. The vehicle had a single owner and appeared to be in great condition at the time of purchase. However, in December 2024 it presented a critical safety issue involving the engine. While driving, the vehicle began shaking violently and lost power, almost stopping in the middle of an intersection. This placed me and others at significant risk of a collision, as I was unable to control the car properly or move it safely out of traffic. The problem was confirmed by the Ford dealership, where diagnostics initially revealed a misfire code (P0302). After further inspection, the dealership determined that the engine required a full replacement. This repair was estimated to cost $9,000—nearly the current value of the vehicle. The car is at the dealership and has not been repaired due to the prohibitive cost. Through my research, I found Technical Service Bulletin (TSB) 19-2346, which documents similar engine issues reported by other Ford Escape owners, requiring significant repairs and part replacements. Despite reaching out to Ford Customer Service, I was denied assistance and left to bear the full cost of these extensive repairs. There were no warning lamps or messages prior to the failure. The issue occurred without warning while I was driving, making the defect hazardous. Given the serious safety implications of this defect, I strongly urge this issue to be considered for recall. A vehicle with relatively low mileage should not experience catastrophic engine failure, and Ford must take responsibility for addressing this widespread and dangerous issue. My life and the safety of others on the road are far more valuable than the cost of repairs.

Coolant is getting in to the engine and blowing the engine up. Ford is aware of the issue but is denying coverage and repair under a distraction. They are aware of the repair and issued Customer Satisfaction program 21N12 which is the fix to the engine. However, they say that if customer satisfaction program 19B37 was not completed prior to 2022, then you do not qualify to do 21N12 even though under 21N12 if the car is under 7 years old and 84,000 miles that it qualifies. Ford says that if the previous owner (since we did not get the car until 2023/24) did not do 19B37 that we are screwed and they will not cover the engine replacement that they know about. This issue is all over the internet, so I am shocked a recall has not been issued.

Complete Engine failure causing vehicle to be totally un drive able at only 91,000 miles. Engine failure cause was diagnosed by local authorized Ford dealer service department as systemic engine design flaw that caused catastrophic fluid intrusion into cylinder(s), rendering engine useless. Remedy, engine needs to be totally replaced, not repaired, but replaced. Not an isolated incident in my particular case as there have been thousands of issues with this model of engine that FORD (manufacturer) has employed on this model year, make, and model (2018 Ford Escape SEL). No warning lamps lighted to warn of potential engine failure, and most importantly, no written notices provided by Ford to alert of the catastrophic engine issue, and certainly no information on remedies provided either.

The contact owns a 2018 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning illuminated. In addition, the vehicle was driving unusually rough with the engine misfiring. The contact and his father attempted to change the spark plugs. The contact stated that one of the spark plugs had seized and was unable to be removed. The vehicle was towed to the dealer where it was diagnosed with a coolant leak and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed that the repair was not covered under recall repair or special programs. The failure mileage was approximately 86,000.

Less than one month after purchasing this used vehicle from a dealership, the check engine light came on. A personal code reader showed the PO302 code. Upon inspection by the manufacturer dealer we were told that it has an engine coolant leak, known as coolant intrusion. The mechanic noted that the engine appeared to have parts replaced trying to rectify this issue (prior to our ownership) but that the only fix to this issue is engine replacement with a cost of around $9500. We were told this would be our cost as the manufacturer no longer replaces the engines under a previous satisfaction program. Now the vehicle is shuttering and has the permanent PO302 code and showing signs of consistent misfiring. Facts lead us to the fact that the previous owner did not resolve the issue and then the dealership put a vehicle on the lot that should not have been without a new engine as this was a pre-existing problem to our purchase.

My engine check light came on and it said Engine Fault Service Now, with a wrench signal exposed. Then I could hardly stop the vehicle , it became very difficult to apply the brakes, using all of my body weight applied to stop the vehicle. I immediately brought it to O’Reily’s auto place and had a diagnostic test run on the vehicle. Multiple default code come up. P1016, p0365, p0299,p164D p0369,p0443,p0456,p1450. Brought it to the Ford dealership, upon inspection the diagnosis Evap system related disc on this line , tested evap system, found canister purge valve to be broken , tech notes that this is a non Oem part. Advised to replace purge valve and hose assembly. Also discovered that vacuum pump not pulling vacuum, advise to replace pump and reset. Upon removal of the vacuum pump, found pump cam lobe twisted off , vacuum pump is seized, cam replacement is seized , cam replacement will be required. Also both front axel boots are torn, spewing grease all over, recommend replacing both axels, leak p2 pinion value, left back axel leaking, both back brake rotors and pads worn 2mm in the red, coolant level low possible leak. Also is discovered that there was a non ford part purge valve that shouldn’t be there. Estimated cost is 8,500-9000 dollars could be more

Good morning, I would like to discuss an issue concerning the Ford Motor Company and one of their many Technician Service Bulletins (TSB). I am a former auto technician now healthcare worker and had the unfortunate luck of purchasing a 2018 Ford Escape with 55k miles for my wife in 2023. The vehicle now has a check engine light on due to engine coolant leaking into the cylinders at 97k miles. After research I discovered Ford issued a limited time fix NOT a recall under the heading of TSB 19-2375 & TSB 21-N-12. The whole engine needs to be replaced and the Ford Motor Company will not pay for a flawed design. There seems to be multiple lawsuits due to many of these engines failing in different Ford Models. Why hasn't this been forced to be a recall? Many people are struggling as it is and a 7 thousand dollar repair is going to put me under. The people of this country including myself need the help of people with is voice. Please I am sinking here

Car occasionally ran rough, engine light came on, code indicated a misfire so we changed the spark plugs and coils. No improvement, then suddenly while on the interstate, it was jumping and bucking and could barely run. Took it to a Ford dealer and they said it was a known problem with engine coolant leaks in Ecoboost engines but that they what $9,000 to replace it. This is not only reprehensible corporate irresponsibility but a safety issue, as my defective engine suddenly stopped working properly while I was driving in heavy high speed traffic.