2017 Ford Escape

The contact owns a 2017 Ford Escape. The contact stated that the check engine warning light was illuminated. The contact stated that a Ford mobile mechanic diagnosed the vehicle and recommended that the spark plug and ignition coil be replaced. The parts were replaced; however, the failure persisted. The vehicle was taken to the dealer, where it was diagnosed that the engine had failed and needed to be replaced due to coolant intrusion into the engine. The dealer related the failure to Ford TSB Number: 22-2229. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 108,258.

The contact owns a 2017 Ford Escape. The contact stated while driving 70 MPH, the vehicle started to lose motive power. The contact stated that unknown warning lights illuminated, and an audible chime sounded. The contact merged to the side of the road and the vehicle failed to respond. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the transmission module and fuel pump had failed. The vehicle was repaired; however, the failure persisted. The vehicle was taken to a second independent mechanic and was diagnosed with gas tank failure. The vehicle was repaired but the failure persisted. The vehicle was then taken to a third independent mechanic where it was diagnosed with a blown head gasket. The local dealer was not contacted. The vehicle was not repaired for the most recent failure. The manufacturer was made aware of the failure. The failure mileage was approximately 110,000.

During the month of September 2024 my Ford Escape Ecoboost developed a rough idle. I took it into our Ford dealership for evaluation. The diagnosis was that coolant had leaked into the cylinder #3 due to a head gasket failure and that I would need to have the engine long block replaced at an estimated cost, at the time, of about $8000. My vehicle has less than 45,000 miles on it. We had the Ford dealership go ahead with the repair; however, I asked that the service advisor request Out of Warranty Assistance from Ford. He did and received a claim number of: CXH 02689613-N6N4L5. He also informed us that our request for financial assistance had been rejected due to the fact that it was outside the extended warranty of 7 years. Mind you, this was about 6 weeks after the end of the warranty that it began to fail and the car had less than 45,000 miles. This issue with the Ford Ecoboost is well known and has caused engine failure. We just didn't let it go to the point of failure, due to our reliance on this car and safety concerns.

The contact owns a 2017 Ford Escape. The contact stated that during a State Inspection, the contact was informed that coolant was leaking into the engine. The contact stated that the check engine warning light illuminated after the Inspection. The independent mechanic stated that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 54,000.

To whom it may concern, We purchased a 2017 Ford Escape Titanium Ecoboost used approximately 3 years ago. Since, September of 2024 we have been having issues with the car. Some of the issues involved overheating due to internal coolant / antifreeze loss that allows coolant to enter into the cylinders of the engine causing engine failure. The check engine light comes on and saw blue or white smoke emitting from the car and misfires when coolant leaked into the cylinders. The most common PCM codes reported as associated with misfire related to the internal coolant leak are P0316 and P0302. Ford previously recalled certain 2013 and 2014 Ford vehicles equipped with the 1.6L engine for a very similar issues under recall campaigns 12V551 and 17V209. However, no such recall exists for the similar issues reported by consumers with the 1.5L and 2.0L Ford Ecoboost engines. We still owe $14,600 on this car and 4 mechanics and Ford have said it needs a new engine. We cannot afford $5000 to $10,000 for a new engine on a car we still owe on. Not sure if you are able to help us out with this issue. Thank you for your time.

The contact owns a 2017 Ford Escape. The contact stated that upon starting up the vehicle, there was an abnormal shaking coming from the engine. The contact stated that while attempting to accelerate, the vehicle hesitated, and drove at a reduced speed. The check engine warning light was illuminated. The contact pulled over to the side of the road, restarted the vehicle, but the vehicle failed to exceed 35 MPH. The vehicle was driven to a local dealer where the vehicle was diagnosed, and the contact was informed that there was coolant intrusion into the engine and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 55,000.

The contact owns a 2017 Ford Escape. The contact stated while driving at various speeds, the engine was overheating. The contact was unaware of a warning light being illuminated. The contact added coolant to the coolant reservoir; however, the failure persisted. The vehicle was taken to Worrall Carburation & Machine, where it was diagnosed and determined that the engine needed to be replaced due to coolant intrusion into the cylinders. The mechanic replaced the engine with a new crate engine that was purchased from the dealer. Additionally, the mechanic replaced the turbo charger. The vehicle was repaired. The dealer was notified of the failure. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 82,000.