2017 Ford Escape

Started out as misfire codes. Replaced spark plugs then ignition coils. Still getting misfire codes. Discovered engine coolant low and through research found there to be an KNOWN design flaw/issue with these engines that usually results in an entire COSTLY replacement to the customer. Listed in Ford TSB 22-2229. This should be a recall covered entirely by ford.

White smoke from the exhaust, engine knocking, low coolant levels with no visible leak and check engine light on. These things happened simultaneously out of nowhere. Went to the dealership to get diagnostic and was told water pump was leaking and needed to be replaced. Reported to my insurance company which prompted the dealership to investigate further by doing further diagnostic (a leak down test) and found that there was a coolant intrusion into the cylinder bores and the entire engine needed replacing. Repair is currently still in progress. My vehicle has been inoperable for 9 weeks, and at the dealership for 7 weeks now; with no ETA on repair completion.

The engine has a crack in cylinder 2. The vehicle is available for inspection in either Lakeland Florida or Dade City Florida. I am at risk of total engine failure while traveling, which could cause a multiple vehicle accident on the very busy roads here. The problem has been confirmed by a certified Ford mechanic who checked the engine fault code and pulled the ignition coil and spark plug to examine the cylinder. No others have examined the vehicle. I have contacted the local Ford dealership but have yet to hear back. The check engine light came on on [XXX], 3 days after I had a Ford dealership change the oil. I tried to make an appointment with the Ford dealership on April [XXX], but the clerk said I had to wait 8 more days (April XXX) for them to put it on the machine to read the code. I took it to a certified Ford mechanic who is at an independent garage on April [XXX]. He used the machine to read the code. He also noticed that the coolant was at the bottom of the tank. Had I waited until April [XXX] for the dealership to see my vehicle, the engine would have completely seized up and the entire engine would have been ruined. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2017 Ford Escape. The contact stated while driving approximately 60 MPH, the vehicle lost motive power and stalled. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the cylinder head was cracked, and the engine needed to be replaced. The vehicle was later towed to the local dealer who confirmed the original diagnosis that the engine was faulty. The vehicle was not repaired. The manufacturer was contacted regarding the failure, but no assistance was offered. The failure mileage was 85,000.

The contact owns a 2017 Ford Escape. The contact stated that while stopped at a traffic light, there was smoke coming from the engine compartment. The vehicle was taken to an independent mechanic where it was diagnosed that coolant and oil were leaking and the turbocharger and hoses needed to be replaced. The vehicle was repaired. On another occasion, while driving approximately 35 MPH, the check engine warning light illuminated. The vehicle was taken to the residence where a handheld diagnostic machine diagnosed that the spark plugs needed to be replaced. The vehicle was then taken to an independent mechanic where it had faulty wheel bearings, spark plugs, and a coolant leak. The contact was informed that the spark plugs and wheel bearings needed to be replaced. The vehicle was repaired but the check engine light illuminated within a week. The vehicle was then taken to the dealer where it was diagnosed that the coolant leaked into cylinder #1 and the engine needed to be replaced. The manufacturer was not notified of the failure. The failure mileage was 84,340.

The contact owns a 2017 Ford Escape. The contact stated that while operating the vehicle, the engine experienced rough operation, reduced power, and the check engine warning light remained illuminated. The vehicle was taken to the local mechanic who diagnosed an engine misfire was present in cylinder #3. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 80,000.

The contact owns a 2017 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the catalytic converter. The vehicle was not repaired. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 94,000.