2017 Ford Escape

Ford has known of a coolant intrusion problem and even issued an extended 7 yr/84k mile warranty for this issue. The car has no issues during that time. I now have to replace the engine on a 9 year old car with only 80k miles on it. Cars engines should last more than 9 years. Ford told me that an engine replacement at 9 years could happen to anyone. There are hundred of complaints online about this known issue. If the engine were to go out on a busy road, it could easily cause an accident.

I am reporting a serious engine failure involving a 2017 Ford Escape SE AWD 2.0L EcoBoost, VIN [XXX]. The vehicle was purchased in October 2024 as a Ford Blue Advantage Certified vehicle from Lithia Ford of Boise with approximately 32,000 miles. The vehicle currently has approximately 45,000 miles. In June 2026, the vehicle developed a check engine warning light while being driven in [XXX]. Prior to this event, the vehicle had shown no unusual symptoms, warning signs, or performance issues. The vehicle was inspected by an independent automotive repair facility, Meridian Automotive in [XXX], and was diagnosed with coolant intrusion requiring replacement of the long block engine assembly. The estimated repair cost is approximately $9,000–$10,000. This is a major engine failure occurring at only 45,000 miles and after approximately 13,000 miles of ownership since purchase. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2017 Ford Escape SE. 77,000 miles. Blown head gasket due to coolant leak that ford was aware of in letter TSV19-2139 but no recall. Cylinder 2 misfire code even after tune up. Today catastrophic overheating with no warning and car went into limp mode at the intersection of Hull Street and Southshore Dr. Midlothian Va 23112. I reached out to local ford dealer and to Ford Consumer affairs but they are unwilling to repair though there was a a courtesy notice posted that the repair would be free if less than 7 years or under 84,000 miles which my vehicle is. I have joined a class action law suit regarding Fords knowledge of the problem in 2019 and their lack of a preventive recall.

The vehicle experienced an internal engine failure involving the engine block/long block. The engine had a multi-cylinder misfire, and an independent repair facility inspected the vehicle and found coolant traces in multiple cylinders. The repair facility referenced Ford TSB 22-2133 and recommended replacement of the engine long block to correct the issue. The failed engine is not currently available for inspection because the vehicle was traded in after the repair estimate determined it was not economically feasible to repair. We suffered a big loss The safety concern was the potential for sudden loss of engine power due to the misfire and internal engine failure. A vehicle experiencing severe misfires while driving could have reduced performance, hesitation, or loss of power, creating a safety risk depending on driving conditions. The problem was confirmed by an independent service center. The vehicle was not inspected by Ford, police, or insurance representatives. Prior to failure, the vehicle developed engine symptoms consistent with a misfire. The check engine light/engine misfire condition occurred before diagnosis. The independent service facility confirmed the condition and found coolant traces in multiple cylinders.

The vehicle’s engine malfunctioned while driving. The check-engine light illuminated, the vehicle began running rough when starting, and the engine shut off approximately three times while being driven. An authorized Ford dealer inspected the vehicle and confirmed "Diagnostic code: P0303. Dealer diagnosis: Coolant intrusion into cylinder #3 Dealer cited TSB 22-2322". The unexpected engine shutdown and loss of power while driving created a safety risk because the driver lost the ability to maintain speed and safely maneuver in traffic. The vehicle currently has approximately 78,419 miles. The engine and vehicle are available for inspection upon request. Ford was contacted for goodwill assistance, but assistance was denied under Ford policy.

In 2020, my vehicle experienced a coolant leak, which caused the engine to overheat and fail. I had the motor replaced at a Ford service center. Today, in July 2026, my vehicle is experiencing the same issue. The coolant intrusion caused the motor to fail. The vehicle had been inspected and serviced by the Ford service center in December of 2025 and has had annual service/inspections since I purchased the vehicle in 2016. Both times, my safety and the safety of other drivers were put at risk. This issue comes on suddenly, with no warning, and has occurred each time going 65mph on the interstate. There is a sudden loss of power/sputtering combined with high engine temperature. There was no warning until the issue became critical and the check engine light began to flash.

The engine overheated and went into limp mode while on the busy interstate, we nearly were hit trying to get off the road because we could not keep speed. The car is available for inspection. It has the typical symptoms of the coolant intrusion as acknowledged by Ford in Technical Service Bulletins 19-2139 and 22-2322. These include startup misfires, rapid loss of coolant into the combustion chambers without external leaks, and severe overheating causing the vehicle to enter limp mode. The misfire's are throwing engine codes P0302 (Cylinder 2 Misfire Detected) and P0303 (Cylinder 3 Misfire Detected) This just happened on July 8, 2026 and the car has 105,203 miles.

What component or system failed or malfunctioned, and is it available for inspection upon request? Coolant system coolant is leaking into cylinder #3, causing misfires; head gasket leaking into cylinder. How was your safety or the safety of others put at risk? UNKNOWN Has the problem been reproduced or confirmed by a dealer or independent service center? Confirmed via dealer diagnosis Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Unknown when the underlying problem first occurred.