The contact owns a 2009 Ford Escape. The contact stated while driving 5 MPH, the steering wheel became firm with the check engine warning light illuminated. The contact was able to drive the vehicle to the residence. The vehicle was not diagnosed. The manufacturer was contacted, and the manufacturer stated that the VIN was not i…
Read full complaint
The contact owns a 2009 Ford Escape. The contact stated while driving 5 MPH, the steering wheel became firm with the check engine warning light illuminated. The contact was able to drive the vehicle to the residence. The vehicle was not diagnosed. The manufacturer was contacted, and the manufacturer stated that the VIN was not included in NHTSA Campaign Number: 14V284000 (Steering). The contact was referred to the NHTSA Hotline. The failure mileage was 165,600.
NHTSA ODI #11516929
Mileage unknown · Apr 12, 2023
Steering
My vehicles steering wheel is having problems turning. Its stuck and if I drive it it will definitely cause a crash bc it wont turn. Its very tight and hardly moves.
NHTSA ODI #11516643
Mileage unknown · Apr 9, 2023
Steering
I was driving my 2009 Escape and the steering wheel started shaking back and forth. Then the power assist went out and I is very hard to steer. I took it to a dealer and they said either the sensor was bad ( $1000 ) to replace or the steering column was bad ($2200) to replace, but they could not get the part. They charged me $1…
Read full complaint
I was driving my 2009 Escape and the steering wheel started shaking back and forth. Then the power assist went out and I is very hard to steer. I took it to a dealer and they said either the sensor was bad ( $1000 ) to replace or the steering column was bad ($2200) to replace, but they could not get the part. They charged me $130 to diagnosis the problem which took 10 minutes and they knew the steering assist light being on that was the problem. then they told me they could not get the steering column, on mega back order so they won't know when they would get the part. On top of that, they charged a $15 shop FEE. For what? FORD suck and I will never own one again and I will tell anyone who listens that FORD SUCKS.
NHTSA ODI #11516185
125,000 miles · Mar 29, 2023
Steering
The contact owns a 2009 Ford Escape. The contact stated while driving 50 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact veered to the side of the road. The contact stated that he turned off and restarted the vehicle; however, the failure recurred while driving. The contact…
Read full complaint
The contact owns a 2009 Ford Escape. The contact stated while driving 50 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact veered to the side of the road. The contact stated that he turned off and restarted the vehicle; however, the failure recurred while driving. The contact stated that the failure reoccurred several times while driving, and the vehicle responded as needed after being restarted. The vehicle was taken to the dealer, where it was repaired for power steering failure under an unknown recall; however, the failure reoccurred a year later. The dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 125,000.
NHTSA ODI #11514413
Mileage unknown · Mar 29, 2023
SteeringCrash
In later part of 2021my vehicle's power steering began disengaging and reengaging. It is now parked in my driveway for I am afraid of driving it. Apparently the was a safety recall issued several years ago recognizing this problem and authorizing a software upgrade, new torque sensor or steering column replacement. I took my …
Read full complaint
In later part of 2021my vehicle's power steering began disengaging and reengaging. It is now parked in my driveway for I am afraid of driving it. Apparently the was a safety recall issued several years ago recognizing this problem and authorizing a software upgrade, new torque sensor or steering column replacement. I took my vehicle to the Ford dealer in 2014 under Safety Recall 14S05 and they did a software reprogramming. Obviously, they missed something. Now they tell me ambiguously that the recall is expired or that by reprogramming the software, they are released from further recall liability and that I would have to pay ($2200) for steering column replacement. No
NHTSA ODI #11514411
87,000 miles · Mar 28, 2023
Steering
The contact owns a 2009 Ford Escape. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 14V284000 (Steering) in 2014. The contact stated that several years later while driving at approximately 30 MPH, the steering wheel became difficult to maneuver. The contact stated that no warning lights were illumi…
Read full complaint
The contact owns a 2009 Ford Escape. The contact stated that the vehicle was serviced under NHTSA Campaign Number: 14V284000 (Steering) in 2014. The contact stated that several years later while driving at approximately 30 MPH, the steering wheel became difficult to maneuver. The contact stated that no warning lights were illuminated. The contact stated that the vehicle was taken to an independent mechanic who diagnosed the failure as a malfunctioning power steering control module that was needing replacement. The contact stated that the independent mechanic reprogrammed the power steering module which temporarily repaired the vehicle. The contact stated that the failure returned, and the vehicle was taken to another independent mechanic who diagnosed the failure as a malfunctioning power steering control module. The part was still not replaced as the independent mechanic informed the contact that the part was on backorder. The vehicle was then taken to a Ford dealer where the contact was informed that the part was no longer being manufactured. The manufacturer was notified of the issue and stated that the part was on backorder; however, they would contact the dealer to order the part under a special case. The contact stated that the dealer informed him that the part was a stop sale as the manufacturer was no longer producing the power steering control module. The approximate failure mileage was 87,000. The contact has yet to receive a replacement part of their vehicle and no recall has been issued.
NHTSA ODI #11514212
Mileage unknown · Mar 24, 2023
Steering
The electric power steering system (EPAS) on my 2009 Ford Escape failed. Without the power steering the vehicle is unsafe to drive. It is currently sitting in my driveway undriven since July of 2022. The dealer has ordered new parts, but there is a long wait list because of the number of these failures. I believe there had been…
Read full complaint
The electric power steering system (EPAS) on my 2009 Ford Escape failed. Without the power steering the vehicle is unsafe to drive. It is currently sitting in my driveway undriven since July of 2022. The dealer has ordered new parts, but there is a long wait list because of the number of these failures. I believe there had been a recall issued for this problem but apparently my vehicle and many others were not included. I was told by the dealer’s parts department that there are at least 900 outstanding orders for this part and Ford has issues with their being manufactured. I had to pay the dealer in advance for the parts before he would order them.
NHTSA ODI #11513647
200,000 miles · Mar 22, 2023
Steering
The contact owns a 2009 Ford Escape. The contact stated while driving approximately 50-70 MPH, the vehicle lost power steering functionality. There were no warning lights illuminated. The vehicle was towed to the residence. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The contact stated that th…
Read full complaint
The contact owns a 2009 Ford Escape. The contact stated while driving approximately 50-70 MPH, the vehicle lost power steering functionality. There were no warning lights illuminated. The vehicle was towed to the residence. The local dealer was not contacted. The vehicle was not diagnosed nor repaired. The contact stated that the failure was related to NHTSA Campaign Number: 14V284000 (Steering). The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 200,000.
NHTSA ODI #11513271
Mileage unknown · Mar 17, 2023
Steering
Oh yes my power steering went out without warning without notice took it to the shop put it on a diagnostic machine they said it was the power power steering I called my the dealer here in Owensboro they said that the problem was fixed in 2014 the same exact problem that I'm having now so obviously there is a history of this saf…
Read full complaint
Oh yes my power steering went out without warning without notice took it to the shop put it on a diagnostic machine they said it was the power power steering I called my the dealer here in Owensboro they said that the problem was fixed in 2014 the same exact problem that I'm having now so obviously there is a history of this safety matter so it's going to be so is there going to be another recall on it or how we going to solve this problem you.
NHTSA ODI #11512486
168,054 miles · Mar 14, 2023
Steering
The contact's aunt owns a 2009 Ford Escape. The contact stated while his aunt was driving 35-40 MPH, the vehicle lost power steering functionality inadvertently. The message "Steering Torque Sensor Failure" was displayed. The contact's aunt was able to veer to the side of the road. The vehicle was towed to the residence. The veh…
Read full complaint
The contact's aunt owns a 2009 Ford Escape. The contact stated while his aunt was driving 35-40 MPH, the vehicle lost power steering functionality inadvertently. The message "Steering Torque Sensor Failure" was displayed. The contact's aunt was able to veer to the side of the road. The vehicle was towed to the residence. The vehicle was then taken to the nearby dealer, where it was diagnosed that the torque sensor needed to be replaced and that the failure was related to the NHTSA Campaign Number: 14V284000 (Steering); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle could not be repaired under the recall as the VIN was not included. The manufacturer referred the contact to the NHTSA Hotline. The failure mileage was approximately 168,054.
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration