This year and model is under a Ford Motor company recall number 14S05 which is the steering torque sensor. this device when failing will cause the power steering to go out and make it almost impossible to steer. Which obviously can cause a major accident. I have called Ford Motor company as well as the local dealerships and they…
Read full complaint
This year and model is under a Ford Motor company recall number 14S05 which is the steering torque sensor. this device when failing will cause the power steering to go out and make it almost impossible to steer. Which obviously can cause a major accident. I have called Ford Motor company as well as the local dealerships and they both stated that this is a specific VIN number eligibility recall. The issue is whether or not my 2009 Ford escape made the list is irrelevant because that is exactly what the vehicle is doing and should be serviced at Ford motor company's expense. Please advise how I can get this resolved.
NHTSA ODI #11589947
Mileage unknown · May 2, 2024
Steering
The steering went out on my daughters car. When calling the dealership to find out about a possible recall as I see it's a known issue, we were told there is no recall for this car. (...same car, same year has recalled many of these for this issue, why not this one?) When taking to a mechanic were quoted that a new steering c…
Read full complaint
The steering went out on my daughters car. When calling the dealership to find out about a possible recall as I see it's a known issue, we were told there is no recall for this car. (...same car, same year has recalled many of these for this issue, why not this one?) When taking to a mechanic were quoted that a new steering column was needed, although it would have to be a salvaged part which is not safe to put another defective refurbished steering assembly especially at the quoted cost of 3k.
NHTSA ODI #11586596
Mileage unknown · Apr 30, 2024
Steering
When my daughter was driving, she experienced complete loss of steering assist when trying to make a turn. It is still happened with no warnings at all. reference recall # 14S05 we purchased this vehicle used with only 3,322 miles on it just a few years ago and thought that it had No recall issues, but after further research…
Read full complaint
When my daughter was driving, she experienced complete loss of steering assist when trying to make a turn. It is still happened with no warnings at all. reference recall # 14S05 we purchased this vehicle used with only 3,322 miles on it just a few years ago and thought that it had No recall issues, but after further research it looks like the vehicle was taken to Apple Ford around 04/12/21 or 04/27/21. Looks like they cleared the recall from records, but did not address the issue. it only had about 3,322 miles on it when it was reviewed in year 2021. After the complete loss of steering assist. I took the vehicle to Lexington Park Ford on 02/09/2024, they told me it had no recalls, after further research they told me the recall was closed back on 04/2021, they wanted to charge us to fix the same thing that the recall is for and it was never properly address. we did not have it fixed, the steering assist fails at random times and makes this vehicle very unsafe to drive.
NHTSA ODI #11586076
Mileage unknown · Apr 16, 2024
Air BagsService BrakesSteering
My power steering just went out a sensor, a recall i have read.My ABS just went to the floor for no reason, a part that was not made, also a recall I have read. My ignition is faulty, put another in but it isn't fixed. I have a button to start it. Mechanic fixed this contraception up. Air bags faulty passenger side.The car tell…
Read full complaint
My power steering just went out a sensor, a recall i have read.My ABS just went to the floor for no reason, a part that was not made, also a recall I have read. My ignition is faulty, put another in but it isn't fixed. I have a button to start it. Mechanic fixed this contraception up. Air bags faulty passenger side.The car tells me to check it. All of these are recalls on the 2009 Ford Escape xlt, but they say no recalls. I wanted to get this all fixed. But it looks like this may be my death car. I am not of very much income fixed income so I can't afford to take to dealership to fix. But I have had certified mechanic look at it. I think it's terrible Ford doesn't acknowledge this and send me to a dealership it 80 miles from me. But they would tag this a "Lemon" and it is dangerous for my safety and others on the roads if everything goes out completely. I will be dead. I have 74,000 original miles on this Ford Escape. Not many miles for the troubles I have and am experiencing. Thanks for letting me share my opinion and maybe something can be done about this.
NHTSA ODI #11583422
Mileage unknown · Apr 1, 2024
Steering
The car started moving the steering wheel back and forth on its own and then completely lost power steering.
NHTSA ODI #11580363
Mileage unknown · Mar 31, 2024
Steering
Back in 2018 I had another incident which was when I was driving down the highway and had to make a turn I had no power steering and almost hit a police car. My car should be included with a recall I read about. That repair cost me $700. Since 2023 when I start my car I won't have any power steering. The Ford dealership is tell…
Read full complaint
Back in 2018 I had another incident which was when I was driving down the highway and had to make a turn I had no power steering and almost hit a police car. My car should be included with a recall I read about. That repair cost me $700. Since 2023 when I start my car I won't have any power steering. The Ford dealership is telling me it is another censor and will cost me $2,500. This is a dangerous thing.
NHTSA ODI #11580337
Mileage unknown · Mar 26, 2024
Air BagsService BrakesSteeringCrashInjury
Unknown. Steering and brakes locked so i lost all control of the vehicle doing about 60 mph down the highway. Which resulted in being drove off the side of the highway through a fence hitting 2 trees before rolling twice. The airbags never deployed and both my passenger and i were taken to the hospital by ambulance. They sustai…
Read full complaint
Unknown. Steering and brakes locked so i lost all control of the vehicle doing about 60 mph down the highway. Which resulted in being drove off the side of the highway through a fence hitting 2 trees before rolling twice. The airbags never deployed and both my passenger and i were taken to the hospital by ambulance. They sustained deep bruising and i suffered a closed wedge compression fracture of the L2 Vertebrae and some lacerations
NHTSA ODI #11579592
190,000 miles · Mar 20, 2024
Power TrainSteering
The contact owns a 2009 Ford Escape. The contact stated that on several occasions while driving at various speeds, the power train warning light illuminated randomly but disappeared. Additionally, the contact stated that on several occasions when the vehicle was started, the steering wheel became stiff and was difficult to turn.…
Read full complaint
The contact owns a 2009 Ford Escape. The contact stated that on several occasions while driving at various speeds, the power train warning light illuminated randomly but disappeared. Additionally, the contact stated that on several occasions when the vehicle was started, the steering wheel became stiff and was difficult to turn. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 190,000.
NHTSA ODI #11578544
Mileage unknown · Mar 18, 2024
Electrical SystemSteering
I was driving to work when all the sudden out of nowhere with no warning I lost all power steering control luckily I just got off the highway and wasn’t going too terribly fast though it scared the crap outta me and this could have ended very badly! I was unable to turn my wheel at all!!! On my dashboard it says POWER STEERING …
Read full complaint
I was driving to work when all the sudden out of nowhere with no warning I lost all power steering control luckily I just got off the highway and wasn’t going too terribly fast though it scared the crap outta me and this could have ended very badly! I was unable to turn my wheel at all!!! On my dashboard it says POWER STEERING ASSIST FAULT after researching this I came across a recall for 2008-2014 Ford Escapes for what exactly happened to me on my
NHTSA ODI #11578172
148,000 miles · Mar 12, 2024
Steering
The contact owns a 2009 Ford Escape. The contact stated while starting the vehicle, the vehicle was without power steering functionality. There were no warning lights illuminated. The vehicle was not taken to the dealer but was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotli…
Read full complaint
The contact owns a 2009 Ford Escape. The contact stated while starting the vehicle, the vehicle was without power steering functionality. There were no warning lights illuminated. The vehicle was not taken to the dealer but was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 148,000.
Ford Motor Company (Ford) is recalling certain model year 2008-2011 Ford Escape and Mercury Mariner vehicles manufactured August 18, 2006, through September 11, 2010. The affected vehicles have a steering torque sensor that may not be able to properly detect driver steering input. As a result, the system could remove the Electric Power Steering (EPS) assist.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will update the software for the power steering control module (PSCM) and the instrument cluster module, free of charge. If a vehicle shows a history of a loss of the torque sensor signal or fault codes relating to the PSCM when the vehicle is brought in for the recall remedy, the affected components will be replaced, free of charge. The recall began on July 18, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S05.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP15001 · Loss Of Power Steering While Driving
Opened Apr 1, 2015 · Closed Jun 14, 2018
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On May 27, 2014, amended June 2, 2014, Ford Motor Company (Ford) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist while driving in approximately 746,067 model year (MY) 2008 through 2011 Ford Escape vehicles equipped with electric power assisted steering (NHTSA 14V-284, Ford 14S05). Ford's DIR described the defect condition as a poor signal to noise ratio [SNR] in the torque sensor within the Electric Power Assisted Steering (EPAS) system [which] does not allow the PSCM to determine the driver's steering input. When the system detects this fault condition, it transitions the EPAS system to the fail-safe/manual steering mode.Ford's DIR indicates that loss of power steering assist while driving would require higher steering effort at lower vehicle speeds, which may result in an increased risk of a crash.Ford's remedy instructs dealers to check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTCs) to determine the proper repair procedure. If no DTCs are present, dealers are to update the PSCM and instrument cluster module software. The updated PSCM software changes the torque sensor fault strategy so that the SNR condition does not result in a loss of power steering assist while driving.In addition, audible and visual warnings are provided for torque sensor faults.If DTCs indicating faults in the torque sensor, PSCM or Power Steering Motor (motor) are present in the initial recall inspection, the dealer performs the following repairs: 1) replaces the torque sensor for torque sensor faults (DTC B2278); or 2) replaces the steering column for faults related to the PSCM (DTC B1342) or motor (DTC B2277).Continued in attachment pages
PE13003 · Electronic Throttle Body Malfunction
Opened Feb 21, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Engine
On February 21, 2013, the Office of Defects Investigations (ODI) opened Preliminary Evaluation PE13-003 to investigate allegations of electronic throttle body (ETB) failures resulting in sudden reduction of engine power in model year (MY) 2009-2013 Ford Escape, Fusion, Mariner and Milan vehicles. During this investigation, Ford identified a condition in subject vehicles equipped with 2.5L and 3.0L engines that may result in a sudden reduction of engine power.According to Ford, the ETB internal motor contacts may develop a high resistance material buildup condition on the commutator, resulting in intermittent electrical connectivity and reduced engine power. When this condition occurs, the Malfunction Indicator Lamp (MIL) or Wrench light will illuminate and the vehicle may enter a limited limp home mode.Ford?s trade name for the feature is Failure Mode Effects Management (FMEM) mode.In this mode, engine power and vehicle speed are reduced, while full function of the power steering, power braking, lighting, and climate control systems are maintained.ODI?s complaint analysis indicate that the predominant failure mode involved reduced motive power associated with the limited limp home mode with engine speeds limited to approximately 900 RPM. Analysis of warranty claims provided by Ford identified 59,807 claims related to ETB replacements and approximately 50 percent of claims are associated with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed.Ford described several factors where the ETB motor may fail resulting in DTCs P2111 or P2112 but the failure is not an existing stuck open or closed ETB valve position.According to Ford, the ETB control strategy provides the driver with three FMEM modes that allow varying degrees of vehicle mobility depending on the severity of the fault detected.DTCs associated with stuck open or closed throttle valves are designated the highest failure severity resulting in engine speeds limited to high idle corresponding to the limited limp home mode.Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability.Other FMEM limp modes may result in reduced engine performance but will maintain vehicle speed above 20mph. During this investigation, Ford and its suppliers, Delphi and Igarashi, updated the powertrain control module (PCM) software to include a throttle body motor cleaning cycle during key-on and modified the ETB internal motor components design, surface finish and material composition to improve durability. Additionally, Ford developed a remedy procedure and issued a special Customer Satisfaction Program (CSP) 13N03 extending the ETB warranty coverage and instructing dealers to update the powertrain calibration to improve vehicle performance in the event that intermittent electrical connectivity of the throttle body motor contacts occurs. The program extends the coverage for up to 10 years of service or 150,000 miles from the warranty start date of the vehicle, all vehicles are eligible for the program through January 31, 2015 regardless of mileage.Owners of the affected vehicles will be contacted by mail to take their vehicle to a Ford dealer who will reprogram the PCM to the latest calibration. The bulletin was sent to dealers on January 17, 2014 and the owner letter mailing began on January 27, 2014. See the investigative file for copies of Ford's bulletin and owner letter. This preliminary evaluation is closed. The closing of this investigation does not constitute a finding that
DP12006 · Electronic Throttle Body Malfunction
Opened Oct 2, 2012 · Closed Feb 21, 2013
Status: closed (inferred from source dates) · Engine
In a letter dated August 30, 2012, The North Carolina Consumers Council (NCCC) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged electronic throttle body failures resulting in engine stall or surge while driving in model year (MY) 2005 through 2012 Ford Escape vehicles. On October 2, 2012 the Office of Defects Investigation (ODI) opened a Defect Petition DP12-006 to evaluate whether to grant or deny the petition. The petition is hereby granted on certain model years. The NCCC letter cites two complaints of stall while driving in MY 2009 Ford Escape vehicles that were diagnosed as failed throttle bodies with diagnostic trouble codes (DTC) P2111, Throttle Body Stuck Open, and P2112, Throttle Body Stuck Closed. The petitioner indicates that the owners of both vehicles reported experiencing repeated incidents of stalling and engine surging. According to Ford, Escape non-hybrid vehicles are equipped with Electronic Throttle Body (ETB) assemblies beginning with MY 2009. Vehicles manufactured between June 22, 2009 and October 15, 2009 may contain contaminated printed circuit boards (PCB) with plating variations. Plating variations could lead to a lack of continuity in the throttle position sensor circuit where P2111 and/or other DTCs would be generated and stored. Ford and its electronic throttle body supplier, Delphi, modified the PCB manufacturing process and issued a technical service bulletin (TSB) 09-23-5. Vehicles produced after October 15, 2009 incorporated ETBs manufactured with a PCB process that resolved this condition. ODI's analysis identified a total of 123 unique reports indicating allegations of reduced motive power or vehicle stall. Depending on the condition of throttle control system malfunction, a driver may experience varying levels of reduced engine performance associated with three limp home modes. In two limp modes, reduced engine performance may maintain vehicle speeds above 20mph while the third is a limited limp home mode with engine speeds limited to approximately 900 RPM. Allegations of stall appear to be related to the limited limp home mode. Vehicles are not likely to unexpectedly stall as a result of this condition, but drivers may characterize the reduced functionality as a stall, even though their vehicle may still has motive capability. Allegations of vehicle surge appear to be related to limp home mode operation. Complaints alleging surge are most likely related to engine RPM fluctuations at low vehicle speeds or idle as the control system engages to prevent engine stall. In limited limp mode, rough-idle conditions may exist while the control system attempts to modulate engine RPMs once the vehicle reaches a reduced speed to maintain approximately 900 RPM. Separately, ODI received 59 complaints alleging incidents of engine stall while driving in model year (MY) 2010-2011 Ford Fusion vehicles. Approximately 60 percent (36) of the incidents occurred at speeds of 40 miles per hour or more. Eighty percent of complaints (47) were received beginning March 2012 and 14 complaints reported that the throttle body was replaced or DTCs associated with limp home modes. Additionally, Ford issued TSB 10-21-6 addressing DTCs associated with idle speed drops and limited limp home mode. The petition is granted on certain model years.Preliminary Evaluation PE13-003 has been opened to assess the scope, frequency and potential safety consequences associated with the alleged defect.See full copy of the closing resume for this defect petition for list of the VOQs associated with the defect petition analysis.
Illustration