2018 Ford Edge

I'm [XXX] and I brought my Ford Edge to Lucas ford on Columbus Road in Burlington, NJ 08016 for Lube and a Tire Rotation. After an hour they said the Ford Edges wheel lugs were swollen and could not be removed under normal conditions. They wanted $300.00 to replace nuts, and with the same ones from FORD. I thought this was a scam and did not have the car dealer replace them. I researched the problem and found it was true and that FORD could care less about it. I tried to remove one nut at home and spent two hours on it and could not remove it. FORD should replace all there defective parts now. As i said I'm [XXX] and if i have a tire blow out on the road, how do remove iot and install the spare? How about a recall on the wheel lug nuts!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact stated that the check engine warning light was intermittently illuminated. The contact stated that while driving at an undisclosed speed, the vehicle started to overheat. Several unknown warning lights were illuminated. The contact stated that coolant was added to the coolant reservoir. The vehicle was taken to an intendent mechanic where it was diagnosed that the head gasket needed to be replaced. The vehicle was then taken to the dealer where it was diagnosed that the head gasket needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 47,000.

June 2023 the coolant started disappearing from the coolant tank. The vehicle was checked by a licensed mechanic and the coolant is leaking into the engine cylinders only. Nowhere else is it leaking. By it leaking into the cylinders, it is causing the car to misfire, This will lead to a car fire or a seized engine. The vehicle is unsafe to drive, therefore is parked. Ford should have recalled this turbo engine but has failed to do so or do anything about it. There are thousands of people with this problem, 3 in my community, several lawsuits around the USA. I need transportation for my family and to get to work.

Ford dealer verified an independent auto repair shop diagnostic conclusion of coolant intrusion in cylinder 1. Ford has issues TSP 22-2229 regarding same issue with an open campaign. The vehicle exhibits low coolant level, white exhaust smoke and runs rough with an illuminated check engine light. The dealer confirmed it is "206" diagnostic condition code. At normal engine operating temperature, the cooling system was set to 20 PSI for 5 hours and the pressure dropped more than 4 PSI. Per the dealer, a customer case number was opened with Ford. Vehicle age: 5 years, 10 months. Mileage 39,536. Ford Customer Care offered to cover 40% off the repair cost. Offer was accepted. Dealer noted the following repairs: Removed the spark plugs, used a borescope and found coolant has entered the cylinders. Removed then engine and replaced the long block assembly using all of the approved ford gasket removers, parts cleaners, shampoo and metal surface prep wipes to clean all related mating surfaces per the workshop service manual. Also replaced all other related seals, gaskets and non-reusable hardware and re-installed all components removed for repairs in the reverse order of removal and referring to TSB 22-2229. Vacuum filled colling system and filled engine with oil. Hooked up IDS and cleared all DTCS verifying they didn't come back. Cleared KAM valves of the PCM, and ran a misfire monitor profile correction relearn. Road tested the vehicle 20 miles to verify repairs. The system is now operating normally at this time." Also, the "tech found car to have original battery and negative terminal was seized to negative post. Removed and replaced battery. Performed a BMS reset. Road test vehicle. All systems okay at this time." I attempted to upload the repair invoices and it would not allow me to do so. I had to delete the pdfs in order to proceed. I can provide this information upon request.

In July 2023, I had to refill my anti freeze just one week after service. My dash lit up regarding the problem. Today, October 2023, same situation. Both situations required about 36 oz of antifreeze. In checking online I noticed this reference number indicating numerous problems like this in 2016-2018 Ford Edge. [XXX] In contacting Ron at Ford Motor Co ([XXX] ), he stated that Ford has no recall for this situation. He referred me to you. Any info on what I can do. Thanks [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

engine malfunction, loose engine power. It will fail to accelerate some times. It has been ispected by the ford dealership and the problem has been confirmed by them. Check engine on. Ford Motor company has a recall on the ford edge 2015-2018. Attached you will find the TSB # 19-2208 from ford in which describe the issues for the recall. Even though my car is showing the exact same malfunction, ford is telling me that my specific vin # is not on the recall and that I need to replace the engine for $ 6,000.00. What I do not understand is how if the vehicle has the same malfunction as the recall and it has been confirmed by Ford that its the same safety issue my vehicle will not be included in the recall. I'm writing NHTS as recomended by ford to see if someone can help me with this issue.

The contact owns a 2018 Ford Edge. The contact stated that the check engine warning light illuminated on the instrument panel. An ODB scanner retrieved the code for a misfire in cylinder #3. Upon investigation, the contact discovered that coolant intrusion into the engine cylinder was a common failure for similar model vehicles. The manufacturer was notified of the failure and informed the contact that there were no recalls on the vehicle. The contact was provided a case number and the contact was referred to a dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 96,500.

Eco boost engine is less than four years old and coolant leaked into engine. This should never happen on a four year old vehicle. Ford put out a “bulletin” on this, not a recall, but never informed me of it directly. When we contacted Ford told us we were out of luck. Cost me 7k to fix. Internet says this is happening way more often than it should be. My mechanic told me this should only happen to vehicles with hundreds of thousands of miles. He was as stunned as we were. This could have killed me. I’m fortunate that I decided to have it looked at. The cost was significant, but my life is worth more. A recall should be triggered. Ford knows it, lawyers know it, the Feds should know it too.

I have a 2018 Ford Edge SEL with a 2.0 L engine and 63,550 miles. The EcoBoost engine has coolant intrusion into the cylinders due to a design flaw in the engine where the head gasket fails. Ford has a TSB bulletin (TSB 19-2346) they sent out that requires a new engine replacement for this issue. This issue has been present in 2015-2018 Ford edge and occurs usually when the warranty expires. This relates to safety in that the engine can fail or catch fire. I took it in to a Ford dealer and they said I would need an engine replacement costing $8,100. My car has not been inspected by the manufacturer but I called them and was told that they had no program available to help me. I did contact the dealer I purchased the use car from and they said they couldn't do anything to help me. The MIL (check engine light) came on 2 weeks after I purchased the car from the dealer and when I checked under the hood I found the coolant reservoir empty. I now have payments on a car that needs an engine replacement for $8,100.

The check engine light came on. The warning was a cylinder 2 misfire. The fix is an engine replacement. I called Ford. They acknowledged a coolant leakage problem. They said there was no recall but would offer "assistance". I was told to limit driving until repair as the engine will stall at any time. This problem happened shy of 68,000 miles (shortly after warranty expiration).