2018 Ford Edge

The contact owns a 2018 Ford Edge. The contact stated while opening the front driver’s side door, there was a squeaking sound and the contact had to hold the door to keep if from bending towards the front of the vehicle. No warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the door needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 78,000.

Summary: Some 2015-2018 Edge equipped with a 2.0L EcoBoost due to coolant intrusion into engine which could cause the potential for engine fires and failure, misfires, collision risk, and costly repairs. Vehicle did not exhibit a low coolant level, white exhaust smoke did not run rough. Automaker knew about the Ford EcoBoost engine defect since 2010 based on pre-production testing and complaints made by consumers to the NHSTA but didn’t address the cause of the problem. Now I have to pay $10,000 parts and labor!!! Called Ford Customer Service. No assistance unless a recall is sent.

The contact owns a 2018 Ford Edge. The contact stated while driving 30 MPH, the vehicle stalled while approaching a stop light. The vehicle continued to stall when it came to a stop. Several unknown warning lights were illuminated. There was an abnormal fuel odor was detected on the interior of the vehicle. A message that the accessories were available was displayed. The vehicle was taken to an independent mechanic, who checked the battery. The contact called the local dealer, who informed the contact about scheduling an appointment. The vehicle was not diagnosed or repaired. The contact called the manufacturer and was referred to the NHTSA Hotline. The failure mileage was approximately 53,000.

Check engine light will appear. Vehicle is blowing number two cylinder along with spark plug every two weeks. It is going through large amounts of antifreeze. Drives as if it is bogged down and shifts very hard and loud. While driving is shakes from front end. I have brought vehicle to a master mechanic and has started that the head gasket will eventually break or could catch fire. This is a on going issue at this time.

The contact's son owns a 2018 Ford Edge. The contact stated while her son was driving at an undisclosed speed, the low coolant warning light illuminated. The contact's son drove the vehicle to his residence and parked the vehicle. The next day, the contact’s son attempted to start the vehicle however, the vehicle failed to start. The vehicle was towed to the dealer where it was diagnosed with a failed engine and that the engine needed to be replaced. The contact was informed that the engine failure was due to coolant leaking into the cylinders. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 77,000.

My car began running rough and a check engine light came on. I took it to a reputable repair shop and the car presented a code indicating a problem with cylinder #4, so they proceeded with a routine tune up. The problem (rough idle and check engine light), then the heater quit working then without any warning the engine coolant temperature warning light came on. The shop examined the car to discover coolant was leaking into the cylinders. This problem is a known defect apparently, known not by me, but by the Ford Motor Co who sold this car with an engine they knew was defective and did not ever warn me. I am grateful the light came on while I was in the city and not out on an isolated highway somewhere without cell service. This is a very dangerous situation. My engine cannot be repaired it has to be replaced! There was no cracked manifold, no blown motor, just this leakage that is the result of a serious design flaw, so serious that Ford quit manufacturing the engine and replaced it with a Series 2 version (it is an ecoboost engine) and my new engine will be the Series 2. I can't even buy the original engine as it has been pulled from the market. But my car was sold new to me in August, 2018 with this flawed engine. I am including pictures the mechanic has taken of the coolant in the engine. The mechanic would not allow me to pick up my car and drive it after discovering this issue as he said it was a safety issue and could lead to my or other driver's injury or fatality. That's pretty serious. the engine replacement is going to cost me $8700 plus the cost of the previous repairs and a rental car for a week while the car is repaired. That is a lot of money for a widow.

The contact owns a 2018 Ford Edge. The contact stated while operating the vehicle, the check engine warning light remained illuminated, and the vehicle was vibrating abnormally. The vehicle was taken to the local dealer who diagnosed that coolant was discovered in cylinder #1, causing a crack in the engine long block. The contact was informed that the engine needed to be replaced. Additionally, the transmission pressure plate had failed causing the vehicle to vibrate. The vehicle was not repaired. The failure mileage was 98,000.

The contact owns a 2018 Ford Edge. The contact stated while driving 45–50 MPH, the check engine warning light illuminated. While starting the vehicle, the check engine warning light illuminated, and the wrench symbol was displayed. While driving at an undisclosed speed, the vehicle was shaking and slow to accelerate. The vehicle was taken to the local dealer, where it was diagnosed that a torque replacement was needed. The vehicle was not repaired. The manufacturer was contacted and referred to the NHTSA Hotline, but no assistance was provided. The contact stated that the failure was related to NHTSA Campaign Number: 18V390000 (Power Train). The failure mileage was approximately 126,000.