2018 Ford Edge

The contact owns a 2018 Ford Edge. The contact stated that the vehicle had experienced rough starts and the check engine warning light remained illuminated. The vehicle was taken to the local mechanic who discovered coolant inside the cylinders and informed the contact that the engine long block needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 48,000.

The contact owns a 2018 Ford Edge. The contact stated while driving 35 MPH, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who determined that coolant was leaking into the engine. The mechanic recommended that the engine be replaced. The contact called the local dealer and was referred to the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 97,000.

Recently, I had to replace the engine on my 2018 Ford Edge with only 73k miles on it. I spoke to an agent on July 10th with Case #: [XXX]. The total engine replacement cost was $7,700. Ford only covered $3,000, leaving me with the remaining balance of $4,700. I first noticed my check engine light was on in July, so I took it to the dealership (Tony Betten Ford, Grand Rapids, MI) to find out the engine block was cracked and needed to be replaced. The powertrain warranty only covers 5 years or 60k miles, and my vehicle is 6 years old with just over 73k miles, so it did not qualify. I should not have to replace an entire engine at this mileage, especially since other automakers' warranties are upwards of 100k miles. I've taken good care of this vehicle and bought it brand new (in 2018) and would expect better of a Ford Vehicle. Coincidentally, my brother also owns a 2018 Ford Edge. He had the EXACT SAME issue with his Edge around the same mileage (70k miles) and had to replace his engine too- This is clearly a known issue on these vehicles. Also, this is a current recall and known issue on 1.5L engine, so it's clearly an issue on 2L engine too. For the safety of all 2L engine owners, this should absolutely be a full recall. I've been a lifelong Ford vehicle owner and driver and I would hope the customer service from Ford would be to treat this as a recall and take care of this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2018 Ford Edge. The contact stated that while his wife was driving at unknown speeds, the engine warning light illuminated. The driver checked the oil and noticed a milky substance in the oil. The vehicle was taken to an independent mechanic, who determined that the head gasket was blown. The vehicle was repaired, but the failure recurred. The vehicle was taken to the local dealer, who diagnosed it using a microscopic camera and determined that there was a notch in the base of the engine that caused the failure. The mechanic recommended that the engine be replaced. The manufacturer was contacted, and informed the contact that there was no warranty coverage on the vehicle for the failure. The failure mileage was approximately 50,000.

The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed and making a right turn, the vehicle lost motive power and the steering wheel locked. The traction control warning light was illuminated, and the message "No Hill Start Assist" was displayed. The vehicle was taken to an independent mechanic, where it was diagnosed that the rack and pinion system had failed and needed to be replaced. The contact stated that the rack and pinion was previously replaced; however, the failure persisted. The vehicle was not repaired. No further information was provided. The manufacturer was not made of the failure. The failure mileage was approximately 116,000.

The vehicle started giving red overheating signals to the dash. I put in coolant. A week later it happened again and the car would only go 5 MPH. I called a mechanic and was told that this EcoBoost 2.0L was defective and that is was very common for the head gaskets to fail and poor coolant into the block. I had the vehicle towed to this mechanic and he confirmed the engine needed to be replaced. He quoted repairs at $8,000. I called FORD Motor Co direct and they told me in order to get help with repairs I had to take it to a FORD Dealer and get it evaluated. I had it towed once again to the local Dealership. They evaluated the vehicle and stated that the engine and turbo were both defective and it would be $9,000 to repair. They told me that this vehicle would definitely catch on fire if I had driven it after the failure. FORD is now denying any help with repairs and told me good luck. This is a safety hazard to my life and wellbeing and I feel FORD is negligant.

The contact owns a 2018 Ford Edge. The contact stated that while attempting to start the vehicle, the vehicle would shake and fail to turn over before starting. The check engine warning light would occasionally illuminate. The vehicle was taken to a local independent mechanic where it was diagnosed that coolant had leaked into the engine block. The vehicle was then taken to a local dealer where it was diagnosed with an error code: P0302 (cylinder #2 misfire) engine coolant leak and the engine needed to be replaced. The vehicle was left at the local dealer for further repairs and was not repaired due to cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 40,000.

The contact owns a 2018 Ford Edge. The contact stated that while parked, the check engine warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed that coolant had leaked into the engine block and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The contact referenced Technical Service Bulletin 19-2346 as a probable cause for failure. The approximate failure mileage was 39,493.