2018 Ford Edge

When approaching a stop, the vehicle vibrates heavily as if it is trying to fight the brakes to continue moving and avoid downshifting. The wrench light on my dash came on, so I took it into the dealer to have the problem evaluated. The torque converter has failed on my Edge, according to the dealership evaluation. They also indicated that this could lead to complete failure of the transmission, inability to drive the vehicle and loss of power train control. The shop was able to verify the issue and confirm that it won't go away. There is no noted recall for bad torque converter according to Ford, but the service manager informed me that this is the most common issue with the Edge platform and it is expensive (between $5-10k). I contacted customer relations and ford says there is no issue with the platform and all vehicle repairs are the responsibility of the owner. I have independently reviewed documents regarding customer complaints and discussed the issue with Ford technicians and they confirm that Ford knows there is a problem and doesn't want to address it as a recall. Independent repair shops have refused to repair this transmission issue on the premise that it is a known issue that there is no resolution for and they do not want to have any responsibility over repairing a flawed powertrain and risk famage to their reputations, causing a disparate impact to the consumer. This needs to be addressed and remedied by Ford, especially since this is not an isolated issue, but platform wide.

The problem began in early August 2025 when the check engine light came on and the vehicle misfired. A Ford mobile technician inspected it before 8/23/25, confirmed Diagnostic Code P0303 (Cylinder 3 Misfire), but said it was likely just a bad ignition coil. Based on that, I went to Midas on 8/23/25 for a tune-up and coil check. On 9/29/25, the check engine light returned and for the first time the coolant over-temperature warning illuminated. Midas confirmed coolant intrusion into Cylinder 3: borescope and pressure test showed leakage, leak-down test failed with air entering the coolant reservoir, and visible coolant loss was present. At 80,445 miles, the engine was deemed unsafe and required full replacement. Hawk Ford confirmed no warranty extensions or programs applied. The repair cost was $10,500 out of pocket. This defect matches Ford TSB [XXX] , is widely reported in EcoBoost engines, and creates a serious safety risk since the vehicle misfires, overheats, and may stall while driving. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2018 Ford Edge (VIN [XXX] ) suffered a premature transmission failure at 105,415 miles. Just 389 miles earlier, Ford performed Customer Satisfaction Program 22N12 (flexplate/torque converter/pump replacement), for which I paid $1,669 as my 50% share. Less than two months later, the same dealer diagnosed the transmission as failed due to the forward clutch being stuck and quoted $6,955 for replacement. Ford’s maintenance schedule does not require transmission service until 150,000 miles, so this failure is premature and unreasonable. A transmission failure at highway speed could cause sudden loss of power, greatly increasing the risk of a crash. This issue appears related to Ford’s known flexplate defect (CSP 22N12) and raises concern of broader transmission reliability/safety problems in affected vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I’m having an issue where there’s a sudden loss of all power while driving at highway speeds, forcing me to slowly move to a safe spot while trying not to get hit by other cars. Once I’m safely stopped, I have to turn the vehicle off and back on, and then the power is restored—but the problem can randomly happen anytime at speeds over 65–70 mph. No codes are showing. A repair shop couldn’t find the issue, and even the dealership says everything is fine and just tells me to keep driving it. Sometimes it happens twice in one day, and other times I won’t see it for a week.

The car has been having a chemical smell when it starts. I recently was driving from San Antonio, Texas to Austin, Texas and received a warning that my car was overheating. The warning went off immediately and I continued driving it. A few days later, I got an oil change and was told that I had no coolant in the vehicle. They filled the coolant for me. I continued driving the car. This week, the car was shaking pretty violently when I turned on the ignition. I proceeded to drive it and it drove normally. The following day, a check engine light came on. I took it in to see a mechanic that day and they confirmed that I had a coolant intrusion problem caused by the 2.0L Eco boost engine which is defective and allows coolant to escape into the engine injectors. Ford is not taking any responsibility for this and says that it is not under warranty so there's no programs they can offer me. Ford should issue a recall of this defective product to avoid injuries or accidents.

The contact owns a 2018 Ford Edge. The contact stated that at start-up, there was an abnormal rattling sound coming from the engine. There was no warning light illuminated. The vehicle was taken to a local dealer, where it was diagnosed, and the contact was informed that the flex plate, flywheel, and transmission pump were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 140,000.

The contact owns a 2018 Ford Edge. The contact stated that while driving at an undisclosed speed, the ABS, the Advance Trac, the Hill Start Assist, and the Powertrain warning lights were illuminated. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000.