2018 Ford Edge

Car went into limp mode and over temp light came on. Coolant reservoir empty. Research led to TSB 19-2346. Prior to this CEL was coming on and off and throwing code P0301 errors. Replaced plugs and coil packs at the suggestion of the dealer but made no different. Started out with rough idle but smoothed out after about 30 seconds. Dealer diagnosed issue and quoted $6,900.00 plus tax to install new long block. Safety concern is the engine started to overheat. Fortuantely we stopped before anything serious happened, but found several reports online of this causing engine fire and destroying the car.

coolant is leaking into the cylinders and causing misfires and shuttering of the car, the engine temperature spikes and warnings go off. this is happening in my 2.0L engine. this is the same problem as the 1.5L engine problem that Ford has recalled, but Ford is refusing to recall the 2.0L engine with the same issue. Ford has required me to replace the engine at my expense and now a few months later it is exhibiting the same problem and it is back at the Ford dealer and there is no promise date for putting in engine #3. I am left still paying on the loan for the car and I have no car and don't know when I will get it back. Ford is not offering a loaner/rental vehicle while they are holding my vehicle for repairs. Ford said they would not provide a good trade-in value because of the known issues. I can't sell it on the open market because of the known maintenance issues with Ford vehicles in general, but specifically Ford Edge. Ford's handling of this situation is as bad or perhaps worse than the problem itself.

- A certified Ford technician informed me there is a crack in the engine cylinder block, and coolant is leaking through to the pistons. One or more pistons is full of coolant and shakes the car when starting up, and has caused downstream issues with exhaust, catalytic converters, spark plugs, and O2 sensors. This resulted in the engine running too hot and welding the spark plugs to the engine. The dealer quoted me $8,400 just to replace the engine and said other components may be damaged and additional costs would likely be incurred. The vehicle along with all affected components is available for inspection upon request. - This issue put myself and another at risk while on the highway, I was forced to pull to the side of the road abruptly in fear of continued driving making the issue worse. - This issue has indeed been confirmed by a Ford dealer, who cited this as a common issue they see. - After contacting the manufacturer (Ford), they refused to offer any additional inspection, financial assistance, or anything else to further investigate or remedy this issue. The police and insurance representatives are not involved at this time. - A check engine light relating to bad O2 sensors appeared a year ago, but went away. The high engine coolant temperature warning sound & message appeared a week or so ago, which prompted me to take it in to get serviced immediately.

Check engine light went on. Code was P0302/07E8 pd - Cylinder 2 misfire. After changing spark plugs - multiple times - and changing out the ignition coil, mechanic said he'd have to replace the entire engine. Took to Ford Dealer who confirmed concerns, performed test and found coolant in cylinder 2. Said that engine needed to be replaced. A mechanic said if engine wasn't replaced it could eventually cause overheating, engine fires and catastrophic failures. My car only had 56,244 miles on it when I had to replace the engine at dealer, at a cost to me of $8000. (Warranty expired at 5 years, 50,000 miles. Ford has recalled other models with this same problem. This model and year should be included in the recall.

My car was leaking coolant into the engine not only causing the engine to fail and need replacing, but the engine overheated, causing me to have to pull over on the side of the road. It happened a few time before the issue could be found. The dealer finally found the cause of the overheating was due to coolant intruding into the engine causing cylinders to misfire.

Took my car in to get repaired as the heater was not working. Turns out that I am required to have a full engine replacement after ONLY 58,000 miles due to coolant intrusion. This is absolutely unacceptable. The risk of coolant leaking into an engine is complete engine failure which can result in engine fires. This was confirmed by the dealer service center. There was a check engine light on, but then it turned off after a week.

Recently, I had to replace the engine on my 2018 Ford Edge with only 73k miles on it. I spoke to an agent on July 10th with Case #: [XXX]. The total engine replacement cost was $7,700. Ford only covered $3,000, leaving me with the remaining balance of $4,700. I first noticed my check engine light was on in July, so I took it to the dealership (Tony Betten Ford, Grand Rapids, MI) to find out the engine block was cracked and needed to be replaced. The powertrain warranty only covers 5 years or 60k miles, and my vehicle is 6 years old with just over 73k miles, so it did not qualify. I should not have to replace an entire engine at this mileage, especially since other automakers' warranties are upwards of 100k miles. I've taken good care of this vehicle and bought it brand new (in 2018) and would expect better of a Ford Vehicle. Coincidentally, my brother also owns a 2018 Ford Edge. He had the EXACT SAME issue with his Edge around the same mileage (70k miles) and had to replace his engine too- This is clearly a known issue on these vehicles. Also, this is a current recall and known issue on 1.5L engine, so it's clearly an issue on 2L engine too. For the safety of all 2L engine owners, this should absolutely be a full recall. I've been a lifelong Ford vehicle owner and driver and I would hope the customer service from Ford would be to treat this as a recall and take care of this. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)