Vehicle began to rough idle, and then while driving the vehicle MIL came on, as well as a "Engine overheat throttle limited" error. Pulled over and vehicle would not move. Tried to power cycle the vehicle and would not start back up. Had it towed to dealer and was told this was the long block coolant intrusion problem that lead…
Read full complaint
Vehicle began to rough idle, and then while driving the vehicle MIL came on, as well as a "Engine overheat throttle limited" error. Pulled over and vehicle would not move. Tried to power cycle the vehicle and would not start back up. Had it towed to dealer and was told this was the long block coolant intrusion problem that leader to my engine completely failing. I was made aware of Ford TSB 19-2346, and told the repairs would be $9200. After googling around, this is a common problem on these 2018 ford ecoboost engines and Ford obviously knows there is a problem that could cause accidents or engine fires. Luckily my kids were not in the car, otherwise this could have been catastrophic due to the loss of power while driving. I called Ford support and they told me that Ford has no programs to help affected customers. There should be a Recall and Ford should be forced to replace or repair affected engines as this will get someone killed if they lose power or have an engine fire while driving.
NHTSA ODI #11636542
Mileage unknown · Jan 16, 2025
Engine
Coolant leaking into engine cylinders. Had an independent service center state we need a new engine. The labor cost to replace the gasket would add up to the cost of a new engine. Told us Ford had corrected the engineering problem that caused the leak. Said it was common problem with the Ford Edge vehicle.
NHTSA ODI #11636366
Mileage unknown · Jan 5, 2025
Engine
I bought the car and 2 days later the check engine light came on so I took it to Wendle Ford Town in Spokane Washington and I was told that the Engine was leaking antifreeze into the cylinders so I became concerned that if it was doing that then it could cause the Engine to overheat or stop unexpectedly because of overheating an…
Read full complaint
I bought the car and 2 days later the check engine light came on so I took it to Wendle Ford Town in Spokane Washington and I was told that the Engine was leaking antifreeze into the cylinders so I became concerned that if it was doing that then it could cause the Engine to overheat or stop unexpectedly because of overheating and cause an accident
NHTSA ODI #11634195
Mileage unknown · Dec 30, 2024
Engine
Car has a defect that causes coolant to leak into the engine’s cylinders, which can caused corrosion, oil dilution and contamination, and engine failure. Ford failed to disclose these defects and created a safety risk, because the lack of coolant created by the leaks caused overheating and resulted in total engine failure. Car…
Read full complaint
Car has a defect that causes coolant to leak into the engine’s cylinders, which can caused corrosion, oil dilution and contamination, and engine failure. Ford failed to disclose these defects and created a safety risk, because the lack of coolant created by the leaks caused overheating and resulted in total engine failure. Car is available for inspection. Mechanic has confirmed car needs a new engine. See attached. Car has not been inspected by any others. ' The car has multiple error codes indicating failure.
NHTSA ODI #11633115
57,900 miles · Dec 20, 2024
Engine
The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. In addition, the contact stated that when the vehicle was started, the vehicle was abnormally shaking. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contac…
Read full complaint
The contact owns a 2018 Ford Edge. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. In addition, the contact stated that when the vehicle was started, the vehicle was abnormally shaking. The vehicle was taken to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced Technical Serviced Bulletin: 22-2229; however, the contact was informed that the repair was not covered under the program. The failure mileage was approximately 57,900.
NHTSA ODI #11631785
Mileage unknown · Dec 18, 2024
Engine
Coolant intrusion to engine cylinder bay which leads to misfires, white smoke and constant lagging, jerking and rough starts. Dealership confirmed new engine is required to remedy this issue.
NHTSA ODI #11631430
Mileage unknown · Dec 17, 2024
Engine
The car has 64,000 mi on it. They had to change the long block because of coolant infusion into the number 2 cylinder. They denied my lifetime warranty because I had the oil changed at the dealership twice at 6 months and 2 weeks. I had the oil changed religiously at 5, 000 or less miles at the dealership where I bought the car,…
Read full complaint
The car has 64,000 mi on it. They had to change the long block because of coolant infusion into the number 2 cylinder. They denied my lifetime warranty because I had the oil changed at the dealership twice at 6 months and 2 weeks. I had the oil changed religiously at 5, 000 or less miles at the dealership where I bought the car, Ricart Ford. Also they denied it because I changed the cabin air filter on my own.
NHTSA ODI #11631262
Mileage unknown · Dec 16, 2024
Engine
Coolant intrusion into engine cylinder. Requires long block +engine build. Issue reported at around 75000 miles.
NHTSA ODI #11631013
Mileage unknown · Dec 15, 2024
Engine
Check engine light came on and I checked the code with a reader. The code came up to a cylinder 2 misfire. Made an appointment with local dealership for diagnostic of the issue. Before the appointment was able to happen the check engine light went off. Appointment cancelled and 2 days later the check engine light came back on so…
Read full complaint
Check engine light came on and I checked the code with a reader. The code came up to a cylinder 2 misfire. Made an appointment with local dealership for diagnostic of the issue. Before the appointment was able to happen the check engine light went off. Appointment cancelled and 2 days later the check engine light came back on so made a new appointment. Continued to drive car with no issues. Brought car in for service and received a report back that cylinder 2 & 3 misfire and was advised coolant leaking into the engine and recommended repair is a new engine. After a quick google search found that this is a widespread issue with this engine.
NHTSA ODI #11630808
Mileage unknown · Dec 14, 2024
Engine
In September 2024 (just over 68k miles) my check engine light came on in my 2018 Ford Edge, car overheated, smoke from tailpipe and would no longer run. I had it towed to the dealership where it was determined that it needed a whole new engine. This is the same engine that is recalled or warranty extended for the Escape but not …
Read full complaint
In September 2024 (just over 68k miles) my check engine light came on in my 2018 Ford Edge, car overheated, smoke from tailpipe and would no longer run. I had it towed to the dealership where it was determined that it needed a whole new engine. This is the same engine that is recalled or warranty extended for the Escape but not the Edge! 2 weeks later, I paid thousands of dollars to have the engine replaced. Today, less than 3 months later and only a few hundred miles after a new engine- the check engine light is flashing and the vehicle is sputtering. This vehicle is used to transport our children and get us to/from work. This is completely unacceptable and unsafe. The vehicle is, once again, unable to be driven. I have contacted Ford Customer Service who has advised we make another dealership appointment and they are not open currently. Something needs to be done about this vehicle!
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence & remedy
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Additional source detail variants (2)
Power Train:shift Linkage/cable/rod
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence & remedy
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Additional source detail variants (2)
Service Brakes
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Ford Motor Company (Ford) is recalling certain 2018 Ford Edge and Lincoln MKX vehicles. These vehicles may have door striker bolts that are shorter than intended. Vehicles with shorter door striker bolts fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components" potentially resulting in the doors opening in the event of a crash.
Consequence & remedy
Consequence: If the doors open in the event of a crash, there is an increased risk of injury.
Remedy: Ford will notify owners, and dealers will replace the door striker bolts, free of charge. The recall began October 18, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18C06.
Ford Motor Company (Ford) is recalling certain 2018 Ford Edge, Lincoln MKX, 2019 Ford Flex, and Lincoln MKT vehicles. The power supply cables at the starter and the alternator may not have been properly secured, possibly resulting in an electrical arc.
Consequence & remedy
Consequence: An electrical arc can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the alternator and starter motor power supply cables to verify that they are properly secured, correcting them as necessary, free of charge. The recall began September 26, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S25.
Additional source detail variants (2)
Electrical System:starter Assembly
Ford Motor Company (Ford) is recalling certain 2018 Ford Edge, Lincoln MKX, 2019 Ford Flex, and Lincoln MKT vehicles. The power supply cables at the starter and the alternator may not have been properly secured, possibly resulting in an electrical arc.
Consequence: An electrical arc can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the alternator and starter motor power supply cables to verify that they are properly secured, correcting them as necessary, free of charge. The recall began September 26, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S25.
Electrical System:alternator/generator/regulator
Ford Motor Company (Ford) is recalling certain 2018 Ford Edge, Lincoln MKX, 2019 Ford Flex, and Lincoln MKT vehicles. The power supply cables at the starter and the alternator may not have been properly secured, possibly resulting in an electrical arc.
Consequence: An electrical arc can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the alternator and starter motor power supply cables to verify that they are properly secured, correcting them as necessary, free of charge. The recall began September 26, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S25.
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford Edge and 2017 Lincoln MKZ vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
Consequence & remedy
Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the torque converters, free of charge. The recall began on July 5, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16 (S2). Note: This recall is an expansion of recall 17V-427.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP26008 · Loss Of Motive Power
Opened Sep 3, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling
The Office of Defects Investigation (ODI) received a petition on August 5, 2026, requesting a defect investigation into the 2.0 Liter EcoBoost engine on model year 2015-2018 Ford Edge vehicles. The petition alleges that engine coolant intrusion results in a significant loss of engine power, accompanied by an "Engine Coolant Over Temperature" warning message. The petition further alleges that after the vehicle has sat and cooled down, the engine runs roughly and generates a check engine light for a cylinder misfire. This defect petition is being opened to evaluate the issue and determine whether to grant or deny the petition. The petition can be reviewed at NHTSA.gov under ODI number 11754989.
2018 Ford Edge Problems, Complaints & Recalls | Skip That Year
Illustration