NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,345 reports3,050 miles · Sep 21, 2017
Electrical SystemEngine
2017 FORD EDGE TITANIUM AWD 4CYL - LOSES POWER WHEN DRIVING WHILE DRIVING, ON MORE THAN 5 INSTANCES THE CAR LOSES POWER. ACCESSORIES - LIGHTS, POWER STEERING STAY ON BUT MOTOR SHUTS OFF. SO FAR HAS HAPPENED GOING APPROX 35 MPH AND AND ON 09/20 OCCURRED THREE TIMES, THEN HAS TROUBLE STARTING WHEN ENGINE SHUTS OFF WHILE DRIV…
Read full complaint
2017 FORD EDGE TITANIUM AWD 4CYL - LOSES POWER WHEN DRIVING WHILE DRIVING, ON MORE THAN 5 INSTANCES THE CAR LOSES POWER. ACCESSORIES - LIGHTS, POWER STEERING STAY ON BUT MOTOR SHUTS OFF. SO FAR HAS HAPPENED GOING APPROX 35 MPH AND AND ON 09/20 OCCURRED THREE TIMES, THEN HAS TROUBLE STARTING WHEN ENGINE SHUTS OFF WHILE DRIVING, THE FOLLOWING ERRORS APPEAR "STEERING ASSIST FAULT SERVICE REQUIRED" "CROSS TRAFFIC SYSTEM FAULT" "BLIND SPOT SYSTEM FAULT" "FULL ACCESSORY POWER ACTIVE" CAUGHT ON VIDEO AT LEAST 2 OF THE 09/20/2017 INSTANCES FORD STATES IT IS INTERMITTENT AND NOT PRODUCING A CODE
NHTSA ODI #11024901
3,000 miles · Sep 15, 2017
Engine
CAR BUCKED AND WAS STALLING WHILE MAKING A LEFT HAND TURN. VEHICLE WOULD NOT START,EVENTUALLY IT STARTED WAS TO BRING THE CAR TO FORD, CAR TOOK ABOUT 10 TRIES TO START THEN STALLED. CAR WAS TOWED TO FORD, STARTED THERE AND THEY HAVE NOT BEEN ABLE TO DUPLICATE (TOW DRIVER WAS UNABLE TO START VEHICLE). I HAVE ABOUT 4 VIDEOS OF…
Read full complaint
CAR BUCKED AND WAS STALLING WHILE MAKING A LEFT HAND TURN. VEHICLE WOULD NOT START,EVENTUALLY IT STARTED WAS TO BRING THE CAR TO FORD, CAR TOOK ABOUT 10 TRIES TO START THEN STALLED. CAR WAS TOWED TO FORD, STARTED THERE AND THEY HAVE NOT BEEN ABLE TO DUPLICATE (TOW DRIVER WAS UNABLE TO START VEHICLE). I HAVE ABOUT 4 VIDEOS OF THE ISSUE WHEN IT WOULD NOT START, ALSO HAVE PICTURES. DEALER HAD THE CAR FOR ABOUT 10 DAYS, THEY SAID THEY HAVE ANOTHER VEHICLE IN FOR SERVICE DOING THE SAME THING. (THIS IS AFTER REPORTING ONE ISSUE WHERE THE CAR LOST POWER WHILE DRIVING AT APPROX 35 MPH DEALER WAS UNABLE TO DUPLICATE THE ISSUE, SENT ME HOME WITH THE VEHICLE.)
NHTSA ODI #11023627
4,000 miles · Sep 6, 2017
StructureInjury
I OPENED THE ELECTRIC LIFTGATE AND WAS IN THE PROCESS OF PLACING A WHEELCHAIR INTO THE BACK COMPARTMENT WHEN THE HATCH DECIDED TO CLOSE AUTOMATICALLY. THE LIFTGATE STRUCK ME ON THE HEAD AND CONTINUED TO PUSH ME DOWN. I HAD TO PUSH ON THE LIFTGATE AS HARD AS I COULD TO GET IT TO REVERSE. IF A YOUNG CHILD HAD BEEN HIT IT WOUL…
Read full complaint
I OPENED THE ELECTRIC LIFTGATE AND WAS IN THE PROCESS OF PLACING A WHEELCHAIR INTO THE BACK COMPARTMENT WHEN THE HATCH DECIDED TO CLOSE AUTOMATICALLY. THE LIFTGATE STRUCK ME ON THE HEAD AND CONTINUED TO PUSH ME DOWN. I HAD TO PUSH ON THE LIFTGATE AS HARD AS I COULD TO GET IT TO REVERSE. IF A YOUNG CHILD HAD BEEN HIT IT WOULD HAVE CAUSED SERIOUS INJURIES. WE CALLED 2 FORD DEALERS WHO OFFERED TO GIVE US AN APPOINTMENT FOR SERVICE WITH A 2 WEEK WAIT. (BOY, DO THEY CARE). I ENDED UP WITH A MILD CONCUSSION......NAUSEA AND MILD LIGHTHEADEDNESS. SOMETHING SHOULD BE DONE TO STOP THIS LIFTGATE FROM HURTING PEOPLE....
NHTSA ODI #11021852
300 miles · Sep 6, 2017
Service BrakesSteeringCrashInjury
TL* THE CONTACT OWNS A 2017 FORD EDGE. WHILE THE CONTACT'S DAUGHTER WAS REVERSING OUT OF THE DRIVEWAY, THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO OPERATE. ADDITIONALLY, THE STEERING SEIZED AND THE VEHICLE STARTED TO VIBRATE ABNORMALLY. WHILE THE VEHICLE WAS STILL IN MOTION, THE CONTACT'S DAUGHTER JUMPED OUT OF THE VEHICLE AND …
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD EDGE. WHILE THE CONTACT'S DAUGHTER WAS REVERSING OUT OF THE DRIVEWAY, THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO OPERATE. ADDITIONALLY, THE STEERING SEIZED AND THE VEHICLE STARTED TO VIBRATE ABNORMALLY. WHILE THE VEHICLE WAS STILL IN MOTION, THE CONTACT'S DAUGHTER JUMPED OUT OF THE VEHICLE AND SUFFERED A CONCUSSION, BRUISES, HEADACHES, BACK ACHES, AND CONTUSIONS THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE CONTACT STATED THAT THE OPENED DOOR ALSO CAUSED DAMAGE TO THE NEIGHBOR'S VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS CONTACTED OR NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 300.
NHTSA ODI #11021830
Mileage unknown · Aug 28, 2017
EngineFire
ON AUGUST 16, 2017 I RENTED A 2017 FORD EDGE FROM ALAMO AT THE SAVANNAH, GA AIRPORT. ON AUGUST 18, 2017 WHILE EN ROUTE FROM SAVANNAH TO CHARLESTON, SC I WAS STOPPED BY A POLICE OFFICER ON HIGHWAY 17 NEAR YAMASSEE, SC. WHILE ON THE SHOULDER WITH THE CAR RUNNING BUT STATIONARY, SMOKE BEGAN COMING OUT OF THE CAR. MYSELF AND MY FAMI…
Read full complaint
ON AUGUST 16, 2017 I RENTED A 2017 FORD EDGE FROM ALAMO AT THE SAVANNAH, GA AIRPORT. ON AUGUST 18, 2017 WHILE EN ROUTE FROM SAVANNAH TO CHARLESTON, SC I WAS STOPPED BY A POLICE OFFICER ON HIGHWAY 17 NEAR YAMASSEE, SC. WHILE ON THE SHOULDER WITH THE CAR RUNNING BUT STATIONARY, SMOKE BEGAN COMING OUT OF THE CAR. MYSELF AND MY FAMILY EVACUATED AND WITHIN 5-10 MINUTES THE ENTIRE CAR WAS ENGULFED IN FLAMES. THE POLICEMAN RADIOED FOR A FIRE TRUCK BUT BY THE TIME THE FIRE WAS PUT OUT, THE ENTIRE CAR AND ALL OF ITS CONTENTS WAS DESTROYED.
NHTSA ODI #11020178
1,200 miles · Aug 28, 2017
Unknown Or OtherVisibility/wiper
THE SUN VISOR ON THE PASSENGER SIDE FELL OUT OF THE HEADLINER ON THE MOUNTING SIDE THE FIRST TIME WE PUT IT DOWN--IT HUNG DOWN ABOUT TWO INCHES. TODAY UNDER RAPID ACCELERATION THE OTHER SIDE CAME OUT OF IT;S CLIP FASTENER AND THE WHOLE UNIT FELL DOWN ABOUT TEN INCHES IN FRONT OF MY WIFE FACE. IT ALSO APPEARS THAT THE DRIVERS S…
Read full complaint
THE SUN VISOR ON THE PASSENGER SIDE FELL OUT OF THE HEADLINER ON THE MOUNTING SIDE THE FIRST TIME WE PUT IT DOWN--IT HUNG DOWN ABOUT TWO INCHES. TODAY UNDER RAPID ACCELERATION THE OTHER SIDE CAME OUT OF IT;S CLIP FASTENER AND THE WHOLE UNIT FELL DOWN ABOUT TEN INCHES IN FRONT OF MY WIFE FACE. IT ALSO APPEARS THAT THE DRIVERS SIDE VISOR HAD ALREADY BEEN REPAIRED AS THERE ARE DIRTY SMUDGES ON THE UNDERSIDE OF THE VISOR. THERE WAS ALSO AN EDGE--2017--ON THE SHOWROOM FLOOR THAT HAD THE DRIVERS SIDE VISOR HANGING DOWN A COUPLE OF INCHES DUE TO A FAULTY FASTENER.. WE SAW A TOTAL OF THREE EDGE'S INCLUDING THE ONE WE PURCHASED AND THREE OF THE SIX VISORS HAD THE SAME ISSUE. IFS A DRIVERS SIDE VISOR CAME DOWN THE WAY OUR PASSENGER SIDE VISOR DID TODAY THERE IS A VERY GOOD CHANCE OF IT CREATING AN ACCIDENT. I AM FINALLY HAVING MINE REPAIRED TOMORROW AFTER WAITING TWO WEEKS. I HAVE SPOKEN WITH TWO SERVICE DEPARTMENTS WHO CHECKED SERVICE BULLETINS AND THEY SAID THERE HAD BEEN NO REPORTED ISSUES BUT OBVIOUSLY THERE IS. ALSO SPOKE WITH FORD MOTOR COMPANY CUSTOMER SERVICE AND GOT THE SAME STORY. I HAVE PICTURES BUT DUE TO BEING INCOMPETENT WITH USING A COMPUTER AND IPHONE I CANNOT GET THE PICTURES TO THIS DOCUMENT. IF YOU SEND ME AN EMAIL I CAN ATTACH THE PHOTOS TO A REPLY.
NHTSA ODI #11020143
3,000 miles · Aug 24, 2017
Air BagsCrash
TL* THE CONTACT OWNS A 2017 FORD EDGE. WHILE THE CONTACT'S WIFE WAS DRIVING APPROXIMATELY 30 MPH AND CROSSING AN INTERSECTION, ANOTHER VEHICLE SUDDENLY TURNED IN FRONT OF THE CONTACT AND CRASHED INTO THE FRONT OF THE VEHICLE. THE CONTACT'S VEHICLE SPUN AROUND A FEW TIMES. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE RECEIVED DAMAG…
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD EDGE. WHILE THE CONTACT'S WIFE WAS DRIVING APPROXIMATELY 30 MPH AND CROSSING AN INTERSECTION, ANOTHER VEHICLE SUDDENLY TURNED IN FRONT OF THE CONTACT AND CRASHED INTO THE FRONT OF THE VEHICLE. THE CONTACT'S VEHICLE SPUN AROUND A FEW TIMES. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE RECEIVED DAMAGE TO THE FRONT END AND WAS NO LONGER OPERABLE. THE CONTACT'S WIFE HAD THE VEHICLE TOWED TO THE RODIO FORD DEALER (LOCATED AT 13680 W TEST DR, GOODYEAR, AZ 85338; 623-298-3900) WHO THEN HAD THE VEHICLE TOWED TO THE UNLIMITED COLLISION BODY SHOP (LOCATED AT 8112 N 75TH AVE, PEORIA, AZ 85345; 623-979-7565) WHO DEEMED THE VEHICLE TOTALED. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 3,000.
NHTSA ODI #11019421
Mileage unknown · Aug 21, 2017
Power Train
MFG RECALL #17S16 NHTSA RECALL # 17V427 FORD INC HAS BEEN UNABLE TO COMPLETE THE REPLACEMENT OF THE TORQUE CONVERTER ON OUR NEW 2017 FORD EDGE IN A TIMELY MANNER. OUR NEW FORD EDGE WAS SHIPPED FROM THE FACTORY MID JUNE, BUT NOT DELIVERED TO THE SELLING DEALERSHIP UNTIL 8/11. IT STILL HAS NOT BEEN FIXED AND DELIVERED TO US. O…
Read full complaint
MFG RECALL #17S16 NHTSA RECALL # 17V427 FORD INC HAS BEEN UNABLE TO COMPLETE THE REPLACEMENT OF THE TORQUE CONVERTER ON OUR NEW 2017 FORD EDGE IN A TIMELY MANNER. OUR NEW FORD EDGE WAS SHIPPED FROM THE FACTORY MID JUNE, BUT NOT DELIVERED TO THE SELLING DEALERSHIP UNTIL 8/11. IT STILL HAS NOT BEEN FIXED AND DELIVERED TO US. OUR SELLING DEALER DOES NOT HAVE ANY INFORMATION FROM FORD INC AS TO WHEN THE SAFETY RECALL WILL BE COMPLETED AND OUR NEW CAR DELIVERED TO US. THE VEHICLE WAS ORDERED BY OUR LOCAL FORD DEALER 5/5/17.
NHTSA ODI #11018706
3 miles · Aug 6, 2017
Electronic Stability Control (esc)Engine
CAR LOST POWER IN THE MIDDLE OF DRIVING CAR WAS IN DRIVE ON A STRAIGHT ROAD, APPROXIMATELY 35 MPH WHEN IT LOST POWER. THE ACCESSORIES WERE WORKING,
NHTSA ODI #11013146
1,500 miles · Aug 3, 2017
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2017 FORD EDGE. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT OBSERVED AN ABNORMAL ODOR WITHIN THE CABIN WITHOUT WARNING. IN ADDITION, THE CONTACT AND THE PASSENGER (HIS WIFE) EXPERIENCED A CHEMICAL TASTE WITHIN THEIR MOUTHS, BURNING IN THEIR THROATS, AND HEADACHES. THE VEHICLE WAS TAKEN TO THE DEALER (DIEHL'S…
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD EDGE. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT OBSERVED AN ABNORMAL ODOR WITHIN THE CABIN WITHOUT WARNING. IN ADDITION, THE CONTACT AND THE PASSENGER (HIS WIFE) EXPERIENCED A CHEMICAL TASTE WITHIN THEIR MOUTHS, BURNING IN THEIR THROATS, AND HEADACHES. THE VEHICLE WAS TAKEN TO THE DEALER (DIEHL'S FORD SALES 11782 NATIONAL PIKE, GRANTSVILLE, MD, 21536). THE CONTACT WAS INFORMED OF TSB 17-0035 (ENGINE AND ENGINE COOLING). THE DEALER CONDUCTED A SMOKE TEST AND DIAGNOSED THAT THE EXHAUST SPOILER OVER THE REAR HATCH SEALS FAILED. WITH THE AIR CONDITIONER ON RECIRCULATION MODE, THE VEHICLE RE-ABSORBED THE EXHAUST FUMES INTO THE CABIN. THE DEALER REPAIRED THE SPOILER, AND SEALS, AND ASKED THE CONTACT TO TEST DRIVE THE VEHICLE. THE REMEDY FAILED. DUE TO TEST DRIVING THE VEHICLE THREE TIMES PER THE DEALER, THE CONTACT HAD TO GO TO THE HOSPITAL TO RECEIVE MEDICAL ATTENTION. THE HOSPITAL STATED THAT THE CONTACT RECEIVED CARBON MONOXIDE POISONING ACCORDING TO A BLOOD TEST. THE RESULTS WERE NOT SEVERE, BUT THE PHYSICIAN RECOMMENDED TO AVOID THE VEHICLE, BREATHE FRESH AIR, AND GET PLENTY OF REST. THE DEALER STILL HAD THE VEHICLE AND, THIRTY DAYS LATER, A REMEDY STILL COULD NOT BE PROVIDED AFTER MULTIPLE ATTEMPTS. THE MANUFACTURER WAS CONTACTED AND MADE AWARE OF THE FAILURE THE SAME DAY THAT THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER PROVIDED CASE NUMBER: 12525112. THE MANUFACTURER WAS UNABLE TO DIAGNOSE THE VEHICLE FEWER THAN THREE ATTEMPTS WITHIN THIRTY DAYS. THE CONTACT ASKED FOR THE VEHICLE TO BE BOUGHT BACK UNDER THE LEMON LAW. THE FAILURE MILEAGE WAS 1,500.
NHTSA ODI #11012491
Official recalls
8Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.
Jun 10, 2022
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence & remedy
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Additional source detail variants (2)
Power Train:shift Linkage/cable/rod
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence & remedy
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Additional source detail variants (2)
Service Brakes
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Jun 11, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford Edge and 2017 Lincoln MKZ vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
Consequence & remedy
Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the torque converters, free of charge. The recall began on July 5, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16 (S2). Note: This recall is an expansion of recall 17V-427.
Jul 6, 2017
Ford Motor Company (Ford) is recalling certain 2017 Lincoln MKZ and Ford Edge and Fusion vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
Consequence & remedy
Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.
Remedy: Ford or Lincoln will notify owners, and dealers will replace the torque converters, free of charge. The recall began August 25, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16.
Mar 27, 2017
Ford Motor Company (Ford) is recalling certain 2017 Edge vehicles equipped with the optional Panoramic Vista Roof. These vehicles may have an improperly welded windshield header, reducing the vehicle's lateral structural integrity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."
Consequence & remedy
Consequence: If the vehicle has reduced lateral structural integrity, the occupants are at an increased risk of injury in the event of a side-impact crash.
Remedy: Ford will notify owners, and dealers will repair the windshield header, free of charge. The recall began May 18, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 17C05.
Feb 27, 2017
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Edge and Lincoln MKX vehicles and 2017 Lincoln Continental vehicles. In the event of a crash, the driver's frontal air bag may not fully inflate or the air bag cushion may detach from the air bag module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: During deployment, if the air bag does not fully inflate or the cushion detaches, there is an increased risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the driver frontal air bag module, free of charge. The recall began June 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP26008 · Loss Of Motive Power
Opened Sep 3, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling
The Office of Defects Investigation (ODI) received a petition on August 5, 2026, requesting a defect investigation into the 2.0 Liter EcoBoost engine on model year 2015-2018 Ford Edge vehicles. The petition alleges that engine coolant intrusion results in a significant loss of engine power, accompanied by an "Engine Coolant Over Temperature" warning message. The petition further alleges that after the vehicle has sat and cooled down, the engine runs roughly and generates a check engine light for a cylinder misfire. This defect petition is being opened to evaluate the issue and determine whether to grant or deny the petition. The petition can be reviewed at NHTSA.gov under ODI number 11754989.
PE24027 · Loss Of Braking Caused By Rear Brake Hose Failure
Opened Oct 3, 2024 · Closed Oct 30, 2025
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Service Brakes
On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.