FULL ISSUE HISTORY DOCUMENT ATTACHED.
2017 Ford Edge
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2017 Ford Edge do not stand out strongly from the model-year median of 724.
About this comparison →How this year compares
Owner complaints by model year
Compare all Edge years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
610 reports with mileage · 735 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 680 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 262 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 146 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
680 reportsIN JUNE 2020 THE ENGINE LIGHT CAME ON. WE CALLED OUR LOCAL FORD DEALERSHIP TO MAKE AN APPOINTMENT. THEY WERE NOT ABLE TO LOOK AT IT FOR A FEW DAYS, BUT WAS TOLD IT WOULD BE FINE TO DRIVE. WE NEEDED THE CAR TO GET TO WORK AND BACK SO WE TOOK IT IN TO HAVE IT CHECKED WITH ANOTHER REPUTABLE SERVICE PROVIDER. HE INFORMED US THAT WE …
Read full complaint
IN JUNE 2020 THE ENGINE LIGHT CAME ON. WE CALLED OUR LOCAL FORD DEALERSHIP TO MAKE AN APPOINTMENT. THEY WERE NOT ABLE TO LOOK AT IT FOR A FEW DAYS, BUT WAS TOLD IT WOULD BE FINE TO DRIVE. WE NEEDED THE CAR TO GET TO WORK AND BACK SO WE TOOK IT IN TO HAVE IT CHECKED WITH ANOTHER REPUTABLE SERVICE PROVIDER. HE INFORMED US THAT WE DEFIANTLY NEEDED TO TAKE IT TO OUR LOCAL FORD DEALERSHIP AS THE CODE IT WAS THROWING WAS A MAJOR ENGINE PROBLEM.THE CODES WERE P0301-P0304, WHICH IS A DEFECT IN THE ENGINE WHICH WILL ALLOW COOLANT INTRUSION INTO THE CYLINDERS. HE TOLD US THAT THERE WAS TECHNICAL SERVICE BULLETIN, COPY INCLUDED WITH THIS LETTER, ON THIS VEHICLE AND THAT THE ENGINE MOST LIKELY WOULD NEED TO BE REPLACED. WE IMMEDIATELY CALLED NEWBERG FORD AND MADE ANOTHER APPOINTMENT. WE TOOK IT IN AND AFTER A DAY IN A HALF WERE TOLD THAT IT WAS INDEED AN ENGINE DEFECT AND THE ENGINE WOULD NEED TO BE REPLACED. WE WERE ALSO TOLD THAT WE SHOULD NOT DRIVE THIS VEHICLE AS IT COULD FAIL WHILE DRIVING. THANK GOD WE DID NOT FOLLOW THEIR FIRST ADVICE THAT IT WOULD BE FINE TO DRIVE! AT FIRST, THEY TOLD US IT WAS GOING TO COST US OVER $8000 TO REPAIR. WE WERE DEVASTATED. WHILE WE STILL OWED SEVERAL THOUSAND DOLLARS ON THE CAR, WE REALLY DID NOT HAVE THAT KIND OF MONEY! WE COULDN'T NOT FIX IT AS IT IS A DAILY DRIVER. FORTUNATELY, THE DEALERSHIP CAME UP WITH A LOWER COST TO REPAIR IT, WHICH WAS WEIRD, BUT WE WERE ABLE TO FINANCE IT TO GET THE WORK DONE. NOW WE ARE NOT ONLY MAKING CAR PAYMENTS BUT ALSO PAYMENTS ON A LOAN THAT IS ALMOST HALF THE WHAT IS OWED ON THIS CAR! THIS IS NOT ACCEPTABLE!!! WE PURCHASED THIS CAR WITH THE CONFIDENCE WE HAVE ALWAYS HAD IN FORD. FORD IS VERY AWARE OF THIS 'DEFECT 'IN THIS ENGINE AND IS NOT WILLING TO MAKE ANY EFFORT TO RECALL IT?? THIS WAS NOT ANYTHING WE DID TO THIS VEHICLE; IT IS DUE TO A MANUFACTURING DEFECT!!!!
IN JUNE 2020 THE ENGINE LIGHT CAME ON. WE CALLED OUR LOCAL FORD DEALERSHIP TO MAKE AN APPOINTMENT. THEY WERE NOT ABLE TO LOOK AT IT FOR A FEW DAYS, BUT WAS TOLD IT WOULD BE FINE TO DRIVE. WE NEEDED THE CAR TO GET TO WORK AND BACK SO WE TOOK IT IN TO HAVE IT CHECKED WITH ANOTHER REPUTABLE SERVICE PROVIDER. HE INFORMED US THAT WE …
Read full complaint
IN JUNE 2020 THE ENGINE LIGHT CAME ON. WE CALLED OUR LOCAL FORD DEALERSHIP TO MAKE AN APPOINTMENT. THEY WERE NOT ABLE TO LOOK AT IT FOR A FEW DAYS, BUT WAS TOLD IT WOULD BE FINE TO DRIVE. WE NEEDED THE CAR TO GET TO WORK AND BACK SO WE TOOK IT IN TO HAVE IT CHECKED WITH ANOTHER REPUTABLE SERVICE PROVIDER. HE INFORMED US THAT WE DEFIANTLY NEEDED TO TAKE IT TO OUR LOCAL FORD DEALERSHIP AS THE CODE IT WAS THROWING, P0301-P0304, WAS A MAJOR ENGINE DEFECT. HE TOLD US THAT THERE WAS A TECHNICAL SERVICE BULLETIN ON THIS VEHICLE AND THAT THE ENGINE MOST LIKELY WOULD NEED TO BE REPLACED. WE IMMEDIATELY CALLED NEWBERG FORD AND MADE ANOTHER APPOINTMENT. WE TOOK IT IN AND AFTER A DAY IN A HALF WERE TOLD THAT IT WAS INDEED AN ENGINE DEFECT AND THE ENGINE WOULD NEED TO BE REPLACED. WE WERE ALSO TOLD THAT WE SHOULD NOT DRIVE THIS VEHICLE AS IT COULD FAIL WHILE DRIVING. THANK GOD WE DID NOT FOLLOW THEIR FIRST ADVICE THAT IT WOULD BE FINE TO DRIVE! AT FIRST, THEY TOLD US IT WAS GOING TO COST US OVER $8000 TO REPAIR. WE WERE DEVASTATED. WHILE WE STILL OWED SEVERAL THOUSAND DOLLARS ON THE CAR, WE REALLY DID NOT HAVE THAT KIND OF MONEY! WE COULDN'T NOT FIX IT AS IT IS A DAILY DRIVER. FORTUNATELY, THE DEALERSHIP CAME UP WITH A LOWER COST TO REPAIR IT, WHICH WAS WEIRD, BUT WE WERE ABLE TO FINANCE IT TO GET THE WORK DONE. NOW WE ARE NOT ONLY MAKING CAR PAYMENTS BUT ALSO PAYMENTS ON A LOAN THAT IS ALMOST HALF OF WHAT IS OWED ON THIS CAR! THIS IS NOT ACCEPTABLE!!! WE PURCHASED THIS CAR WITH THE CONFIDENCE WE HAVE ALWAYS HAD IN FORD. FORD IS VERY AWARE OF THIS 'DEFECT 'IN THIS ENGINE AND IS NOT WILLING TO MAKE ANY EFFORT TO RECALL IT?? THIS WAS NOT ANYTHING WE DID TO THIS VEHICLE; IT IS DUE TO A MANUFACTURING DEFECT!!!!
THIS ENGINE IS FAULTY. I PURCHASED IT AND THE CYLINDER CRACKED. THIS WAS DIAGNOSED BY THE FORD DEALER. THE ENGINE DROVE PERFECTLY FINE. THEN I BEGAN HAVING SOME HARD SHAKING AND JERKING. THE VEHICLE THEN OVERHEATED CAUSING THE CHECK ENGINE LIGHT TO COME ON. THIS HAS BEEN REPORTED ON OTHER SITES BY MULTIPLE FORD OWNERS.*DT CONSU…
Read full complaint
THIS ENGINE IS FAULTY. I PURCHASED IT AND THE CYLINDER CRACKED. THIS WAS DIAGNOSED BY THE FORD DEALER. THE ENGINE DROVE PERFECTLY FINE. THEN I BEGAN HAVING SOME HARD SHAKING AND JERKING. THE VEHICLE THEN OVERHEATED CAUSING THE CHECK ENGINE LIGHT TO COME ON. THIS HAS BEEN REPORTED ON OTHER SITES BY MULTIPLE FORD OWNERS.*DT CONSUMER ALSO HAD ISSUES WITH ENGINE WITH LOW COOLANT LEVEL AND WHITE EXHAUST SMOKE.*JB *TR
ENGINE LIGHT CAME ON. CODE WAS P0302, INITIAL INPUT FROM FORD DEALER, CHANGE SPARK PLUGS, 98XXX MILES, PROBABLY DUE FOR A TUNE-UP. MAINTENANCE PERFORMED, CODE RESET. ENGINE LIGHT CAME BACK ON, AND ENGINE COOLANT OVERTEMPT INDICATION WHILE DRIVING INTO WORK, LOW ON ANTI-FREEZE, TAKEN TO DIFFERENT FORD DEALER THAT SAME AFTERNOON, …
Read full complaint
ENGINE LIGHT CAME ON. CODE WAS P0302, INITIAL INPUT FROM FORD DEALER, CHANGE SPARK PLUGS, 98XXX MILES, PROBABLY DUE FOR A TUNE-UP. MAINTENANCE PERFORMED, CODE RESET. ENGINE LIGHT CAME BACK ON, AND ENGINE COOLANT OVERTEMPT INDICATION WHILE DRIVING INTO WORK, LOW ON ANTI-FREEZE, TAKEN TO DIFFERENT FORD DEALER THAT SAME AFTERNOON, BORESCOPE OF CYLINDER 2 INDICATES LEAKAGE OF ANTIFREEZE INTO THE CYLINDER TOLD THAT ENGINE LONGBLOCK WILL REQUIRE REPLACEMENT.
I BOUGHT MY 2017 FORD EDGE LESS THAN A YEAR AND HALF AGO AND THE FIRST YEAR WAS RUNNING FINE BUT THEN IT GAVE SOME BATTERY ISSUES FOR NO REASON THEN I HAD TO REPLACED IT. THAT WAS MY FIRST ISSUE WITH IT, A YEAR LATER IM DEALING WITH SOME OVERHEATING PROBLEMS WHICH I TOOK IT TO THE MECHANIC AND THE DIAGNOSIS WAS THERE IS COOLANT …
Read full complaint
I BOUGHT MY 2017 FORD EDGE LESS THAN A YEAR AND HALF AGO AND THE FIRST YEAR WAS RUNNING FINE BUT THEN IT GAVE SOME BATTERY ISSUES FOR NO REASON THEN I HAD TO REPLACED IT. THAT WAS MY FIRST ISSUE WITH IT, A YEAR LATER IM DEALING WITH SOME OVERHEATING PROBLEMS WHICH I TOOK IT TO THE MECHANIC AND THE DIAGNOSIS WAS THERE IS COOLANT IN THE ENGINE WITH NO LEAKING OR WHATSOEVER, APPARENTLY THE COOLANT WAS EVAPORATING INTO THE ENGINE. NOW, FORD WONT DO ANYTHING BECAUSE IM PASSED 7K MILES FROM MY WARRANTY EXPIRATION. I HOPE I'LL GET SOME HELP BECAUSE I DONT EVEN HAVE 2 YEARS WITH THIS VEHICLE AND NOW IS ALL DAMAGE FOR NO REASON. TTHE OVERHEATING ISSUES STARTED A MONTH AGO SO I DIDNT WAIT LONG TO TAKE IT TO THE MECHANIC TO CHECK IT OUT. AT THIS POINT MY SUV STILL RUNS BUT I PREFER TO NOT DRIVE IT ANYMORE BECAUSE IT COULD CAUSE MORE DAMAGE TO IT, SO I DONT HAVE A CAR TO GET TO WORK. I'VE BEEN LOOKING FOR INFORMATION ABOUT WHAT TYPE OF ENGINE IS IT OR IF THIS HAS JUST HAPPENED TO ME AND I FOUND OUT THAT THERE IS A RECALLOF THIS MAKE AND MODEL. I REALLY HOPE I GET SOME HELP SINCE REPLACING THE WHOLE ENGINE IS VERY EXPENSIVE AND I CANT AFFORD IT. THEN AGAIN I PURCHASED THIS VEHICLE ON OCTOBER, 2018 AND LESS THAN 2 YEARS THE ENGINE IS DAMAGED COME ON PEOPLE HOW COULD IT BE POSSIBLE IF IS NOT A FABRIC DEFECT OR SOMETHING BECAUSE THERE IS STILL LOW MILLAGE IN MY SUV IS ONLY 67K AND I DONT DRIVE IT VERY FAR. BY THE WAY WHEN IT HAPPENED I WAS COMING BACK HOME FROM WORK SO YEAH IT WAS IN MOTION BUT IT OVER HEATED WHEN I WAS LESS THAN 3 MINUTES AWAY FROM HOME BUT I STOPPED ANYWAYS TO COOLED IT DOWN, ONCE I WAS HOME I PUT COOLANT AND THE NEXT DAY I TOOK IT TO THE MECHANIC.
TL* THE CONTACT CALLED ON BEHALF OF HIS DAUGHTER WHO OWNS A 2017 FORD EDGE. THE CONTACT STATED THAT WHILE HIS DAUGHTER WAS DRIVING 30 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO MEDGAARDEN SOUTHWEST SALES LOCATED AT 1608 12TH ST SW, AUSTIN, MN 55912, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT TH…
Read full complaint
TL* THE CONTACT CALLED ON BEHALF OF HIS DAUGHTER WHO OWNS A 2017 FORD EDGE. THE CONTACT STATED THAT WHILE HIS DAUGHTER WAS DRIVING 30 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO MEDGAARDEN SOUTHWEST SALES LOCATED AT 1608 12TH ST SW, AUSTIN, MN 55912, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED DUE TO COOLANT LEAKING INTO THE ENGINE CYLINDER. THE VEHICLE WAS NOT REPAIRED. THE DEALER CONTACTED THE MANUFACTURER ON BEHALF OF THE VEHICLE OWNER HOWEVER, THE MANUFACTURER DECLINED TO PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 61,900.
TL* THE CONTACT OWNS A 2017 FORD EDGE. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT COOLANT LEAKED INTO CYLINDER NUMBER 2 AND THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NO…
Read full complaint
TL* THE CONTACT OWNS A 2017 FORD EDGE. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT COOLANT LEAKED INTO CYLINDER NUMBER 2 AND THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 104,000. *LN *BF *AS*JB
2ND CYLINDER LEAKING COOLANT. ENGINE NEEDS TO BE REPLACED.
I WAS DRIVING GOING 35 MPH ACCELERATING TO 40 MPH AS I WAS ON THE INSIDE LANE OF THREE LANES ENTERING THE STATE HIGHWAY TO GO OVER THE BRIDGE WHEN MY INDICATOR LIGHT CAME ON SHOWING OVER HEATING AND I LOST POWER. I IMMEDIATELY HAD TO PULL OFF THE ROAD AND WAITED 1 1/2 HOURS FOR ENGINE TO COOL DOWN TO CHECK MY ENGINE. WHEN I CH…
Read full complaint
I WAS DRIVING GOING 35 MPH ACCELERATING TO 40 MPH AS I WAS ON THE INSIDE LANE OF THREE LANES ENTERING THE STATE HIGHWAY TO GO OVER THE BRIDGE WHEN MY INDICATOR LIGHT CAME ON SHOWING OVER HEATING AND I LOST POWER. I IMMEDIATELY HAD TO PULL OFF THE ROAD AND WAITED 1 1/2 HOURS FOR ENGINE TO COOL DOWN TO CHECK MY ENGINE. WHEN I CHECKED I HAD NO COOLANT IN MY RADIATOR . I SPOKE TO A FORD SERVICE EMPLOYEE AND THEY SAID GET IT TO THEM TO CHECK OUT. THEY INSPECTED AND TELL ME THERE IS A SERVICE BULLETIN 19-2346 STATING THE DEFECT. A KNOWN DEFECT CAUSING DANGEROUS SITUATIONS FOR UNAWARE CAR OWNERS. FORD HAS TOLD ME THEY WILL NOT TAKE RESPONSIBILITY FOR THEIR KNOWN DEFECTIVE ISSUE AND WANT $ 7,000.00 TO REPLACE WHOLE ENGINE. CURRENTLY IT IS AT FORD BEING REPAIRED AT MY EXPENSE BUT HOPEFULLY OUR GOVERNMENT OFFICIALS OR A LAWYER CAN HELP REDEEM THIS SITUATION.
Official recalls
825V572000 · Back Over Prevention: Sensing System: Camera
Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
25V544000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.
Consequence & remedy
Consequence: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.
22V413000 · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:shift Linkage/cable/rod
Jun 10, 2022
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence & remedy
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Additional source detail variants (2)
Power Train:shift Linkage/cable/rod
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
Power Train:automatic Transmission:gear Position Indication (prndl)
Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.
Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.
Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.
20V469000 · Service Brakes; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence & remedy
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Additional source detail variants (2)
Service Brakes
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.
Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.
18V390000 · Power Train:automatic Transmission:torque Converter
Jun 11, 2018
Ford Motor Company (Ford) is recalling certain 2017-2018 Ford Edge and 2017 Lincoln MKZ vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
Consequence & remedy
Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the torque converters, free of charge. The recall began on July 5, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16 (S2). Note: This recall is an expansion of recall 17V-427.
17V427000 · Power Train:automatic Transmission:torque Converter
Jul 6, 2017
Ford Motor Company (Ford) is recalling certain 2017 Lincoln MKZ and Ford Edge and Fusion vehicles. On vehicles with 2.0L gas engines and six-speed automatic transmissions, the torque converter weld studs may have been inadequately welded.
Consequence & remedy
Consequence: If the torque converter weld studs fail, the torque converter will not be connected to the engine flexplate and the vehicle will lose the ability to move, increasing the risk of a crash.
Remedy: Ford or Lincoln will notify owners, and dealers will replace the torque converters, free of charge. The recall began August 25, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S16.
17V205000 · Structure:body:roof And Pillars
Mar 27, 2017
Ford Motor Company (Ford) is recalling certain 2017 Edge vehicles equipped with the optional Panoramic Vista Roof. These vehicles may have an improperly welded windshield header, reducing the vehicle's lateral structural integrity. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 214, "Side Impact Protection."
Consequence & remedy
Consequence: If the vehicle has reduced lateral structural integrity, the occupants are at an increased risk of injury in the event of a side-impact crash.
Remedy: Ford will notify owners, and dealers will repair the windshield header, free of charge. The recall began May 18, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for the recall is 17C05.
17V123000 · Air Bags:frontal:driver Side:inflator Module
Feb 27, 2017
Ford Motor Company (Ford) is recalling certain 2016-2017 Ford Edge and Lincoln MKX vehicles and 2017 Lincoln Continental vehicles. In the event of a crash, the driver's frontal air bag may not fully inflate or the air bag cushion may detach from the air bag module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: During deployment, if the air bag does not fully inflate or the cushion detaches, there is an increased risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will replace the driver frontal air bag module, free of charge. The recall began June 16, 2017. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17C02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3DP26008 · Loss Of Motive Power
Opened Sep 3, 2026 · No close date supplied
Status: open (inferred from source dates) · Engine And Engine Cooling
The Office of Defects Investigation (ODI) received a petition on August 5, 2026, requesting a defect investigation into the 2.0 Liter EcoBoost engine on model year 2015-2018 Ford Edge vehicles. The petition alleges that engine coolant intrusion results in a significant loss of engine power, accompanied by an "Engine Coolant Over Temperature" warning message. The petition further alleges that after the vehicle has sat and cooled down, the engine runs roughly and generates a check engine light for a cylinder misfire. This defect petition is being opened to evaluate the issue and determine whether to grant or deny the petition. The petition can be reviewed at NHTSA.gov under ODI number 11754989.
PE24027 · Loss Of Braking Caused By Rear Brake Hose Failure
Opened Oct 3, 2024 · Closed Oct 30, 2025
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Service Brakes
On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings
On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Illustration