← New search

2015 Ford Edge

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2015 Ford Edge do not stand out strongly from the model-year median of 724.

About this comparison →

When problems were reported

Mileage at the reported incident

450 reports with mileage · 274 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Engine. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Power Train. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

18 crash reports3 fire reports17 injury reports

Engine complaints

191 reports
Clear category filter
1,650 miles · Oct 14, 2015
Engine

I WAS TURNING RIGHT AT A SPEED OF 10-15 MPH AND WITHOUT WARNING THE ENGINE SHUT DOWN AND ALL POWER WAS LOST. I AVOIDED HITTING ANOTHER VEHICLE BY QUICKLY SHIFTING TO PARK AND RESTARTED THE ENGINE. THE ONLY THING I NOTICED ON SHUT DOWN WAS THE GREEN LIGHT ON THE IGNITION BUTTON WAS FLASHING.

NHTSA ODI #10782239

765 miles · Sep 29, 2015
Electrical SystemEngine

I WAS STOPPED AT A STOPLIGHT IN CLEAR, WARM WEATHER WHEN THE ENGINE SILENTLY TURNED ITSELF OFF. NOT REALIZING THIS, I ATTEMPTED TO TURN, BUT THE EDGE WAS OFF. AC AND RADIO REMAINED ON. I DID NOT SEE ANY WARNING LIGHTS ON THE DASHBOARD. AFTER A FEW FRANTIC MINUTES, I NOTICED THE SMALL GREEN LIGHT ON THE IGNITION BUTTON WAS FLA…

Read full complaint

I WAS STOPPED AT A STOPLIGHT IN CLEAR, WARM WEATHER WHEN THE ENGINE SILENTLY TURNED ITSELF OFF. NOT REALIZING THIS, I ATTEMPTED TO TURN, BUT THE EDGE WAS OFF. AC AND RADIO REMAINED ON. I DID NOT SEE ANY WARNING LIGHTS ON THE DASHBOARD. AFTER A FEW FRANTIC MINUTES, I NOTICED THE SMALL GREEN LIGHT ON THE IGNITION BUTTON WAS FLASHING. I PUT CAR IN PARK AND WAS ABLE TO RESTART ENGINE. WE HAVE ONLY DRIVEN THE CAR A FEW TIMES SINCE AND NO PROBLEM. I FEAR THIS HAPPENING WHILE DRIVING IN TRAFFIC. VEHICLE HAD 765 MILES ON IT- WE HAD IT FOR 3 WEEKS.

NHTSA ODI #10778411

1,221 miles · Sep 28, 2015
Electrical SystemEngine

WE HAD STOPPED AT A RED LIGHT AND THEN WE PROCEEDED THROUGH THE LIGHT AND THE TRANSMISSION SHIFTED HARD FROM 1ST TO 2ND GEAR (AUTO TRANSMISSION) BUT DIDN'T THINK ANYTHING ABOUT IT. WE THEN TURNED INTO A PARKING LOT AT TAMPA INTERNATIONAL AIRPORT AND THE VEHICLE'S ENGINE JUST SHUT DOWN BEFORE WE CAME TO A STOP. WE COASTED INTO A …

Read full complaint

WE HAD STOPPED AT A RED LIGHT AND THEN WE PROCEEDED THROUGH THE LIGHT AND THE TRANSMISSION SHIFTED HARD FROM 1ST TO 2ND GEAR (AUTO TRANSMISSION) BUT DIDN'T THINK ANYTHING ABOUT IT. WE THEN TURNED INTO A PARKING LOT AT TAMPA INTERNATIONAL AIRPORT AND THE VEHICLE'S ENGINE JUST SHUT DOWN BEFORE WE CAME TO A STOP. WE COASTED INTO A PARKING SPACE AND THE AUTOMOBILE WAS UNRESPONSIVE TO ME TRYING TO SHUT EVERYTHING DOWN FOR APPROXIMATELY 3 TO 5 SECONDS. THERE WAS A NOTIFICATION THAT APPEARED ON THE DASH WHEN THE ENGINE SHUT DOWN BUT I DON'T REMEMBER WHAT IT SAID. IT THEN ALLOWED ME TO DEPRESS THE START/STOP BUTTON THAT ALLOWED THE ELECTRICAL SYSTEM TO SHUT DOWN FOR A RE-START. I THEN RESTARTED THE ENGINE AND PICKED UP MY PASSENGER AND DROVE HOME. THE VEHICLE HAS BEEN PROBLEM FREE BEFORE THE INCIDENT AND DID NOT CAUSE ANY PROBLEMS ON OUR RETURN DRIVE HOME. WE WERE VERY LUCKY TO HAVE BEEN IN A PARKING LOT AND NOT ON A BUSY HIGHWAY PULLING IN FRONT OF ONCOMING TRAFFIC.

NHTSA ODI #10777984

1,850 miles · Sep 20, 2015
Engine

WAS APPROACHING A 4 WAY STOP WHILE LIGHTLY TAPPING ON THE BRAKES WHEN THE ENGINE SHUT DOWN AND THE MESSAGE "FULL ACCESSORY POWER ACTIVE" SHOWED UP IN THE INFORMATION DISPLAY. WHEN THE ENGINE TURNED OFF IT DID NOT BUCKLE OR HESITATE. WAS ABLE TO TURN VEHICLE BACK ON BY SHIFTING INTO PARK.

NHTSA ODI #10765563

2,900 miles · Sep 5, 2015
Engine

THIS PROBLEM INVOLVES A LOSS OF POWER IN MY 2015 FORD EDGE-TITANIUM FWD (3.5L TI-VCT V6 ENGINE). IT OCCURRED AFTER ONLY 2 MONTHS OF OWNERSHIP AND LESS THAN 3000 MILES. AFTER YIELDING AT AN INTERSECTION, I ACCELERATED TO TURN RIGHT. NOTHING HAPPENED. THINKING MY FOOT SLIPPED OFF THE ACCELERATOR, I REPOSITIONED AND PRESSED AG…

Read full complaint

THIS PROBLEM INVOLVES A LOSS OF POWER IN MY 2015 FORD EDGE-TITANIUM FWD (3.5L TI-VCT V6 ENGINE). IT OCCURRED AFTER ONLY 2 MONTHS OF OWNERSHIP AND LESS THAN 3000 MILES. AFTER YIELDING AT AN INTERSECTION, I ACCELERATED TO TURN RIGHT. NOTHING HAPPENED. THINKING MY FOOT SLIPPED OFF THE ACCELERATOR, I REPOSITIONED AND PRESSED AGAIN. NOTHING HAPPENED. MY EDGE WAS ROLLING SLOWLY, BUT I WAS UNABLE TO PULL OFF THE HIGHWAY DUE TO BEING IN A CONSTRUCTION ZONE. THERE WERE CONES ON THE SIDES OF THE ROAD. I STOPPED THE CAR IN THE MIDDLE OF THE ROAD AND NOTICED A MESSAGE ON THE SCREEN. HOWEVER, IN MY FRANTIC STATE, I DID NOT REMEMBER IT EXACTLY. THE MESSAGE WAS SOMETHING LIKE, POWER ACCESSORIES OFF. I ATTEMPTED TO RESTART. IT WOULDN'T START, BUT I REALIZED IT WAS NOT IN PARK. ONCE I PLACED MY EDGE IN PARK, I WAS ABLE TO RESTART IMMEDIATELY. THANKFULLY, TRAFFIC WAS SLOW, AND THERE WAS NO ACCIDENT. THE SERVICE DEPARTMENT AT THE FORD DEALERSHIP WHERE MY EDGE WAS PURCHASED KEPT IT FOR 2 DAYS AND DROVE IT SEVERAL TIMES. THEY WERE UNABLE TO REPRODUCE THE PROBLEM, AND THEY DID NOT FIND ANY DIAGNOSTIC ISSUES. HOWEVER, THEY WERE CONCERNED AND DID SAY TO RETURN IMMEDIATELY IF THE PROBLEM OCCURS AGAIN. I LOVE THIS AUTOMOBILE, AND I AM A FIRST TIME FORD OWNER. HOWEVER, I NOW FEAR DRIVING IT. AFTER READING SEVERAL SIMILAR COMPLAINTS ON THIS SITE AND OTHER SITES, IT APPEARS THIS HAS BEEN ONGOING FOR YEARS. WILL SOMEONE HAVE TO DIE FOR THIS TO BE CORRECTED?

NHTSA ODI #10761809

2,100 miles · Sep 2, 2015
Engine

I WAS DRIVING IN TRAFFIC, A CONSTRUCTION ZONE. I MERGED INTO THE FINAL LANE AND PUSHED THE GAS TO ACCELERATE. THE VEHICLE JUST STARTED SLOWING DOWN. THE ENGINE HAD DIED COMPLETELY. NO WARNING LIGHTS OF ANY KIND BEFOREHAND. IT JUST STOPPED RUNNING. THE GREEN LIGHT ON THE IGNITION WAS FLASHING, AND AN ERROR CAME ON THE SCREEN SAYI…

Read full complaint

I WAS DRIVING IN TRAFFIC, A CONSTRUCTION ZONE. I MERGED INTO THE FINAL LANE AND PUSHED THE GAS TO ACCELERATE. THE VEHICLE JUST STARTED SLOWING DOWN. THE ENGINE HAD DIED COMPLETELY. NO WARNING LIGHTS OF ANY KIND BEFOREHAND. IT JUST STOPPED RUNNING. THE GREEN LIGHT ON THE IGNITION WAS FLASHING, AND AN ERROR CAME ON THE SCREEN SAYING THAT THE ACCESSORIES WERE POWERED. FORTUNATELY, SINCE I WAS IN CONSTRUCTION, I WASN'T MOVING VERY FAST. I WAS ABLE TO CRUISE A FEW YARDS, PUT IT INTO PARK AND SIT. I WAS STILL IN THE ONE LANE OF TRAFFIC, THOUGH. I TRIED STARTING THE VEHICLE AGAIN SEVERAL TIMES...NOTHING. FINALLY I LET IT SIT FOR ABOUT 30 MINUTES, THEN WAS ABLE TO START IT AGAIN. I DROVE TO THE NEAREST PARKING LOT, CALLED ROADSIDE ASSISTANCE AND HAD IT TOWED TO MY DEALERSHIP. THANK GOD I WASN'T ON THE FREEWAY, OR MOVING FASTER ON THE SURFACE STREET. THE DEALERSHIP HAS IT NOW, BUT AFTER READING HOW MANY OTHERS HAVE THE SAME COMPLAINT, I AM AFRAID TO DRIVE THIS CAR. I'VE HAD THIS VEHICLE TWO MONTHS.

NHTSA ODI #10760978

450 miles · Aug 27, 2015
Engine

THE CAR SHUTS OFF WITH NO WARNING WHILE DRIVING. THIS HAS OCCURRED 5 TIMES IN THE PAST 8 WEEKS.THE FIRST TIME WAS A WEEK AFTER WE PURCHASED THE VEHICLE AND OCCURRED AT A STOP LIGHT, THE ENGINE SHUT OFF WITH NO WARNING LIGHTS. THREE TIMES THE ENGINE HAS SHUT OFF WHILE DRIVING AT SPEEDS AROUND 25 MPH AGAIN NO WARNING LIGHTS. I WAS…

Read full complaint

THE CAR SHUTS OFF WITH NO WARNING WHILE DRIVING. THIS HAS OCCURRED 5 TIMES IN THE PAST 8 WEEKS.THE FIRST TIME WAS A WEEK AFTER WE PURCHASED THE VEHICLE AND OCCURRED AT A STOP LIGHT, THE ENGINE SHUT OFF WITH NO WARNING LIGHTS. THREE TIMES THE ENGINE HAS SHUT OFF WHILE DRIVING AT SPEEDS AROUND 25 MPH AGAIN NO WARNING LIGHTS. I WAS NOT TURNING DURING THESE TIMES. I HAVE TO PUT THE CAR IN NEUTRAL AND HAVE TO PRESS THE BRAKE IN ORDER TO RESTART THE ENGINE. TODAY THE ENGINE SHUT OFF WHILE MAKING A TURN IN AN INTERSECTION IN HEAVY TRAFFIC AND ALMOST CAUSED AN ACCIDENT. THE VEHICLES BEHIND US HAD TO SLAM ON BRAKES TO AVOID HITTING US. THIS IS EXTREMELY DANGEROUS. WE IMMEDIATELY TOOK THE CAR TO THE DEALERSHIP TODAY FOR SERVICE. THIS HAS BEEN OCCURRING MORE FREQUENTLY AND WITHOUT WARNING. I AM AFRAID TO DRIVE THIS VEHICLE.

NHTSA ODI #10759860

1,762 miles · Aug 22, 2015
EnginePower Train

WHILE MAKING A RIGHT TURN ENGINE STALLED AND ACCESSORIES ARE RUNNING LIGHT WARNING APPEARED ON INSTRUMENT CLUSTER. CAR HAD NO POWER AND GREEN LIGHT ON PUSH BUTTON START WAS FLASHING. PUT VEHICLE IN PARK AND IT RESTARTED. APPEARS THIS IS AN ON GOING PROBLEM.

NHTSA ODI #10758503

1,790 miles · Aug 17, 2015
Engine

I HAD JUST MADE A RIGHT TURN ONTO A SECONDARY ROAD FROM A FOUR LANE HIGHWAY. AS I WAS COMING OUT OF THE TURN THE CAR LOST POWER AND WOULD NOT EXCELLERATE. I WAS ABLE TO COAST TO A NEARBY PARKING LOT. I CUT THE CAR OFF (RADIO AND INSIDE CONSOLE WERE WORKING.) AFTER 30 SECONDS RESTARTED THE CAR AND IT SEEMED OK. IF I HAD CO…

Read full complaint

I HAD JUST MADE A RIGHT TURN ONTO A SECONDARY ROAD FROM A FOUR LANE HIGHWAY. AS I WAS COMING OUT OF THE TURN THE CAR LOST POWER AND WOULD NOT EXCELLERATE. I WAS ABLE TO COAST TO A NEARBY PARKING LOT. I CUT THE CAR OFF (RADIO AND INSIDE CONSOLE WERE WORKING.) AFTER 30 SECONDS RESTARTED THE CAR AND IT SEEMED OK. IF I HAD CONTINUED ON THE HIGHWAY WITH SPEED LIMITS OF 55-60 MPH, THERE WOULD HAVE BEEN A REAL CHANCE OF A REAR END COLLISION. VERY DANGEROUS PROBLEM. ON LINE SITE CARGURUS.COM/CARS/DISCUSSION-T35446_DS471580 LIST PAGE AFTER PAGE OF EXAMPLES OF EXACT SAME PROBLEM WITH OTHER FORD EDGES DATING TO 2009. TOOK CAR TO DEALERSHIP TODAY 8-17-15 AND TECH'S COULD NOT FIND ANYTHING AMISS. TOLD THEM ABOUT WEB SITE AND PROBLEM WITH THROTTLE ASSEMBLY. IF THROTTLE STICKS IN OPEN POSITION, COMPUTER CUTS POWER TO ENGINE. DEALERSHIP PRETTY MUCH DISMISSED WHAT I HAD TO SAY. ENGINE SHOULD NOT CUT OFF FOR NO REASON. VERY ANXIOUS THAT THIS WILL HAPPEN AGAIN AND OUTCOME WILL NOT BE GOOD. THERE WAS AN ERROR MESSAGE ON THE CONSOLE, BUT I WAS SO FRAZZLED I DID NOT WRITE IT DOWN.

NHTSA ODI #10749209

1,000 miles · Aug 17, 2015
Engine

TL* THE CONTACT OWNS A 2015 FORD EDGE. WHILE AT A STOP LIGHT, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND IT RESUMED NORMAL OPERATION. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAG…

Read full complaint

TL* THE CONTACT OWNS A 2015 FORD EDGE. WHILE AT A STOP LIGHT, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND IT RESUMED NORMAL OPERATION. THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 1,000.

NHTSA ODI #10749196

Official recalls

7

25V572000 · Back Over Prevention: Sensing System: Camera

Sep 3, 2025

Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.

Consequence & remedy

Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.

25V544000 · Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Aug 22, 2025

Ford Motor Company (Ford) is recalling certain 2016-2018 Lincoln MKX and 2015-2018 Edge vehicles. The rear brake jounce hose may rupture and leak brake fluid.

Consequence & remedy

Consequence: A brake fluid leak can extend the distance required to stop the vehicle, increasing the risk of a crash.

Remedy: Dealers will inspect and replace the brake jounce hoses and adjust brake jounce hoses with no damage present, free of charge. Interim owner letters notifying owners of the safety risk were mailed September 8, 2025. Additional letters will be sent once the remedy is available, anticipated August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S87.

22V413000 · Power Train:automatic Transmission:gear Position Indication (prndl); Power Train:shift Linkage/cable/rod

Jun 10, 2022

Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Consequence & remedy

Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.

Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.

Additional source detail variants (2)

Power Train:shift Linkage/cable/rod

Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.

Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.

Power Train:automatic Transmission:gear Position Indication (prndl)

Ford Motor Company (Ford) is recalling certain 2013-2019 Escape, 2013-2018 C-Max, 2013-2016 Fusion, 2013-2021 Transit Connect, and 2015-2018 Edge vehicles. The bushing that attaches the shifter cable to the transmission may degrade or detach.

Consequence: A damaged or missing bushing may prevent the vehicle from shifting into the intended gear, and cause the vehicle to move in an unexpected direction. Additionally, the vehicle may roll after the driver selects the 'Park' position. Either scenario increases the risk of a crash or injury.

Remedy: Dealers will replace the under hood shift bushing and add a protective cap over the shift cable bushing, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed July 1, 2022. Remedy parts are expected to be available in 4th Quarter 2022. Owner notification letters were mailed October 27, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S43.

20V469000 · Service Brakes; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Aug 10, 2020

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.

Consequence & remedy

Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.

Additional source detail variants (2)

Service Brakes

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.

Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.

Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

Ford Motor Company (Ford) is recalling certain 2015-2018 Ford Edge and 2016-2018 Lincoln MKX vehicles. The front brake hoses may rupture prematurely.

Consequence: A ruptured front brake hose will cause a brake fluid leak, lengthening the distance needed to stop the vehicle, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the front brake hoses with the new hoses that have a revised braid material, free of charge. Owner notification letters were mailed on May 13, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S42.

19V632000 · Steering:electric Power Assist System

Aug 29, 2019

Ford Motor Company (Ford) is recalling certain 2013-2016 Ford Fusion and Lincoln MKZ, 2015-2016 Ford Edge, and 2016 Lincoln MKX vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, and Wisconsin. Road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.

Consequence & remedy

Consequence: If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist, requiring a greater steering effort, especially at lower speeds, and increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the steering gear motor bolts and apply a wax sealer. If any of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began October 18, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S26.

16V733000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Oct 12, 2016

Ford Motor Company (Ford) is recalling certain model year 2015-2016 Ford Edge vehicles manufactured February 9, 2015, to August 12, 2016. During dealer servicing, the affected vehicles may be have been updated with incorrect Antilock Brake System (ABS) and Electronic Stability Control (ESC) software. This software can cause the ESC system to lose engine torque control, and not provide any warning lamps to warn the driver if there was an ABS or ESC system malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems" and number 135, "Light Vehicle Brake Systems."

Consequence & remedy

Consequence: If the operator is not warned of an ABS or ESC malfunction and the ESC loses engine torque control, there would be an increased risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the ABS module, and update the service software, free of charge. The recall begin November 22, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C14.

Additional source detail variants (2)

Electronic Stability Control (esc)

Ford Motor Company (Ford) is recalling certain model year 2015-2016 Ford Edge vehicles manufactured February 9, 2015, to August 12, 2016. During dealer servicing, the affected vehicles may be have been updated with incorrect Antilock Brake System (ABS) and Electronic Stability Control (ESC) software. This software can cause the ESC system to lose engine torque control, and not provide any warning lamps to warn the driver if there was an ABS or ESC system malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems" and number 135, "Light Vehicle Brake Systems."

Consequence: If the operator is not warned of an ABS or ESC malfunction and the ESC loses engine torque control, there would be an increased risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the ABS module, and update the service software, free of charge. The recall begin November 22, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C14.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Ford Motor Company (Ford) is recalling certain model year 2015-2016 Ford Edge vehicles manufactured February 9, 2015, to August 12, 2016. During dealer servicing, the affected vehicles may be have been updated with incorrect Antilock Brake System (ABS) and Electronic Stability Control (ESC) software. This software can cause the ESC system to lose engine torque control, and not provide any warning lamps to warn the driver if there was an ABS or ESC system malfunction. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 126, "Electronic Stability Control Systems" and number 135, "Light Vehicle Brake Systems."

Consequence: If the operator is not warned of an ABS or ESC malfunction and the ESC loses engine torque control, there would be an increased risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the ABS module, and update the service software, free of charge. The recall begin November 22, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C14.

15V250000 · Steering:electric Power Assist System

Apr 28, 2015

Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Fusion and Lincoln MKZ vehicles manufactured February 3, 2012, to March 20, 2015, and 2015 Ford Edge vehicles manufactured February 26, 2015, to February 28, 2015, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. In the affected vehicles, snow or water containing road salt or other contaminants may corrode the electric power steering gear motor attachment bolts.

Consequence & remedy

Consequence: If the bolts corrode, the steering gear motor may detach from the gear housing resulting in a loss of power steering assist. Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will apply sealer and replace the steering gear motor bolts as required. If one or more of the steering gear motor attachment bolts are broken or missing, a new steering gear will be installed in the vehicle. These repairs will be performed free of charge. The recall began on June 24, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S14.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

3

DP26008 · Loss Of Motive Power

Opened Sep 3, 2026 · No close date supplied

Status: open (inferred from source dates) · Engine And Engine Cooling

The Office of Defects Investigation (ODI) received a petition on August 5, 2026, requesting a defect investigation into the 2.0 Liter EcoBoost engine on model year 2015-2018 Ford Edge vehicles. The petition alleges that engine coolant intrusion results in a significant loss of engine power, accompanied by an "Engine Coolant Over Temperature" warning message.  The petition further alleges that after the vehicle has sat and cooled down, the engine runs roughly and generates a check engine light for a cylinder misfire. This defect petition is being opened to evaluate the issue and determine whether to grant or deny the petition. The petition can be reviewed at NHTSA.gov under ODI number 11754989.

PE24027 · Loss Of Braking Caused By Rear Brake Hose Failure

Opened Oct 3, 2024 · Closed Oct 30, 2025

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Additional source detail variants (2)

Service Brakes

On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Service Brakes, Hydraulic:foundation Components:hoses, Lines/piping, And Fittings

On October 3, 2024, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation to investigate instances of rear brake hose ruptures causing a sudden and unexpected loss of braking in model year (MY) 2015-2017 Ford Edge vehicles manufactured by Ford Motor Company. The complaints allege that, without warning, the vehicle lost its ability to brake causing an unanticipated increase in the vehicle’s stopping distance. The complaints also allege that, prior to the rear brake hose rupture event, the vehicle had been serviced under recall 20V-469. Recall 20V469 involved MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles which may experience front brake hose ruptures causing increased brake pedal travel and a reduction in the rate of deceleration. Ford identified the cause of this safety defect as a consistent localized failure of the internal reinforcement braid of the brake hose due to cyclic fatigue via tensile/bending and torsional inputs during suspension and steering articulations. Ford also identified that only 88% of suspension articulation was utilized on the front brake hose test rig during life cycle testing. These findings, along with ODI’s identification of an emerging trend involving rear brake hose ruptures, prompted the opening of this investigation. ODI identified 64 Vehicle Owners Questionnaires related to this investigation, 2 involving a crash. These consumers were interviewed and reported experiencing sudden loss of braking ability while traveling at low and highway speeds without any prior warning such as a “low brake fluid” warning indicator. Consumers reported that, as they tried to stop their vehicle, the brake pedal traveling to the floorboard and the vehicle required more stopping distance than anticipated or considered normal. Consumers also observed brake fluid present on the rear tires and roadway near the rear tires immediately after the incident. Some consumers provided photographs of the rear brake hose ruptures which depicted a similar rupture pattern and location (near the crimp on the dynamic section of the brake hose). 1 photograph showed an installation alignment mark pulled out near the crimp suggesting exposure to unanticipated tensile forces pulling the hose away from the crimp. During this investigation, Ford responded to Information Request Letters detailing information such as warranty claim data, brake hose specifications and engineering drawings, production part changes logs, and Ford’s assessments of potential root cause. Ford reported that the front and rear brake jounce hoses equipped on the subject vehicle population utilized the same construction and material. Therefore, Ford’s analysis consisted of a comparison between the front and rear hoses demonstrating that the rear hose bend radii in full jounce and full rebound were larger than the front hose. Ford also described that the two hoses are exposed to different loading environments as the rear brake hose is exposed to suspension inputs only, while the front hose is exposed to both suspension and steering inputs; thus, the rear hose is subjected to lower tension and fatigue loads. However, it is important to point out that larger bend radii alone do not necessarily mean a brake hose can withstand the dynamic loading requirements of a brake hose (as discussed earlier, the defect identified in the front brake hoses were attributed to the hose material). Rear brake hose failures were identified through exemplar vehicle and parts inspections conducted by NHTSA’s Vehicle Research and Testing Center. Ford stated that its investigation did not identify any specific or common root cause for this safety defect, and that brake hoses can fail for many reasons including contact with road debris, improper vehicle servicing, and fatigue, as well as vehicle age and miles in service. Based on its assessment of failure rates and warranty claims, Ford concluded that the rear brake hose ruptures did not present an unreasonable risk to motor vehicle safety because consumers would experience a progressive leak accompanied by a red brake warning indicator within the instrument panel and would not experience a total loss of braking due to the diagonally split brake system. Note that these assessments are contrary to the consumer experiences described above. As previously described, consumers described a sudden, unexpected loss of braking ability with no prior warning in their instrument cluster (not a progressive leak) and an increase in anticipated vehicle stopping distance (presenting an unreasonable risk to motor vehicle safety). ODI conveyed these perspectives and investigative findings to Ford during a technical discussion on July 23, 2025. On August 22, 2025, Ford submittedrecall 25V-544 which included MY 2015-2018 Ford Edge and MY 2016-2018 Lincoln MKX vehicles, for a total recall population of 499,129 vehicles. As described in the Part 573, in September 2024, Ford concluded that this concern did not present an unreasonable risk to motor vehicle safety and closed its investigation into allegations involving rear brake jounce hose ruptures within this vehicle population. Ford reopened this investigation in July 2025 following the technical discussion with ODI referenced above. Ford identified the safety defect as a rupture of the rear brake jounce hose resulting in an increase in pedal travel and increase in vehicle stopping distance elevating the risk of a crash. To date, Ford has not fully determined the root cause of this safety defect and is currently working to develop a remedy program. In view of the recall action taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.