IN STOP AND GO TRAFFIC AT LOW SPEEDS, THE VEHICLE HAS STALLED MULTIPLE TIMES (11 TIMES IN THE LAST YEAR AND A HALF). THE MOST RECENT TIME IN HEAVY, SLOW-MOVING CONSTRUCTION TRAFFIC. CAR LOSES ALL POWER WITHOUT WARNING. LOSS OF POWER STEERING, VERY TIGHT BRAKES, NO ACCELERATION POSSIBLE AND A LOW OIL WARNING. I HAVE TO TURN T…
Read full complaint
IN STOP AND GO TRAFFIC AT LOW SPEEDS, THE VEHICLE HAS STALLED MULTIPLE TIMES (11 TIMES IN THE LAST YEAR AND A HALF). THE MOST RECENT TIME IN HEAVY, SLOW-MOVING CONSTRUCTION TRAFFIC. CAR LOSES ALL POWER WITHOUT WARNING. LOSS OF POWER STEERING, VERY TIGHT BRAKES, NO ACCELERATION POSSIBLE AND A LOW OIL WARNING. I HAVE TO TURN THE CAR OFF AND RESTART, THIS SOMETIMES WORKS, OTHER TIMES I HAVE NEEDED THE CAR TOWED BECAUSE IT DID NOT RESTART. THIS IS A COMPANY CAR AND IT HAS BEEN TO THE DEALERSHIP MULTIPLE TIMES, AND ONLY THIS LAST WEEK WAS ANYTHING EVER FOUND TO BE WRONG. ALL PREVIOUS TIMES THE STALLING COULD NOT BE DUPLICATED, AND I WAS TOLD EITHER NOTHING WAS WRONG WITH THE CAR, THEY FIXED A PART THEY THOUGHT MIGHT BE THE PROBLEM, OR I MUST HAVE PUT IN BAD GAS. AFTER STALLING A MONTH AGO, THIS PAST WEEK A DATA RECORDER WAS ATTACHED AND A DEFECTIVE OXYGEN SENSOR WAS FOUND IN THE EMISSIONS SYSTEM WHEN THE CAR STALLED FOR THE DEALERSHIP. THE OXYGEN SENSOR WAS REPLACED AND THEY TEST DROVE THE CAR. THE STALLING DID NOT OCCUR DURING THEIR FINAL TEST DRIVES. I RECEIVED THE CAR BACK A WEEK AGO, ONLY TO HAVE IT STALL THREE TIMES WITHIN 10 MILES TWO DAYS AGO. ALMOST WAS RE-ENDED BY A SEMI-TRAILER TRUCK THIS LAST TIME AS I WAS IN THE MIDDLE OF SIX LANES OF TRAFFIC, AND WITH NO STEERING, WAS HELPLESS TO MOVE. HAVE STALLED OUT IN A GAS STATION, ROUNDING CORNERS IN INTERSECTIONS, AT STOP SIGNS, DRIVING DOWN MY STREET, AND NOW FOUR TIMES ON THE HIGHWAY DURING LOW SPEED TRAFFIC CONGESTION. HAVING THE CAR TOWED TO THE DEALERSHIP AS I AM TOO AFRAID TO DRIVE IT. THERE ARE AT LEAST FOUR OTHER COMPLAINTS ABOUT THIS ISSUE ON THE NHTSA WEBSITE, AND IT SOUNDS LIKE VERY SIMILAR TO SYMPTOMS SEEN IN THE GM RECALLS. CAR STALLS WITHOUT WARNING IN MORE AND MORE DANGEROUS SITUATIONS. THIS ISSUE NEEDS TO BE ADDRESSED BY THE MANUFACTURER BECAUSE OF ITS DANGEROUSLY SERIOUS NATURE. *TR
NHTSA ODI #10606377
41,000 miles · May 10, 2014
Power Train
ON MULTIPLE OCCASIONS STARTING IN THE BEGINNING OF THE YEAR MY CAR STARTED STALLING AND WOULD JUST CUT OFF IN THE MIDDLE OF THE STREET. IT HAPPENED MANY TIMES AFTER THAT SO I TOOK IT TO MY LOCAL FIRESTONE BECAUSE MY CAR WAS OUT OF WARRANTY. THEY SUGGESTED IT MAY BE BAD GAS AND THEY DID A THROTTLE BODY FLUSH. SO BETWEEN THE FLUS…
Read full complaint
ON MULTIPLE OCCASIONS STARTING IN THE BEGINNING OF THE YEAR MY CAR STARTED STALLING AND WOULD JUST CUT OFF IN THE MIDDLE OF THE STREET. IT HAPPENED MANY TIMES AFTER THAT SO I TOOK IT TO MY LOCAL FIRESTONE BECAUSE MY CAR WAS OUT OF WARRANTY. THEY SUGGESTED IT MAY BE BAD GAS AND THEY DID A THROTTLE BODY FLUSH. SO BETWEEN THE FLUSH AND USING MID GRADE GAS FROM A DIFFERENT STATION IT WORKED FOR ABOUT 1,000 MILES THEN THE PROBLEM STARTED AGAIN. MY CAR WOULD SHAKE AND REV AND ON MANY TIMES CUT OFF IN THE MIDDLE OF AN INTERSECTION, THANK GOD IT NEVER CAUSED AN ACCIDENT ESPECIALLY WITH MY 2YR OLD DAUGHTER BEING WITH ME MOST OF THE TIME. I TOOK IT TO FORD DEALER AND AFTER THE $100 DIAGNOSTIC THEY TOLD ME THE THROTTLE BODY WAS DEFECTIVE AND FORD HAD RECALLED MANY THROTTLE BODIES RECENTLY JUST NOT FOR MY CAR YET AND THE THROTTLE BODY IS NOT PART OF THE DRIVE TRAIN SO IT'S NOT COVERED. SO I HAD TO PAY $600 THAT I REALLY DIDN'T HAVE TO GET THIS ISSUE CORRECTED AFTER PAYING OVER $500 LATE LAST YEAR TO FIX THE BRAKE BOOSTER ON A 2012 VEHICLE. I HAVE HAD SO MANY PROBLEMS WITH THIS VEHICLE AND THIS NEW THROTTLE BODY ISSUE IS THE LAST STRAW. I WILL NEVER BUY ANOTHER FORD PRODUCT AGAIN. *TR
NHTSA ODI #10587571
36,000 miles · Nov 18, 2013
Power Train
WHILE DRIVING THE VEHICLE LOSSES ALL POWER AND A POWER TRAIN FAILURE ERROR MESSAGE IS DISPLAYED. THE THROTTLE BECOMES UNRESPONSIVE AND YOU CANNOT ACCELERATE. WHEN THE CAR STOPS MOVING, THE ENGINE BEGINS TO SHAKE VIOLENTLY AND SHUTS ITSELF OFF. *TR
NHTSA ODI #10552750
40,000 miles · Nov 1, 2013
Power Train
TL* THE CONTACT OWNS A 2012 FORD EDGE. THE CONTACT STATED THAT THAT THE VEHICLE FAILED TO RECOGNIZED THAT IT WAS IN THE PARK POSITION AND AS A RESULT, IT PREVENTED THE SEATS FROM RECLINING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SHIFT ASSEMBLY CASING WAS DEFECTIVE AND NEEDED TO BE REPLACED. T…
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD EDGE. THE CONTACT STATED THAT THAT THE VEHICLE FAILED TO RECOGNIZED THAT IT WAS IN THE PARK POSITION AND AS A RESULT, IT PREVENTED THE SEATS FROM RECLINING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SHIFT ASSEMBLY CASING WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE . THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 40,000.
NHTSA ODI #10550544
Mileage unknown · Jun 5, 2013
EnginePower Train
AFTER SEEING THE RECENT ISSUES W/ THE FORD V6 ECOBOOST ENGINE, I THOUGHT IT WISE TO TELL ABOUT THE 2.0L ECOBOOST ENGINE IN MY EDGE. AFTER OWNING THE VEHICLE LESS THAN A YEAR, I WAS DRIVING THRU A NEIGHBORHOOD AT A VERY SLOW PACE, I STARTED TO MAKE A RIGHT TURN & THE CAR SIMPLY DIED. NO SHAKING, NO WARNING. LOST ALL POWER STEERIN…
Read full complaint
AFTER SEEING THE RECENT ISSUES W/ THE FORD V6 ECOBOOST ENGINE, I THOUGHT IT WISE TO TELL ABOUT THE 2.0L ECOBOOST ENGINE IN MY EDGE. AFTER OWNING THE VEHICLE LESS THAN A YEAR, I WAS DRIVING THRU A NEIGHBORHOOD AT A VERY SLOW PACE, I STARTED TO MAKE A RIGHT TURN & THE CAR SIMPLY DIED. NO SHAKING, NO WARNING. LOST ALL POWER STEERING & ENGINE COMPRESSION. TURNED OFF, RESTARTED & ALL WAS WELL. TOOK TO DEALERSHIP THE NEXT WEEK, IF WE CANT REPLICATE IT WE CANT FIX IT. LAST MONTH, MY WIFE WAS TURNING RIGHT SLOWLY INTO A PARKING LOT & IT HAPPENED AGAIN. THIS TIME FORD KEPT THE CAR FOR OVER A WEEK TRYING TO DUPLICATE THE ISSUE, NO LUCK. IF WE CANT FIND IT, WE CANT FIX IT. I WAS TOLD IT COULD BE NUMEROUS THINGS & NO BULLETINS OR FIXES AT THIS TIME. SO MY PREGNANT WIFE NOW DRIVES A BRAND NEW VEHICLE THAT DECIDES TO DIE IN TRAFFIC WHILE TURNING, MAYBE IN FRONT OF ONCOMING TRAFFIC,. I HAVE READ NUMEROUS COMPLAINTS ONLINE ABOUT THIS SAME THING HAPPENING TO OTHER EDGE ECOBOOST VEHICLES, BUT ALAS NO FIX. IN THE RECENT ARTICLES I HAVE BEEN READING IT SAYS THE 2.0L ECOBOOST ENGINE HAS NOT BEEN AFFECTED, I FEEL THAT IS INCORRECT. I THINK FORD NEEDS TO LOOK INTO ALL ECOBOOST ENGINES & FIND A FIX NOW OR REPLACE THE VEHICLE. *TR
NHTSA ODI #10515140
10,000 miles · May 24, 2013
Power Train
VEHICLE EXPERIENCES EXTREMELY HARD TRANSMISSION SHIFTS. WHEN SLOWING DOWN AND GOING TO SPEED BACK UP, TRANSMISSION APPEARS TO SHIFT INTO WRONG GEAR CAUSING VEHICLE TO BANG HARD THEN SHIFT INTO CORRECT GEAR TO THE POINT THE ENTIRE VEHICLE SHAKES/FEELS LIKE YOU WERE HIT. VEHICLE ALSO ENGAGES HARD INTO 1ST/2ND GEAR WHEN COASTING …
Read full complaint
VEHICLE EXPERIENCES EXTREMELY HARD TRANSMISSION SHIFTS. WHEN SLOWING DOWN AND GOING TO SPEED BACK UP, TRANSMISSION APPEARS TO SHIFT INTO WRONG GEAR CAUSING VEHICLE TO BANG HARD THEN SHIFT INTO CORRECT GEAR TO THE POINT THE ENTIRE VEHICLE SHAKES/FEELS LIKE YOU WERE HIT. VEHICLE ALSO ENGAGES HARD INTO 1ST/2ND GEAR WHEN COASTING AND REAPPLYING GAS. I HAVE EXPERIENCED THE HARD SHIFT INTO GEAR ISSUE MULTIPLE TIMES (AT LEAST 10-15) AND 1ST/2ND GEAR ENGAGE BUMP EVERYDAY. THIS IS A PROBLEM THAT CONTINUES TO GET WORSE AND WILL PROBABLY LEAD TO TRANSMISSION FAILURE. *TR
NHTSA ODI #10513381
2,500 miles · Aug 13, 2012
Power Train
PURCHASED THIS CAR BRAND NEW. THE TRANSMISSION HAS BEEN A PROBLEM FROM THE START. DRIVING UNDER NORMAL, DRY CONDITIONS WHEN THROTTLE IS DECELERATED AND THEN A SLIGHT PAUSE BEFORE ACCELERATION THE CAR SLAMS HARD INTO GEAR WHEN YOU BEGIN TO THROTTLE AGAIN. THE FIRST EVENT THE DEALERSHIP "FLASHED THE COMPUTER" AND SAID THAT WOULD F…
Read full complaint
PURCHASED THIS CAR BRAND NEW. THE TRANSMISSION HAS BEEN A PROBLEM FROM THE START. DRIVING UNDER NORMAL, DRY CONDITIONS WHEN THROTTLE IS DECELERATED AND THEN A SLIGHT PAUSE BEFORE ACCELERATION THE CAR SLAMS HARD INTO GEAR WHEN YOU BEGIN TO THROTTLE AGAIN. THE FIRST EVENT THE DEALERSHIP "FLASHED THE COMPUTER" AND SAID THAT WOULD FIX IT. THE SECOND INCIDENT HAS NETTED NO RESULTS. THE DEALER HAD MY CAR FOR 10 DAYS WITHOUT EVEN LOOKING AT IT CLAIMING A LACK OF CERTIFIED TECHNICIAN. THEY SET AN APPOINTMENT FOR ME ON 7/30/2012 AND BY 8/9/12 HAD STILL NOT LOOKED AT MY CAR. *TR
Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
Consequence & remedy
Consequence: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.
Ford Motor Company (Ford) is recalling certain model year 2012-2013 Edge vehicles manufactured from September 2, 2010, through April 25, 2013, and equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel line with one that does not have a damper, free of charge. The safety recall began on February 25, 2014. Owners may contact Ford at 1-866-436-7332. Ford's number for this recall is 13S13. IMPORTANT: This recall supersedes recall 12V-438. All vehicles that have been remedied under the previous recall need to have the current remedy applied.
Ford is recalling certain 2012 Edge vehicles manufactured from September 2, 2010, through October 31, 2011, equipped with 2.0L engines. The fuel line pulse damper metal housing may crack as a result of an improper manufacturing process. A cracked fuel line pulse damper housing may result in a combination of fuel odor, weepage, or a continuous leak while the fuel system is pressurized.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will repair the vehicles free of charge. The safety recall began on September 27, 2012. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Additional source detail variants (3)
Interior Lighting
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages:doors:latch
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
Latches/locks/linkages
The Office of Defects Investigation (ODI) opened this investigation on September 28, 2016 based on allegations that the door ajar light located on the instrument cluster stays on all of the time even when all doors are closed and fully latched on 2011-2013 model year Ford Edge vehicles.When the light is illuminated continuously, vehicle occupants cannot be certain if any of the doors are properly latched.Reported safety consequences as a result of this issue include doors opening while driving (because doors were initially not latched properly), doors cannot be locked while driving, and the interior dome lights staying on continuously. Ford data received from the Information Request letter corresponding to this investigation indicates the failures were caused by contamination of the electrical contacts on the switch located within each door latch that tells the vehicle if the door is open or closed.All four doors contain the same latch design and switch.According to Ford, the Body Control Module (BCM) monitors the position of the switch and continuously samples it to detect a state of change.After a closed door state is detected, a continuous wetting current designed to keep the electrical contacts clean is sent from the BCM to the switches as long as the BCM is active.Beginning with the 2011 model year Edge vehicles, a change in BCM strategy resulted in a reduction of the wetting current sent out to clean the switch contacts by more than 75%.Over time, this low level of current is not sufficient to keep the switch contacts clean and contamination build up causes them to fail as described above.During the course of this investigation, ODI has identified a total of 1,983 complaints related to the door ajar light.Of these complaints, 14 indicated that a door opened while driving.Twelve of the 14 door opening events were situations where an occupant of the vehicle (often a child) opened a passenger door because the doors were not locked.The remaining two complaints involved a door opening on its own because the driver was unaware that the door was unlatched.There were no accidents but one complainant reported that a shoulder injury was caused by the driver having to repeatedly slam the door in an effort to get the door ajar light to turn off.After reviewing all available data, an unreasonable risk to motor vehicle safety has not been identified.The door latches themselves continue to function properly, remaining securely latched until acted upon by a driver or passenger.Child safety locks on the rear doors continue to function properly and can be used to prevent the rear doors from opening via the inside door handles.Vehicle crashworthiness is not affected by the lock condition of the doors and all active safety systems continue to function normally even if the vehicle BCM believes one or more doors is open.In addition, no accidents or accident related injuries have been reported.A safety-related defect trend has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor the issue and reserves the right to take future action if warranted by the circumstances.ODI numbers for the reports cited above are shown in the attached document.
2012 Ford Edge Problems, Complaints & Recalls | Skip That Year
Illustration