PROBLEM: HESITATION ON ACCELERATION, ROUGH IDLES, LOSS OF POWER UPON ACCELERATION. INJECTOR FOUND CLOGGED ON 12-2006. REPLACED TURBO ASSEMBLY AND COLD AIR BOOT ON 12/20/2006. FILED WRITTEN COMPLAINT TO FORD IN APRIL 2006 FOR RECURRING ENGINE ISSUES. FORD NEVER ANSWERED. ON 1/30/09 TRUCK NOT RUNNING AND FORD REPLACED THE TRANS…
Read full complaint
PROBLEM: HESITATION ON ACCELERATION, ROUGH IDLES, LOSS OF POWER UPON ACCELERATION. INJECTOR FOUND CLOGGED ON 12-2006. REPLACED TURBO ASSEMBLY AND COLD AIR BOOT ON 12/20/2006. FILED WRITTEN COMPLAINT TO FORD IN APRIL 2006 FOR RECURRING ENGINE ISSUES. FORD NEVER ANSWERED. ON 1/30/09 TRUCK NOT RUNNING AND FORD REPLACED THE TRANSMISSION. ASKED FORD SERVICE TO CHECK ROUGH RUNNING AND ENGINE POWER LOSS BUT COMPUTER SHOWED NO CODES. TOOK TRUCK INTO FORD ON 1/21/20011 FOR BRAKES AND VEHICLE NOT RUNNING PROPERLY EVEN AFTER WARM UP. DIAGNOSIS FROM FORD --- FOUND RUST IN THE FUEL FILTER, WAS TOLD FUEL TANK NEEDED REPLACED AS WELL AS INJECTORS AND INJECTOR PUMP AND FUEL LINES. COST TO REPLACE $5000 OR MORE. WARRANTY RAN OUT NOVEMBER 2010. FORD IS NOW REQUIRING VEHICLE OWNERS TO REPLACE THEIR FUEL TANKS AND ANY ANCILLARY PARTS AT THEIR OWN COST. FORD HAD TO OF KNOWN THAT THERE WAS A PROBLEM WITH THE FUEL TANKS DELAMINATING AFTER 2004. AS A SMALL BUSINESS OWNER IN THIS ECONOMY HAVING TO SPEND EXTRA MONEY ON A PROBLEM THAT COULD AND SHOULD HAVE BEEN TAKEN CARE OF UNDER WARRANTY IS EGREGIOUS. MY VEHICLE CURRENTLY HAS 113,000 MILES AND TO ALREADY HAVE TO REPLACE A TRANSMISSION AND NOW THE FUEL TANK IS INDICATIVE OF A DEFECTIVE VEHICLE. FORD IS NEGLIGENT IN NOT ACKNOWLEDGING A POTENTIALLY DANGEROUS TO LIFE SAFETY PROBLEM.
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN VANS, A DIODE IN THE ANTI-LOCK BRAKING SYSTEM (ABS) MODULE MAY EXPERIENCE AN ELECTRICAL SHORT.
Consequence & remedy
Consequence: THE ELECTRICAL SHORT MAY CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, OR THE MODULE MAY OVERHEAT RESULTING IN A BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION MAY OCCUR WHILE THE VEHICLE IS BEING DRIVEN OR UNATTENDED.
Remedy: DEALERS WILL INSTALL A NEW FUSE IN THE ABS CIRCUIT AND INSTALL A HEAT SHIELD OVER THE ABS MODULE. THE RECALL BEGAN ON OCTOBER 15, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.
ON CERTAIN VANS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
Consequence & remedy
Consequence: THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. THE RECALL BEGAN SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673. ALSO FORD IS EXTENDING THE LIMITED WARRANTY (FOR A ONE TIME REPLACEMENT) OF THE ABS MODULE FOR A TOTAL OF 10 YEARS OR 150,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF YOUR VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL SEPTEMBER 30, 2005.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE09055 · Hvac Switch Failures
Opened Dec 7, 2009 · Closed Apr 21, 2010
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
2004 Ford E-450 Problems, Complaints & Recalls | Skip That Year
Illustration