NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
35 reportsClear category filter80,000 miles · Mar 16, 2018
Service Brakes, Hydraulic
TL* THE CONTACT OWNS A 1996 DEMON HORNET RV ON A 1995 FORD E-350 CHASSIS. WHILE INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT BOTH FRONT ROTORS HAD FRACTURED WHILE BEING STORED FOR THE WINTER. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 1996 DEMON HORNET RV ON A 1995 FORD E-350 CHASSIS. WHILE INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT BOTH FRONT ROTORS HAD FRACTURED WHILE BEING STORED FOR THE WINTER. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 80,000.
NHTSA ODI #11079799
73,000 miles · Sep 13, 2006
Service Brakes, Hydraulic
1995 E-350 MOTORHOME THE ABS SYSTEM FAILED TWICE AND WAS REPAIRED BOTH TIMES. *KB THE ABS WAS OUT OF WARRANTY. THE CONSUMER FEELS THAT THE ABS SHOULD NOT HAVE FAILED AT SUCH LOW MILEAGE. THE FIRST ABS FAILED AT 37000 MILES. THE SECOND ONE FAILED AT 73000 MILES. *NM
NHTSA ODI #10169080
Mileage unknown · Jul 22, 2002
Service Brakes, Hydraulic
BRAKES ARE LEAKING AND RUBBING AGAINST EXHAUST, COULD RUB A HOLE. CONSUMER FEELS VEHICLE MAY NOT STOP IN A COLLISION.*AK
NHTSA ODI #8014445
Mileage unknown · May 6, 2002
Service Brakes, Hydraulic
TOMS RIVER SCHOOLS VEHICLE MAINT. DEPT MAINTAINS 17 FORD E-350 MINI SCHOOL BUSES, 1995 AND 1998 MODEL YEARS. THIS BRAKE HOSE FAILURE WAS DUE TO A RUSTED PORTION OF THE HOSE ASSEMBLY . THE AREA THAT RUSTED AWAY IS THE CRIMPED CONNECTION WHICH JOINS THE RUBBER HOSE TO THE STEEL FITTING END OF THE HOSE ASSEMBLY. THIS RUST IS NOT VI…
Read full complaint
TOMS RIVER SCHOOLS VEHICLE MAINT. DEPT MAINTAINS 17 FORD E-350 MINI SCHOOL BUSES, 1995 AND 1998 MODEL YEARS. THIS BRAKE HOSE FAILURE WAS DUE TO A RUSTED PORTION OF THE HOSE ASSEMBLY . THE AREA THAT RUSTED AWAY IS THE CRIMPED CONNECTION WHICH JOINS THE RUBBER HOSE TO THE STEEL FITTING END OF THE HOSE ASSEMBLY. THIS RUST IS NOT VISIBLE WHILE DOING A ROUTINE INSPECTION OF THE BRAKE SYSTEM BECAUSE IT IS COVERED BY A RUBBER SLEEVE!. APPARANTLY WATER/MOISTURE IS COLLECTING UNDER THIS RUBBER SLEEVE AND CORRODING THE STEEL CRIMPED AREA OF THE FITTING UNTIL THERE IS NO MORE OF A SECURE CONNECTION OF THE RUBBER HOSE TO THE STEEL , THEN WHEN THE BRAKES ARE APPLIED AND THE FLUID IS PRESSURIZED IN THE BRAKE SYSTEM THE RUBBER HOSE WILL BLOW AWAY FROM THE STEEL FITTING!...I BELIEVE THIS IS A SERIOUS PROBLEM AS IT IS SUDDEN BRAKE LOSS, MULTIPLIED BY THE FACT THAT A ROUTINE PREVETIVE MAINTENANCE CHECK OF THE BRAKE HOSES DOES NOT REVEAL THE RUSTED/FAULTY CONNECTION BECAUSE OF THE RUBBER SLEEVE COVERING IT.
NHTSA ODI #761579
Mileage unknown · May 21, 2001
Service Brakes, Hydraulic
FRONT BRAKE ROTORS WERE CRACKED. DEALER HAS ADVISED CONSUMER THAT 2 SERVICE BULLETINS WERE ISSUED. ALSO, STATED THAT FORD CORPORATION HAS ADVISED THAT ROTORS WERE "DEFECTIVE".*AK ABS LIGHT ILLUMINATED. CONSUMER STATES VEHICLE DOES NOT TOW A CAR. *SLC
NHTSA ODI #888795
Mileage unknown · May 21, 2001
Service Brakes, Hydraulic
FRONT BRAKE ROTORS ARE CRACKED WHICH WAS NOTICED DURING A STATE INSPECTION. ALSO, ABS LIGHT WILL COME ON WHILE VEHICLE IS IN OPERATION AND HITS A BUMP. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS. *THERE IS A TECHNICAL SERVICE BULLETIN THAT HAS BEEN ISSUED FOR THIS DEFECT.*AK *JB
NHTSA ODI #888778
Mileage unknown · Jan 31, 2001
Service Brakes, Hydraulic
ABS WOULD COME ON SPORADICALLY, BRAKES WOULD LOCK UP, SLIDE ON SNOW, HAVE A ROCK HARD PEDAL, AND CONSUMER WOULD SLIDE THROUGH STOPS, ABS SENSOR WAS REPLACED IN 2001, HOWEVER AFTER ONE WEEK, THE LIGHT IS BACK ON WITH ABS NOT FUNCTIONING, DEALER CAN NOT FIND ANY PROBLEMS. *SLC
NHTSA ODI #785245
Mileage unknown · Jan 16, 2001
Power TrainService Brakes, Hydraulic
ABS LIGHT KEPT COMING ON. TOOK VEHICLE TO DEALER & MECHANIC COULD NOT LOCATE CAUSE OF PROBLEM. WENT HOME, AND VEHICLE STARTED VIBRATING WHEN LIGHT CAME ON AGAIN AND BRAKES WERE APPLIED. TOOK IT BACK TO DEALER, AND MECHANIC REPLACED SOME OF PARTS ON BRAKE BOOSTER/UNIVERSAL JOINTS/ROTORS AND PADS/MASTER CYLINDER, AND OTHER PARTS…
Read full complaint
ABS LIGHT KEPT COMING ON. TOOK VEHICLE TO DEALER & MECHANIC COULD NOT LOCATE CAUSE OF PROBLEM. WENT HOME, AND VEHICLE STARTED VIBRATING WHEN LIGHT CAME ON AGAIN AND BRAKES WERE APPLIED. TOOK IT BACK TO DEALER, AND MECHANIC REPLACED SOME OF PARTS ON BRAKE BOOSTER/UNIVERSAL JOINTS/ROTORS AND PADS/MASTER CYLINDER, AND OTHER PARTS. PROBLEM STILL EXIST. A DIFFERENT MECHANIC DID NOT KNOW WHAT CAUSED PROBLEM. INFORMED OWNER TO TRADE VEHICLE IN. *AK
NHTSA ODI #878215
Mileage unknown · Nov 13, 2000
Service Brakes, Hydraulic
OWNER HAS A FLEET OF 22 1994-1995 VEHICLES THAT ARE STARTING TO SHOW A HIGH RATE OF FAILURES OF THE UPPER BRAKE SHOE ANCHOR IS BREAKING OUT OF THE BACKING PLATE, THIS CAUSES THE BRAKE SHOES TO CONTACT THE OUTBOARD FACE OF THE BRAKE DRUM, WHICH CAN ALSO CAUSE DAMAGE TO THE WHEEL CYLINDER AND CAUSE BRAKE FAILURE. *SLC
NHTSA ODI #557301
Mileage unknown · Sep 9, 2000
Service Brakes, Hydraulic
THIS VEHICLE DEVELOPED CRACKS ON BOTH BRAKE ROTORS THRU TO THE FINS. I HAVE BOTH IN MY POSSESSION. I HAVE BEEN IN CONTACT WITH FORD MOTOR CO. AND THEY DENY ANY RESPONSIBILITY AS MY WARRANTY HAD EXPIRED IN MAY OF 2000. I HAD A WOBBLE IN THE STEERING WHEEL FOR SOMETIME PRIOR TO MAY OF 2000 BUT DID NOT REALIZE WHAT IT WAS. IT BECAM…
Read full complaint
THIS VEHICLE DEVELOPED CRACKS ON BOTH BRAKE ROTORS THRU TO THE FINS. I HAVE BOTH IN MY POSSESSION. I HAVE BEEN IN CONTACT WITH FORD MOTOR CO. AND THEY DENY ANY RESPONSIBILITY AS MY WARRANTY HAD EXPIRED IN MAY OF 2000. I HAD A WOBBLE IN THE STEERING WHEEL FOR SOMETIME PRIOR TO MAY OF 2000 BUT DID NOT REALIZE WHAT IT WAS. IT BECAME INCEASINGLY WORSE, WHEN I SPOKE WITH THE LOCAL FORD DEALER THEY REFERRED ME TO AUTOMOTIVE & RV SPECIALISTS AS THE DEALER COULD NOT WORK ON A LARGE VEHICLE. THE ROTORS WERE REPLACED WITH NAPA ROTORS AS RV SPECIALISTS OWNER MR. DALLAS SHARK SAID FORD WAS HAVING PROBLEMS WITH CASTING IN THEIR ROTORS AND IT WOULD NOT MAKE SENSE TO REPLACE WITH TWO MORE FORD ROTORS. FORD HAS DENIED REINBURSEMENT FOR THIS REASON. MR SHARK STATED THAT THIS WAS A SERIOUS SAFETY ISSUE AS THE ROTORS COULD HAVE EXPLODED AT ANYTIME LEAVING ME WITH NO BRAKING CAPABILITY AT ALL. HE WILL BE HAPPY TO ANSWER ANY QUESTIONS ON MY BEHALF. HE CAN BE CONTACTED AT 520-532-0086 OR 800 N. 16TH ST. SHOW LOW, AZ 85901. I HAVE DOCUMENTION FROM THE FORD MOTOR CO. AVAILABLE IF NEEDED IN THIS INVESTIGATION. THANK YOU
NHTSA ODI #730866
Official recalls
3Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Feb 4, 2008
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Aug 1, 2006
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration