WHEN I AM DRIVING MY 1994 E350 DIESEL TRUCK, THERE WILL BE A SUDDEN LOSS OF POWER STEERING AND BRAKES RESULTING IN A LOSS OF ABILITY TO STOP THE TRUCK. FORTUNATELY, I WAS TRAVELING AT A SLOW SPEED WITH PLENTY OF CLEARANCE AHEAD OF ME AND WAS ABLE TO PULL THE TRUCK OFF THE ROAD AND HAVE IT TOWED IN TO A MECHANIC SHOP. SO …
Read full complaint
WHEN I AM DRIVING MY 1994 E350 DIESEL TRUCK, THERE WILL BE A SUDDEN LOSS OF POWER STEERING AND BRAKES RESULTING IN A LOSS OF ABILITY TO STOP THE TRUCK. FORTUNATELY, I WAS TRAVELING AT A SLOW SPEED WITH PLENTY OF CLEARANCE AHEAD OF ME AND WAS ABLE TO PULL THE TRUCK OFF THE ROAD AND HAVE IT TOWED IN TO A MECHANIC SHOP. SO FAR THE SERPENTINE BELT HAS BEEN REPLACED, A NEW TENSIONER INSTALLED, AND A NEW IDLER PUT IN. UNFORTUNATELY, THE PROBLEM PERSISTS AND IS VERY DANGEROUS. I SEE THAT A RECALL WAS ISSUED # 9610030000 BY NHTSA FOR 1994 FORD ECONOLINE E350 TRUCKS WITH SERPENTINE BELT PROBLEMS AND THAT THE FORD DEALERS HAVE AGREED TO REMEDY THE PROBLEM. WHEN I CALL FORD, THEY SAY THAT MY VIN# IS NOT AMONG THOSE THAT WERE RECALLED. THIS IS THE 3RD TIME I HAVE LOST POWER STEERING AND BRAKES DUE TO A SERPENTINE BELT MALFUNCTION. I BELIEVE THAT MORE VEHICLES MANUFACTURED THAT YEAR SHOULD BE INCLUDED IN THE RECALL. *TR
NHTSA ODI #10280328
Mileage unknown · Dec 1, 2006
Engine And Engine CoolingFire
1994 E350 CAUGHT ON FIRE. *TS A MECHANIC TOLD THE CONSUMER THE TRUCK HAD A BAD WATER PUMP AND THAT WAS THE CAUSE OF THE FIRE. *JB
NHTSA ODI #10176426
Mileage unknown · Feb 11, 2004
Engine And Engine CoolingTires
THERE ARE METAL LINES POSITIONED OVER THE LEFT REAR TIRE. THE DEBRIS AND WATER FROM THE ROAD CAUSED THESE METAL LINES TO RUST AND LEAK, CAUSING ANTIFREEZE TO DROP ONTO THE TIRE. THE CONSUMER IS CONCERNED THAT THE ANTIFREEZE COULD CAUSE THE TIRES TO LOSE TRACTION WHILE DRIVING. *AK
NHTSA ODI #10057944
Mileage unknown · Aug 21, 2002
Engine And Engine Cooling
EXHAUST MANIFOLD FAILED DUE TO EXCESSIVE HEAT AND THE TYPE OF MATERIAL USED, THE CONSUMER IS REQUESTING THAT THE MANUFACTURER PAY FOR AT LEAST HALF THE BILL FOR THE FAILED COMPONENT. NLM
NHTSA ODI #567176
Mileage unknown · Jan 11, 2000
Engine And Engine Cooling
WHEN TRAVELING FAN BELT FELL OFF PULLEY, CAUSING COMPLETE LOSS OF POWER STEERING AND BRAKES. ALSO, TWO YEARS AGO RECALL OMP96B82 WAS ISSUED CONCERNING THE SAME PROBLEM, RECALL REPAIR WORK WAS DONE. HOWEVER, PROBLEM HAS OCCURRED AGAIN. VEHICLE CURRENTLY AT DEALER AWATING REPAIRS. *AK *ML
NHTSA ODI #854890
Mileage unknown · Apr 9, 1997
Engine And Engine Cooling
FOLLOWING A RECALL FOR REPLACEMENT OF A PULLEY, DEALER INFORME DOWNER THAT THE VACUUM PUMP LOCKED UP. *AK
NHTSA ODI #809984
Mileage unknown · Nov 22, 1996
Engine And Engine CoolingFireInjury
VEHICLE FIRE, CAUSING INJURY.
NHTSA ODI #511660
Mileage unknown · Jul 5, 1995
Engine And Engine Cooling
THE TENSIONER ON THE BUS GOES OUT. THIS IS THE FOURTH TIME. TT
Cummings Mobility Conversion & Supply, Inc. (Cummings) is recalling various model year 1994-2011 Ford and Chevrolet vans equipped with Braun NCL-2, and NVL-2 wheel chair lifts manufactured November 20, 2006, through September 10, 2010. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.
Consequence & remedy
Consequence: A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.
Remedy: Braun Corporation notified all the vehicle owners, and Cummings Mobility replaced the recalled parts with new parts, free of charge. The recall was completed as of April 10, 2014. Owners may contact Cummings customer service at 1-800-639-5438.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
THESE VEHICLES DO NOT COMPLY WITH FMVSS 105, "HYDRAULIC BRAKE SYSTEMS." THE PARKING BRAKE APPLICATION FORCE FOR A FOOT OPERATED CONTROL SYSTEM SHOULD NOT EXCEED 125 POUNDS TO HOLD THE VEHICLE ON A 30% GRADE. INTERFERENCE BETWEEN THE PARKING BRAKE PEDAL AND A WIRE HARNESS MAY INCREASE THE NEEDED PEDAL FORCE TO GREATER THAN 125 POUNDS TO SET THE PARKING BRAKE TO HOLD THE VEHICLE ON THE 30% GRADE.
Consequence & remedy
Consequence: THE INTERFERENCE BETWEEN THE FOOT PEDAL AND THE WIREHARNESS MAY NOT ALLOW THE PARKING BRAKE TO FULLY SET. IF THIS OCCURS WHEN THEVEHICLE IS PARKED ON AN INCLINE, IT MAY ROLL, CAUSING A CRASH.
Remedy: FINAL STAGE MANUFACTURERS WILL BE INFORMED OF THIS CONDITION AND PROVIDED WITH PARTS AND INSTRUCTIONS NECESSARY TO CORRECT THIS SITUATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
1994 Ford E-350 Problems, Complaints & Recalls | Skip That Year
Illustration