I WAS DRIVING AT 60 MPH WHEN I BEGAN DECELERATING AND REALIZED ENGINE HAD SHUT OFF. I COASTED TO A STOP. I WAS GETTING TOOLS TO CHECK RELAYS WHEN I NOTICED FIRE AT REAR WHEEL, DRIVER SIDE, AT GAS TANK. CALLED CLOSEST FIRE DEPARTMENT. 6/9/06. PARKING BRAKE LINE ON FIRE WITH ABS LINE. HAD WIRING REPAIRED. JULY 16,2006 BRAKES FEL…
Read full complaint
I WAS DRIVING AT 60 MPH WHEN I BEGAN DECELERATING AND REALIZED ENGINE HAD SHUT OFF. I COASTED TO A STOP. I WAS GETTING TOOLS TO CHECK RELAYS WHEN I NOTICED FIRE AT REAR WHEEL, DRIVER SIDE, AT GAS TANK. CALLED CLOSEST FIRE DEPARTMENT. 6/9/06. PARKING BRAKE LINE ON FIRE WITH ABS LINE. HAD WIRING REPAIRED. JULY 16,2006 BRAKES FELT LIKE THEY WERE LOCKING, REAR WAS SMOKING AGAIN, LOOKED LIKE FIRE AT GAS TANK. JULY 17 HAD MECHANIC CHECK ALL BRAKES WHICH WERE EXCELLENT EXCEPT PARKING BRAKE LINE BENT, BUT RELEASED. JULY 19, BRAKES LOCKING UP A LITTLE. JULY 20, COULDN'T DRIVE WITHOUT REVERSE/FORWARD AND STILL DIDN'T WANT TO GO. I SELL ICE CREAM TO LITTLE CHILDREN WHILE MY VAN IS RUNNING. PARKING BRAKES WORK BUT WON'T RELEASE FULLY. APPEARED TO BE VINYL LINING AT FLOOR LEVEL INTERFERING, BUT MAY HAVE BEEN WIRING. HAD A SECOND FIRE ON GROUND BATTERY TERMINAL AND INSIDE HOOD ON JUNE 16,2006 CALLED FIRE DEPARTMENT. DON'T KNOW CAUSE. REPLACED BURNED WIRING ONLY. ALL ELSE WORKED. ALSO, IT APPEARS THE LEAKY FILLER HOSE WAS NEVER REPLACED ON THIS VAN. INTERIOR LIGHT HAD FIRE PATTERN WHEN BOUGHT SECOND HAND. I WAS NOT AWARE THERE WAS A RECALL. *NM
NHTSA ODI #10163012
Mileage unknown · Feb 23, 2001
Parking Brake
PARKING BRAKE SLIPS OFF ON ANY LEVEL SURFACE. RACHET MECHANISM NEEDED TO BE REPLACED. THIS IS WAS 2ND TIME IT HAD HAPPENED. *AK
NHTSA ODI #881214
Mileage unknown · Jan 3, 2001
Parking BrakeSuspension
FRONT BALL JOINTS REPLACED TWICE. NEEDED TO BE DONE AGAIN. ALSO, PARK BRAKE REPLACED 3 TIMES. *AK
NHTSA ODI #877336
Mileage unknown · Apr 20, 1995
Parking BrakeService Brakes, HydraulicVehicle Speed Control
BRAKES LOCKS UP; HAVE TO PUSH ACCELERATOR HARD TO MOVE VEHICLE; ALSO, EMERGENCY BRAKES LOCKS UP INTERMITTENTLY. TT
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
1993 Ford E-350 Problems, Complaints & Recalls | Skip That Year
Illustration