The contact owns a 1993 Ford E-150. The contact stated that upon attempting to pull into a parking space and turning the steering wheel, she heard an abnormal sound coming from underneath the front driver's side seat and the steering wheel seized. There was no warning light illuminated. The contact contacted AAA who inspected th…
Read full complaint
The contact owns a 1993 Ford E-150. The contact stated that upon attempting to pull into a parking space and turning the steering wheel, she heard an abnormal sound coming from underneath the front driver's side seat and the steering wheel seized. There was no warning light illuminated. The contact contacted AAA who inspected the vehicle and informed the contact that the gear box had detached from the subframe. The vehicle was towed to an independent mechanic where it was diagnosed that the front driver's side subframe had three holes and one of the holes had expanded significantly and needed to be welded prior to fastening the gear box to the subframe. The independent mechanic informed the contact that they could not weld the subframe. The dealer was notified and informed the contact that the next availability was in approximately two months. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was approximately 200,000.
NHTSA ODI #11472754
Mileage unknown · Jan 29, 2001
Power TrainVehicle Speed ControlCrash
THREE TIMES THE LEFT FRONT INNER WHEEL BEARING HAS DISINTEGRATED ALLOWING ROTOR TO FALL DOWN ON SPINDLE, WITH NO INDICATION OF BEARING FAILURE, NO NOISE WHATSOEVER.THIS MOST RECENT INCIDENT TIRE WHEEL ROTOR CAME COMPLETELY OFF SPINDLE AT 70 M.P.H. THE OUTER BEARING STILL FULL OF GREASE . INDICATION THAT THERE IS INSTANTANIOUS …
Read full complaint
THREE TIMES THE LEFT FRONT INNER WHEEL BEARING HAS DISINTEGRATED ALLOWING ROTOR TO FALL DOWN ON SPINDLE, WITH NO INDICATION OF BEARING FAILURE, NO NOISE WHATSOEVER.THIS MOST RECENT INCIDENT TIRE WHEEL ROTOR CAME COMPLETELY OFF SPINDLE AT 70 M.P.H. THE OUTER BEARING STILL FULL OF GREASE . INDICATION THAT THERE IS INSTANTANIOUS DISCENERGRATION OF INSIDE BEARING. I BELIEVE SPINDLE WAS TURNED TO SMALL BY A FEW THOUSANDS ALLOWING RACE TO BREAK LOOSE. I AM BLESSED TO HAVE WALKED AWAY FROM THIS ENGNEERING DIASTER CALLED FORD ECONOLINE. I AM 53 YEARS OLD @ HAVE HAD MORE PROBLEMS WITH THIS VAN THAN ALL OF THE OTHER VEHICLES I HAVE EVER OWNED.*AK
NHTSA ODI #740077
Mileage unknown · Oct 4, 1999
Engine And Engine CoolingPower TrainSteering
TRANSMISSION OPERATES POORLY WHEN VEHICLE TEMPERATURE IS HIGH, REPLACEMENT TRANSMISSION REPEATED BEHAVIOR. MJS
NHTSA ODI #548941
Mileage unknown · Aug 6, 1998
Power Train
WHILE DRIVING AT 65 MPH THE TRANSMISSION DISENGAGED. OWNER HAD TO DRIVE VEHICLE IN A SECOND. VEHICLE HAS BEEN REPAIRED AT OWNER'S EXPENSE. *AK
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.
Consequence & remedy
Consequence: THE OVERHEATING AND FIRES CAUSED BY THE NEON TRANSFORMER CAN RESULT IN DAMAGE TO THE LIGHTBEAM ASSEMBLY, THE ROOF OF THE VEHICLE, AND COULD RESULT IN A VEHICLE FIRE.
Remedy: MARK III DEALERS WILL MODIFY THE ASSEMBLIES TO ELIMINATE THE NEON LIGHTING FIXTURE IN THE VEHICLE AND REPLACE IT WITH INCANDESCENT LIGHTS OPERATING DIRECTLY FROM THE VEHICLE 12-VOLT BATTERY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE96072 · Loss Of Steering Control
Opened Dec 5, 1996 · Closed Apr 29, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1993 Ford E-150 Problems, Complaints & Recalls | Skip That Year
Illustration