Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 11 of 64 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 9 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
3 crash reports11 fire reports4 injury reports
What owners actually said
64 reports
Mileage unknown · Feb 26, 2002
Tires
ORGINIAL TIRES PURCHASED 10/13/98, FROM THEN UNTIL 10/31/00 TIRES WERE CHECKED ON SIX DIFFERENT TIMES BECAUSE OF VIBRATION. EACH TIME THE TIRES WERE EITHER ROTATED, BALANCED OR SHOCKS CHECKED. THEN ON 10/30 /00 THE LEFT REAR TIRE LOST A CHUNK OF THE TIRE WITH NO INJURY OR ACCIDENT, BUT WHEN IT WAS TAKEN IN TO RAPLACE THE TIRE, I…
Read full complaint
ORGINIAL TIRES PURCHASED 10/13/98, FROM THEN UNTIL 10/31/00 TIRES WERE CHECKED ON SIX DIFFERENT TIMES BECAUSE OF VIBRATION. EACH TIME THE TIRES WERE EITHER ROTATED, BALANCED OR SHOCKS CHECKED. THEN ON 10/30 /00 THE LEFT REAR TIRE LOST A CHUNK OF THE TIRE WITH NO INJURY OR ACCIDENT, BUT WHEN IT WAS TAKEN IN TO RAPLACE THE TIRE, I WAS TOLD THAT THE OTHER TIRES WERE SEPARATING AND NEEDED REPLACING.*AK (DOT NUMBER: VDHLW02208 TIRESIZE: D235175R15)
NHTSA ODI #758659
Mileage unknown · Jan 17, 2002
StructureFire
FIRE STARTED IN THE DOOR, APPEARED TO BE ELECTRICAL
NHTSA ODI #9005525
Mileage unknown · Aug 7, 2001
Engine And Engine Cooling
EXHAUST MANIFOLD BROKE, FUMES STARTED COMING INTO VEHICLE. MANIFOLD HAS BEEN REPLACED TWICE. CONTACTED FORD, AND FORD STATED IT WAS OUT OF WARRANTY.*AK
NHTSA ODI #893735
Mileage unknown · Jun 6, 2001
Power Train
BELL HOUSING FOR AUTOMATIC TRANSMISSION HAS CRACKED. TRANSMISSION IS SHIFTING FINE. HOWEVER, PROBLEM IS WITH TORQUE CONVERTER. CONSUMER WAS INFORMED THAT TRANSMISSION COULD DROP OUT OF VEHICLE WITH A CRACKED HOUSING. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
NHTSA ODI #889846
Mileage unknown · May 4, 2001
Fuel System, Gasoline
WHILE VEHICLE IS PARKED ON HILL, GAS WOULD LEAK OUT OF FUEL FILLER. *AK *JB
NHTSA ODI #887494
Mileage unknown · Feb 16, 2001
Engine And Engine Cooling
FUEL VENT LINE HOSE DEVELOPED CRACKS. WHEN TANK IS FULL WITH GAS VENT LINE LEAKS. FORD HAS NOT BEEN CONTACTED. *AK
NHTSA ODI #880726
Mileage unknown · Aug 18, 2000
Tires
THREE OF THESE TIRES HAVE BEEN REPLACED BY SEARS DUE TO TREAD SEPARATON.( DOT NUMBER: TIRE SIZE: 235 75R 15 )
NHTSA ODI #728405
Mileage unknown · Jun 22, 2000
Visibility
THIS IS A DESIGN PROBLEM RELATING TO ALL VANS WITH REAR HEATERS MANUFACTURED FROM 1991 TO THE PRESENT. THE TUBING LEADING TO THE REAR HEATER HAS RUSTED OUT ON ALL 18 OF OUR FLEET VANS. WITHOUT CLOSE INSPECTION, TUBE COULD RUST COMPLETELY THROUGH, CAUSING LOSS OF ENGINE COOLANT. THE TUBES RUN UNDER THE BODY OF THE VAN AND THROUGH…
Read full complaint
THIS IS A DESIGN PROBLEM RELATING TO ALL VANS WITH REAR HEATERS MANUFACTURED FROM 1991 TO THE PRESENT. THE TUBING LEADING TO THE REAR HEATER HAS RUSTED OUT ON ALL 18 OF OUR FLEET VANS. WITHOUT CLOSE INSPECTION, TUBE COULD RUST COMPLETELY THROUGH, CAUSING LOSS OF ENGINE COOLANT. THE TUBES RUN UNDER THE BODY OF THE VAN AND THROUGH THE REAR WHEEL WELL, WHERE THEY ARE EXPOSED TO ROAD SALT AND OTHER ENVIRONMENTAL CONDITIONS. OUR NEWEST VAN HAS ONLY 12,000 MILES AND IS ALREADY SHOWING SIGNS OF RUST.
NHTSA ODI #724369
Mileage unknown · Nov 22, 1999
Engine And Engine Cooling
ENGINE OIL PAN HAS CORRODED AND RUSTED THROUGH, CAUSING AN OIL LEAK IN THE VEHICLE. DEALER SAID OIL PAN NEEDED TO BE REPLACED. *AK
NHTSA ODI #851563
Mileage unknown · Sep 8, 1999
Structure
REAR DOOR HANDLE WILL NOT OPEN TO LET CONSUMER OUT FROM OUTSIDE. BUT LET OUT FROM INSIDE. HAD IT REPAIRED. NOW SIDE DOOR WON'T LET OUT FROM OUTSIDE, BUT LET IN FROM INSIDE. THE HANDLE IS CATCHING MECHANISM IS NOT CATCHING PROPERLY. TAKING VEHICLE BACK TO DEALER. *AK
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
THE TIRE CERTIFICATION LABELS INCORRECTLY IDENTIFY THE VEHICLE TIRE REQUIREMENTS AS P235/75R15 SL (STANDARD LOAD), RATHER THAN AS P235/75R15 XL (EXTRA LOAD).
Consequence & remedy
Consequence: THE CERTIFICATION LABELS ON THE AFFECTED VEHICLES DO NOTCOMPLY WITH FMVSS 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THANPASSENGER CARS." INCORRECT TIRE SELECTION COULD RESULT IN SUDDEN FAILURE OFA TIRE WHILE THE VEHICLE IS IN MOTION, AND RESULT IN A VEHICLE ACCIDENT.
Remedy: CORRECT TIRE INFORMATION LABELS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO THE OWNERS OF THESE VEHICLES. OWNERS WILL BE INSTRUCTED THAT DEALERS CAN INSTALL THE LABEL PROVIDED IF THEY PREFER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE96072 · Loss Of Steering Control
Opened Dec 5, 1996 · Closed Apr 29, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
1992 Ford E-150 Problems, Complaints & Recalls | Skip That Year
Illustration