TL*THE CONTACT OWNS A 1992 FORD E150. THE CONTACT STATED THAT THE WIRING HARNESS CAUSED A FIRE ON THE PASSENGER SIDE OF THE VEHICLE. THE AUTOMATIC TRANSMISSION WAS DAMAGED. THE FORD DEALER REPLACED THE SWITCH, BUT FAILED TO RECOGNIZE THAT THE WIRES WERE FAULTY. THEY STATED THAT THE SWITCH WAS ON THE DRIVER SIDE AND THE FIRE …
Read full complaint
TL*THE CONTACT OWNS A 1992 FORD E150. THE CONTACT STATED THAT THE WIRING HARNESS CAUSED A FIRE ON THE PASSENGER SIDE OF THE VEHICLE. THE AUTOMATIC TRANSMISSION WAS DAMAGED. THE FORD DEALER REPLACED THE SWITCH, BUT FAILED TO RECOGNIZE THAT THE WIRES WERE FAULTY. THEY STATED THAT THE SWITCH WAS ON THE DRIVER SIDE AND THE FIRE BEGAN ON THE PASSENGER SIDE; THEREFORE, THE SWITCH WAS UNRELATED TO THE FIRE. THE CONTACT STATED THAT THE FAULTY SWITCH THAT REACHED OVER TO THE PASSENGER SIDE WIRES EVENTUALLY LED TO THE FIRE. THE DEALER STATED THAT THEY WOULD REPAIR THE VEHICLE IF GIVEN PERMISSION BY THE MANUFACTURER. THE CONTACT CALLED THE MANUFACTURER AND THEY HUNG UP ON HIM. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 100,000. UPDATED 3/18/08 *CN THE CONSUMER STATED THEIR MECHANIC OBTAINED THE DAMAGE WIRES AND REMOVED TO AVOID FURTHER DAMAGE. THE CONSUMER FURTHER STATED THE TRANSMISSION HAD ALREADY FAILED AND COULD ONLY BE REPAIRED OR REPLACED. UPDATED 03/18/08 *TR
NHTSA ODI #10219187
93,821 miles · May 3, 2005
Power Train
LINE THAT CARRIES TRANSMISSION FLUID TO/FROM AUTOMATIC TRANSMISSION TO RADIATOR/TRANSMISSION FLUID COOLER WERE PLACED OVER A WIRE BUNDLE WRAPPED WITH A HARD RUBBER WRAP. AFTER 13 YEARS/93K MILES, THIS CONSTANT CONTACT/RUBBING BETWEEN THE WRAPPED WIRE BUNDLE AND THE AUTOMATIC TRANSMISSION FLUID LINE RESULTED IN A HOLE WEARING I…
Read full complaint
LINE THAT CARRIES TRANSMISSION FLUID TO/FROM AUTOMATIC TRANSMISSION TO RADIATOR/TRANSMISSION FLUID COOLER WERE PLACED OVER A WIRE BUNDLE WRAPPED WITH A HARD RUBBER WRAP. AFTER 13 YEARS/93K MILES, THIS CONSTANT CONTACT/RUBBING BETWEEN THE WRAPPED WIRE BUNDLE AND THE AUTOMATIC TRANSMISSION FLUID LINE RESULTED IN A HOLE WEARING IN THE ATF LINE, AND SUBSEQUENT LOSS OF TRANSMISSION FLUID. ONLY BECAUSE THIS FAILURE WAS DETECTED EARLY WAS A CATASTROPHIC LOSS OF ATF FLUID AND FAILURE OF THE TRANSMISSION AVERTED. WITHOUT EARLY DETECTION, SEVERE LOSS OF ATF FLUID WOULD OCCUR, WITH SUBSEQUENT FAILURE OF THE AUTOMATIC TRANSMISSION. THIS FAILURE COULD LEAVE THE VEHICLE IN A HAZARDOUS POSITION, SINCE IT COULD OCCUR WITHOUT WARNING.
NHTSA ODI #10119549
Mileage unknown · Jun 6, 2001
Power Train
BELL HOUSING FOR AUTOMATIC TRANSMISSION HAS CRACKED. TRANSMISSION IS SHIFTING FINE. HOWEVER, PROBLEM IS WITH TORQUE CONVERTER. CONSUMER WAS INFORMED THAT TRANSMISSION COULD DROP OUT OF VEHICLE WITH A CRACKED HOUSING. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK
NHTSA ODI #889846
Mileage unknown · Jul 28, 1997
Power TrainCrashInjury
VEHICLE WOULD NOT START. GEAR INDICATOR IN PARK POSITION, MECHANIC USED A REMOTE START SWITCH TO CRANK. UPON CRANKING, VEHICLE BEGAN TO MOVE BACKWARDS. DRIVER AND MECHANIC WERE STANDING BESIDE VEHICLE. THE OPENED DOOR KNOCKED DRIVER DOWN AND VEHICLE ROLLED OVER HER. BOTH THOUGHT THE VEHICLE WAS IN PARK.
NHTSA ODI #521931
Mileage unknown · Jan 23, 1997
Power TrainInjury
TRANSMISSION JUMPED OUT OF PARK GEAR, ACCELERATED BACKWARDS, STRIKING DRIVER AS HE WAS WALKING AWAY FROM VEHICLE.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
THE TIRE CERTIFICATION LABELS INCORRECTLY IDENTIFY THE VEHICLE TIRE REQUIREMENTS AS P235/75R15 SL (STANDARD LOAD), RATHER THAN AS P235/75R15 XL (EXTRA LOAD).
Consequence & remedy
Consequence: THE CERTIFICATION LABELS ON THE AFFECTED VEHICLES DO NOTCOMPLY WITH FMVSS 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THANPASSENGER CARS." INCORRECT TIRE SELECTION COULD RESULT IN SUDDEN FAILURE OFA TIRE WHILE THE VEHICLE IS IN MOTION, AND RESULT IN A VEHICLE ACCIDENT.
Remedy: CORRECT TIRE INFORMATION LABELS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO THE OWNERS OF THESE VEHICLES. OWNERS WILL BE INSTRUCTED THAT DEALERS CAN INSTALL THE LABEL PROVIDED IF THEY PREFER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
PE96072 · Loss Of Steering Control
Opened Dec 5, 1996 · Closed Apr 29, 1997
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA93020 · Parking Brake Failure
Opened Jul 28, 1993 · Closed Sep 23, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Additional source detail variants (2)
Service Brakes, Hydraulic
There is no summary currently available
Service Brakes, Hydraulic
There is no summary currently available
PE93015 · Parking Brake Failure
Opened Mar 9, 1993 · Closed Jul 27, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
1992 Ford E-150 Problems, Complaints & Recalls | Skip That Year
Illustration