NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
9 reportsClear category filter186,000 miles · Apr 15, 2014
Power TrainUnknown Or Other
MY NAME IS [XXX] AND MY FORD CROWN VICTORIA HAS A PROBLEM WITH THE REAR AXLE ASSEMBLY THE C-CLIP KEEPS FALLING OFF THE AXLE SHAFT AND I THINK THIS SHOULD BE A RECALL I'M NOT SURE HOW MANY OTHER PEOPLE EXPERIENCED THIS PROBLEM BUT I AM AND THE REAR END IS TOO EXPIENCIVE TO REPAIR AND I THINK THIS SHOULD BE ADMITTED TO FORD BECAUS…
Read full complaint
MY NAME IS [XXX] AND MY FORD CROWN VICTORIA HAS A PROBLEM WITH THE REAR AXLE ASSEMBLY THE C-CLIP KEEPS FALLING OFF THE AXLE SHAFT AND I THINK THIS SHOULD BE A RECALL I'M NOT SURE HOW MANY OTHER PEOPLE EXPERIENCED THIS PROBLEM BUT I AM AND THE REAR END IS TOO EXPIENCIVE TO REPAIR AND I THINK THIS SHOULD BE ADMITTED TO FORD BECAUSE THE AXLE SHAFT IS FAULTY AND THE DIFFERENTIAL 3:55 IS A BAD CONCEPT ON MY CAR I DON'T SPEED OR BEAT MY CAR DOWN OR DOG IT OUT I DRIVE THE SPEED LIMIT AND USE THE CAR AS SUPPOSED TO AND THE OTHER PROBLEM IS THE CAR HAS RANDOM MISFIRES AS WELL THE PROBLEM I INSIST OF COMPLAINING OF CAN CAUSE AN ACCIDENT OR WORSE AND I FEEL FORD SHOULD RECALL THE CAR FOR THIS MAJOR PROBLEM PLEASE CONTACT ME IF YOU CAN HAVE SOMETHING DONE ABOUT THESE PROBLEMS. 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *TT
NHTSA ODI #10582897
Mileage unknown · Sep 9, 2005
Power Train
1999 CROWN VICTORIA BECAME STUCK IN PARK.*MR *JB
NHTSA ODI #10136667
Mileage unknown · Jul 8, 2004
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
REFERENCE ODI ID 752976 - I HAD A SIMILAR EXPERIENCE AND FAILURE OF THE SAME EQUIPMENT AND PARTS DESCRIBED IN THE REFERENECED COMPLAINT. THESE ARE LATENT DESIGN/MATERIAL/MANUFACTURING DEFECTS. I WAS ORIGINALLY TOLD, UNDER WARRANTY, THAT THE SHUDDER WAS DUE TO THE TRACTION CONTROL SENSORS. THIS APPARENTLY WAS INCORRECT. NOW T…
Read full complaint
REFERENCE ODI ID 752976 - I HAD A SIMILAR EXPERIENCE AND FAILURE OF THE SAME EQUIPMENT AND PARTS DESCRIBED IN THE REFERENECED COMPLAINT. THESE ARE LATENT DESIGN/MATERIAL/MANUFACTURING DEFECTS. I WAS ORIGINALLY TOLD, UNDER WARRANTY, THAT THE SHUDDER WAS DUE TO THE TRACTION CONTROL SENSORS. THIS APPARENTLY WAS INCORRECT. NOW THAT THE VEHICLE IS JUST OVER 100,000 MI, FORD WILL DO NOTHING TO CORRECT THIS DEFECT. THE DEALER TO THEIR CREDIT IS TRYING TO CORRECT THE SHUDDER PROBLEM BY SERVICING THE TRANSMISSION WITH ADDITIVES. THE INTAKE MANIFOLD CRACKING IS A DESIGN/MATERIAL DEFECT WHICH WAS FINALLY DISCOVERED AFTER THE WARRANTY PERIOD ALTHOUGH I HAD COMPLAINED ABOUT COOLANT ODOR SEVERAL TIMES WHILE IN WARRANTY. FORD SPLIT THE DIFFERENCE WITH ME ON THE COST OF REPAIR, THEY SHOULD HAVE SHOLDERED THE ENTIRE COST. NOW WE HAVE ANOTHER PROBLEM WHICH FORD, ACCORDING TO THE SERVICE SUPERVISOR IS UNWILLING TO CORRECT. THERE IS A SERIOUS PROBLEM WITH THE BRAKE BOOSTER, IT HAS A TENDENCY TO CRACK INTERNALLY AND CAUSE A HARD PEDAL. THIS DEFECT WAS DISCOVERED ON MY WIFE'S MERCURY SABLE AT ABOUT 38,000-MI AND NOW IS BE EXHIBITED ON MY CROWN VICTORIA. CATASTROPHIC FAILURE OF THIS COMPONENT AT HIGH SPEED COULD CAUSE AN ACCIDENT, LOSS OF CONTROL IN A PANIC STOP BECAUSE THE DRIVER WOULD HAVE TO EXERT AN UNUSUAL AMOUNT OF OF PRESSURE ON THE PEDAL TO APPLY THE BRAKES AND ACTIVATE THE ABS. I WAS TOLD THAT FORD AS A GENERAL POLICY WILL NOT DO ANYTHING TO CORRECT PROBLEMS ON VEHICLES OVER 100,000 MI. THE MANUFACTURER SHOULD NOT HAVE INDEMNITY RELIEF ON SAFETY ISSUES AND LATENT DEFECTS.*AK
NHTSA ODI #10080584
Mileage unknown · Jun 7, 2002
Power Train
BETWEEN 29-49MPH TRANSMISSION WILL BUCKLE AND OR SHUTTER WITH NO WARNING. CAUSE UNKNOWN. DEALER NOTIFIED.*AK
NHTSA ODI #8011343
Mileage unknown · Oct 6, 2001
Fuel System, GasolinePower Train
HAD TO POST ON THIS BLUE OVAL NEWS WEB SITE SIMPLY BECAUSE OF THE AMOUNT OF EDUCATED CONSUMERS WHO UTILIZE BLUE OVAL NEWS RESEARCHING PRIOR TO THEIR VEHICLE PURCHASES. BESIDES THE KNOWN ISSUE OF THE DREADED PLASTIC RESIN INTAKE MANIFOLDS CRACKING ON THE 4.6L SOHC ENGINE ON THE FORD CROWN VICTORIA THERE IS A MORE CATASTROPHIC QUA…
Read full complaint
HAD TO POST ON THIS BLUE OVAL NEWS WEB SITE SIMPLY BECAUSE OF THE AMOUNT OF EDUCATED CONSUMERS WHO UTILIZE BLUE OVAL NEWS RESEARCHING PRIOR TO THEIR VEHICLE PURCHASES. BESIDES THE KNOWN ISSUE OF THE DREADED PLASTIC RESIN INTAKE MANIFOLDS CRACKING ON THE 4.6L SOHC ENGINE ON THE FORD CROWN VICTORIA THERE IS A MORE CATASTROPHIC QUALITY ISSUE WITH THE CROWN VICTORIA AND THAT IS THE TORQUE CONVERTER SHUDDER ON THE CROWN VICTORIA 4R70W TRANSMISSION. STARTING WITH THE '92 MODEL YEAR AND IT'S AODE AND NOW THE 4R70W WHICH REPLACED THE AODE STARTING IN '98 FORD HAS KNOWN OF QUALITY ISSUES OF THEIR TRANSMISSIONS WHICH MANIFESTS ITSELF AS A HORRIBLE SHUDDER OR VIBRATION AS THE TRANSMISSION SHIFTS FROM 3RD GEAR GOING INTO 4TH GEAR (USUALLY TRANSITIONING FROM 40 TO 50 MPH!). I PURCHASED MY '99 CROWN VIC AND IT HAS PROVIDED ME RELIABLE TRANSPORTATION UNTIL JUST RECENTLY. I PICKED UP THIS HORRIBLE SHUDDER JUST 6 WEEKS PRIOR TO MY 3YR/36K FORD WARRANTY RUNNING OUT. WHEN THIS PROBLEM FIRST OCCURRED WITH HAVING JUST 22K ON THE ODOMETER AND 6 WEEKS LEFT ON THE WARRANTY I QUICKLY BROUGHT THE CAR IN FOR WARANTY WORK. UNIVERSAL FORD IN LONG ISLAND CITY, NY VALIDATED THAT INDEED THERE WAS A SHUDDER AND REPLACED THE TRANSMISSION WITH A REBUILT TRANSMISSION. I DROVE THE "REPAIRED" VEHICLE FROM NYC TO LEESBURG, VIRGINIA BUT ON THE RETURN TRIP THE SHUDDER CAME BACK WORSE THAN EVER. I MANAGED TO LIMP THE CAR BACK HOME AND THE VEHICLE HAS BEEN AT UNIVERSAL FORD SINCE. FOR THOSE OF YOU CONSIDERING A CROWN VICTORIA PERFORM YOUR "DUE DILIGENCE" AND VISIT SOME OF THE OTHER IMPARTIAL CROWN VIC WEB SITES (WWW.CORRAL.NET BUT MORE IMPORTANTLY WWW.CROWNVIC.NET) SEARCHING ON "TRANNY SHUDDER". FORD HAS KNOWN OF THIS PROBLEM OVER 5 YEARS BUT HASN'T PUBLICALLY MADE IT WIDELY KNOWN ALONG WITH THEIR PLASTIC RESIN INTAKE MANIFOLD DEBACLE. I'VE OWNED OVER A DOZEN CROWN VICTORIAS IN MY LIFE AND STARTING WITH THE '92 MODEL YEAR WHEN THEY TRANSITIONED OVER FROM THE OLD PUSHROD-8 5.0L ENGINE TO THEIR NEW 4.6L SOHC T
NHTSA ODI #752976
Mileage unknown · Feb 16, 2001
Engine And Engine CoolingPower TrainVehicle Speed Control
WHILE DRIVING LOST ALL ENGINE POWER, BUT ENGINE NEVER STALLED. WHEN STEPPING ON GAS PEDAL NOTHING HAPPENED. IT HAPPENED BEFORE ON A INCLINE HILL, AND COULD NOT HOLD VEHICLE FROM ROLLING BACK. THEN, TOOK VEHICLE TO DEALER, AND THEY DID NOT FIND ANYTHING. CONSUMER BELIEVED PROBLEM WAS TRACTION CONTROL. *AK
NHTSA ODI #880745
Mileage unknown · Jun 20, 2000
Power Train
DRIVELINE OF THE VEHICLE HAS FAILED, UNABLE TO DETERMINE CAUSE OF PROBLEM
NHTSA ODI #552714
Mileage unknown · Apr 3, 2000
Power Train
WHEN THE VEHICLE IS PLACED IN PARK INDICATOR READS PARK, BUT THE VEHICLE WILL JUMP BACK INTO GEAR AND START TO ROLL. DEALER HAS NOT BEEN CONTACTED. *AK
NHTSA ODI #859579
Mileage unknown · Apr 15, 1999
Power Train
VEHICLE IS A POLICE PACKAGE CROWN VICTORIA USED FOR PARAMEDIC SERVICE. WE BEGAN TO NOTICE THE VEHICLE SWAY SUBTLY WITH BRAKING, ACCELERATION, AND ROAD IMPERFECTIONS IN JAN 1999. IN MARCH, THE REAR AXLE BEGAN TO MAKE A LOUD BANGING NOISE UPON MODERATE ACCELERATION FROM A STOP. IT WAS TAKEN TO CHAPMAN LINCOLN-MERCURY, BALTIMORE PI…
Read full complaint
VEHICLE IS A POLICE PACKAGE CROWN VICTORIA USED FOR PARAMEDIC SERVICE. WE BEGAN TO NOTICE THE VEHICLE SWAY SUBTLY WITH BRAKING, ACCELERATION, AND ROAD IMPERFECTIONS IN JAN 1999. IN MARCH, THE REAR AXLE BEGAN TO MAKE A LOUD BANGING NOISE UPON MODERATE ACCELERATION FROM A STOP. IT WAS TAKEN TO CHAPMAN LINCOLN-MERCURY, BALTIMORE PIKE, SPRINGFIELD, PA 19064 (610-544-0100), WHERE THE DIAGNOSIS OF A LOOSE/MISSING PASSENGER SIDE REAR TRAILING ARM WAS MADE. APPARENTLY, A BOLT HAD WORKED LOOSE, AND THAT SIDE OF THE AXLE WAS BASICALLY HELD IN PLACE BY THE SHOCK ABSORBER AND LEAF SPRING. OBVIOUSLY, THIS WOULD ADVERSELY AFFECT THE HIGH SPEED HANDLING OF THE VEHICLE, OR EVEN CAUSE THE AXLE TO BREAK COMPLETELY FREE, WITH POTENTIALLY FATAL IMPLICATIONS. I WOULD APPRECIATE BEING INFORMED OF THE OUTCOME OF THIS, PREFERABLY VIA E-MAIL. THANKS.
NHTSA ODI #705645
Official recalls
5Nov 6, 2003
ON CERTAIN NATURAL GAS VEHICLES, IF A FLAME FROM A VEHICLE INTERIOR FIRE BECOMES LOCALLY DIRECTED AT THE NATURAL GAS FUEL TANK LOCATED IMMEDIATELY BEHIND THE REAR SEAT, THE FLAME COULD DAMAGE THE FIBERGLASS WRAP ON THE TANK WEAKENING THE TANK.
Consequence & remedy
Consequence: IF THE STRENGTH OF THE TANK IS SIGNIFICANTLY COMPROMISED, IT COULD RUPTURE, INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSTALL AN INSULATOR BEHIND THE CURRENT SEAT BACK. OWNER NOTIFICATION BEGAN ON JANUARY 7, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Jul 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES HAVE JACKING INSTRUCTIONS WHICH, IF FOLLOWED, COULD CAUSE THE VEHICLE OPERATOR TO PLACE THE JACK ON A FRAME WELD WHEN ATTEMPTING TO RAISE A REAR WHEEL. IF THE VEHICLE IS JACKED UP WITH THE JACK PLACED ON THE FRAME WELD AND IF THE VEHICLE IS FREE TO ROLL (WHEELS NOT BLOCKED OR CHOCKED), THE JACK COULD YIELD AND THE VEHICLE MAY DROP SUDDENLY.
Consequence & remedy
Consequence: IF THIS OCCURS AND ANY PORTION OF THE OPERATOR'S BODY IS UNDER THE VEHICLE, THE POTENTIAL FOR PERSONAL INJURY EXISTS.
Remedy: OWNERS WILL BE PROVIDED WITH A REVISED JACK INSTRUCTION AND STOWAGE CARD AND JACK WARNING LABEL, AS WELL AS A SUPPLEMENT TO THE OWNER GUIDE.
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET DRIVER'S SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
Jun 12, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES USING AFTERMARKET FRONT PASSENGER SIDE SEAT BELT ASSEMBLIES THAT WERE SOLD BY FORD PARTS DEPARTMENTS FROM JANUARY 1, THROUGH JUNE 13, 2000. THESE SEAT BELT ASSEMBLIES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 209, "SEAT BELT ASSEMBLIES." THE EQUIPMENT INVOLVED IS SERVICE STOCK SEAT BELT ASSEMBLIES, MODEL NOS. H 9977, H 9979, T 9063, AND T 9217, BUILT BY TRW VEHICLE SAFETY SYSTEMS, INC. (TRW) MANUFACTURED FROM JUNE 1, 1998 THROUGH MAY 21, 2000. SOME OF THESE SEAT BELT ASSEMBLIES MAY HAVE BEEN INSTALLED AS SERVICE REPLACEMENT EQUIPMENT ON THE VEHICLES INVOLVED IN THE RECALL.
Consequence & remedy
Consequence: IN THE EVENT OF A COLLISION, THESE SEAT BELTS MAY NOT RESTRAIN AN OCCUPANT INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THESE VEHICLES AND REPLACE THE SERVICE SEAT BELT ASSEMBLIES THAT WERE INSTALLED IN THESE VEHICLES FROM JANUARY 1 THROUGH JUNE 13, 2000.
Dec 16, 1998
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
EA03001 · Cng Tank Explosion
Opened Jan 27, 2003 · Closed Nov 19, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
IN SEPTEMBER 2002, A FUEL CYLINDER IN A NATURAL GAS POWERED VEHICLE (NGV) EXPLODED DURING A FIRE.FORD AND VRTC TEST ENGINEERS JOINTLY EXAMINED THE INCIDENT VEHICLE AND REVIEWED TESTING TO DETERMINE WHETHER THE PERFORMANCE OF THE PRESSURE RELIEF VALVE (PRD) WAS PROPER.THE PURPOSE OF A PRD IS TO PROTECT A COMPRESSED NATURAL GAS TANK FROM OVERPRESSURE BY ALLOWING THE CNG TO VENT WHEN THE TEMPERATURE REACHES A SPECIFIC POINT.THE PRD WAS REMOVED FROM THE FAILED TANK AND SUBJECTED TO A YIELD TEMPERATURE DETERMINATION TEST. IT WAS CONCLUDED THAT A DIRECT FLAME (FROM THE INTERIOR OF THE VEHICLE) ONTO THE CYLINDER (LOCATED BEHIND THE REAR SEAT IN THE TRUNK)COMPROMISED THE HOOP STRENGTH OF THE NATURAL GAS CYLINDER, THUS ALLOWING THE CYLINDER TO FAIL PRIOR TO THE PRD RELEASING AT ITSDESIGNED TEMPERATURE.AS A RESULT OF THIS TESTING AND REVIEW OF THE INVOLVED VEHICLE, FORD HAS DEVELOPED AN INSULATOR TO INSULATE THE NATURAL GAS FUEL TANK FROM A LOCALLY DIRECTED FLAME PROJECTING FROM THE INTERIOR OF THE VEHICLE.INSULATORS WILL BE INSTALLED BEHIND THE BACK SEAT ON SUBJECT VEHICLES TO PREVENT FUTURE FAILURES OF THIS TYPE. FORD'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
PE02071 · Cng Tank Exploding In A Fire
Opened Oct 1, 2002 · Closed Jan 27, 2003
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly
AN EXPLOSION OF A COMPRESSED NATURAL GAS (CNG) TANK SHOULD NOT BE ABLE TO OCCUR, AS THE TANK IS FITTED WITH A PRESSURE RELIEF DEVICE (PRD). THIS PRD SHOULD RELEASE THE CNG IN THE TANK, PRIOR TO THE PRESSURE REACHING THE TANK BURST PRESSURE.THE PRD DID NOT RELEASE IN THE SUBJECT WISCONSIN POLICE CRUISER EXPLOSION.NHTSA HAS RECOVERED THE PRD VALVE FROM THE TANK THAT EXPLODED AND TESTING WILL BE NECESSARY TO ESTABLISH WHY THIS TANK SAFETY VALVE DID NOT RELEASE IN THE VERY HIGH TEMPERATURE FIRE THAT OCCURRED IN THE POLICE CRUISER.THERE IS ONLY THE SINGLE KNOWN EVENT, BUT DUE TO THE CATASTROPIC FORCE OF SUCH AN EXPLOSION AND THE POTENTIAL FOR INJURY AND LOSS OF LIFE, THIS INVESTIGATION IS BEING UPGRADED.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
PE00043 · Rear Axle Trailing Arm Frame Mounting
Opened Oct 20, 2000 · Closed Feb 2, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99047 · Blow Back During Refueling
Opened Jul 12, 1999 · Closed Sep 23, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration